air filter NISSAN X-TRAIL 2001 Service Manual PDF

MA-34
ENGINE MAINTENANCE (YD22DDTI)
4. Remove the O-ring from the filter body.
●Push the O-ring in one direction, lift the slack part using fin-
gers, and remove the O-ring from the filter body.
CAUTION:
Do not use wires or flat-bladed screwdrivers etc. as they
may cause damage to the filter body.
INSTALLATION
1. Completely remove all foreign objects adhering to the inside of the filter body or O-ring mounting area
(body side and bracket side).
2. Install the oil filter and O-ring to the filter body.
●Push the oil filter into the filter body completely.
3. Install the filter body to the oil filter bracket.
4. After warming up the engine, check for engine oil leakage.
5. Check engine oil level and add engine oil. Refer to LU-18, "
ENGINE OIL" .
Draining WaterELS000CJ
1. Prepare a tray at the drain hose open end.
2. Loosen drain cock, and operate priming pump to drain water
from fuel filter.
CAUTION:
●Water in filter is drained with fuel. Prepare larger capacity
pan than fuel filter volume.
●Drained water is mixed with fuel. Prevent fuel from adher-
ing to rubber parts such as engine mount insulator.
3. After draining, close drain cock by hand.
CAUTION:
If drain cock is tightened excessively, it may be damaged
and fuel will leak. Do not use tools to tighten drain cock.
4. Bleed air in fuel piping. Refer to FL-16, "
Air Bleeding" .
5. Start engine and check fuel leakage.
JLC292B
Oil filter:
: 20 - 24 N·m (2.0 - 2.5 Kg-m, 15 - 18 ft-lb)
SBIA0138E

SERVICE DATA AND SPECIFICATIONS (SDS)
MA-43
C
D
E
F
G
H
I
J
K
MA
B
MA
SERVICE DATA AND SPECIFICATIONS (SDS)PFP:00030
Standard and LimitELS000K3
BELT DEFLECTION AND TENSION
QR20DE and QR25DE
YD22DDTi
*: When engine is cold.
RADIATOR
Unit: kPa (bar, kg/cm2 , psi)
ENGINE COOLANT CAPACITY
QR20DE and QR25DE
Unit: (lmp qt)
YD22DDTi
Unit: (lmp qt)
ENGINE OIL CAPACITY
QR20DE and QR25DE
Unit: (lmp qt)
YD22DDTi
Unit: (lmp qt)
SPARK PLUG
QR20DE and QR25DE
Tensions of drive belts Auto-adjustment by auto-tensioner
Applied beltBelt deflection with 98 N (10 kg, 22 lb) force applied* mm (in)
New Adjusted Limit for re-adjusting
Air conditioner compressor belt 4 - 5 (0.16 - 0.20) 6 - 7 (0.24 - 0.28) 8.5 (0.335)
Alternator and water pump belt 9.0 - 10.5 (0.354 - 0.413) 11.0 - 12.5 (0.433 - 0.492) 16.5 (0.650)
Cap relief pressureStandard 78 - 98 (0.78 - 0.98, 0.8 - 1.0, 11 - 14)
Limit 59 (0.59, 0.6, 9)
Leakage test pressure 157 (1.57, 1.6, 23)
Coolant capacity (With reservoir tank at MAX level) 7.1 (6-1/4)
Reservoir tank coolant capacity (At MAX level) 0.6 (1/2)
Coolant capacity (With reservoir tank at MAX level) 9.5 (8-3/8)
Reservoir tank coolant capacity (At MAX level) 0.6 (1/2)
Drain and refill With oil filter change Approximately 3.9 (3-3/8)
Without oil filter change Approximately 3.5 (3-1/8)
Dry engine (Overhaul)Approximately 4.5 (4)
Drain and refill With oil filter change Approximately 5.2 (4-5/8)
Without oil filter change Approximately 4.9 (4-3/8)
Dry engine (Overhaul)Approximately 6.3 (5-1/2)
MakeNGK
Standard typeLFR5A-11
Hot typeLFR4A-11
Cold typeLFR6A-11
Spark plug gap mm(in) 1.0 - 1.1 (0.039 - 0.043)

IDX-2
ALPHABETICAL INDEX
Numerics
4WD mode switch ................................... TF-54
,TF-57
4WD shift indicator lamp .................................... TF-55
4WD solenoid valve ................................ TF-49,TF-52
4WD warning lamp TF-40,TF-55,TF-56,TF-57,TF-58
A
A/C air flow ......................................... ATC-31
,MTC-5
A/C component layout ..................................... ATC-23
A/C compressor clutch removal and installation ...........
ATC-135
A/C compressor precaution ............................... ATC-9
A/C compressor special service tool ................ ATC-14
A/C diagnostic work flow (auto A/C) ................ ATC-33
A/C HFC134a (R134a) system precaution ........ ATC-4
A/C HFC134a (R134a) system service procedure .......
ATC-129
A/C HFC134a (R134a) system service tools ... ATC-15
A/C HFC134a system service equipment precaution ...
ATC-10
A/C lubricant (R134a) ...................................... ATC-24
A/C operational check ......................... ATC-54,MTC-7
A/C performance test diagnoses ..................... ATC-88
A/C reray .......................................................... ATC-84
A/C self-diagnoses (auto A/C) ......................... ATC-46
A/C system description (auto A/C) ................... ATC-27
A/C trouble diagnoses (auto A/C) ....... ATC-33,MTC-3
A/C, A - Wiring diagram ................................... ATC-38
A/CCUT - Wiring diagram .............................. EC-1572
A/T - Wiring diagram - AT - FTS ...................... AT-118
A/T - Wiring diagram - AT - MAIN .................... AT-350
A/T - Wiring diagram - AT - PNP/SW ............... AT-112
A/T - Wiring diagram - AT - VSS A/T . AT-124,AT-355
A/T fluid checking .................................. AT-13,MA-36
A/T fluid replacement ............................. AT-13,MA-36
A/T fluid temperature sensor ........................... AT-121
A/T IND - Wiring diagram .................................... DI-57
A/T indicator ........................................................ DI-57
A/T shift lock system ........................................ AT-406
A/T shift lock system - Wiring diagram ............ AT-407
A/T trouble diagnoses .......................... AT-56,AT-258
A/T Wiring diagram - AT - ENG SS ... AT-128,AT-393
A/T Wiring diagram AT - 1ST ........................... AT-134
A/T Wiring diagram AT - 2ND .......................... AT-140
A/T Wiring diagram AT - 3RD .......................... AT-146
A/T Wiring diagram AT - 4TH .......................... AT-152
A/T Wiring diagram AT - BA/FTS ....... AT-195,AT-388
A/T Wiring diagram AT - CAN ............ AT-191,AT-404
A/T Wiring diagram AT - LPSV .......... AT-165,AT-398
A/T Wiring diagram AT - OVRCSV .... AT-187,AT-378
A/T Wiring diagram AT - SSV/A ......... AT-172,AT-369
A/T Wiring diagram AT - SSV/B ......... AT-177,AT-374
A/T Wiring diagram AT - TCV ............ AT-160,AT-383
A/T Wiring diagram AT - TPS ............ AT-182,AT-364
A/T Wiring diagrawm AT - VSSMTR .. AT-201,AT-360
ABS - Wiring diagram ..................................... BRC-12
Absolute pressure sensor .............................. EC-1494
Accelerator control system ............................... ACC-2
Accelerator pedal position (APP) sensor ........ EC-355,
EC-361
,EC-373,EC-631,EC-637,EC-651,EC-893,
EC-1222
,EC-1460
Accelerator pedal released position learning . EC-1404
Accelerator pedal released position switch .... EC-1531
Actuator relay ..................................................... TF-52
Aiming adjustment ............................................... LT-4
Air bag .............................................................. SRS-3
Air bag disposal .............................................. SRS-41
Air bleeding (hydraulic clutch) .............................. CL-8
Air bleeding for brake system ............................ BR-10
Air cleaner and air duct(QR20DE•QR25DE) .... EM-14
Air cleaner and air duct(YD22DDTi) ............... EM-120
Air cleaner filter replacement(QR20DE•QR25DE) ........
MA-22
Air cleaner filter replacement(YD22DDTi) ......... MA-32
Air cleaner filter(QR20DE•QR25DE) ................ EM-14
Air cleaner filter(YD22DDTi) ........................... EM-120
Air conditioner cut control .... EC-36,EC-446,EC-768,
EC-1132
,EC-1401
Air flow meter - See Mass air flow sensor ....... EC-138,
EC-516
,EC-870,EC-999,EC-1202
Air mix door control linkage adjustment ......... ATC-66,
ATC-125
,MTC-10,MTC-28
Air mix. door motor ......................... ATC-64,ATC-125
Air spoiler, rear ................................................... EI-21
Alternator ........................................................... SC-12
Ambient sensor ............. ATC-100,ATC-102,ATC-112
Angular tightening application(QR20DE•QR25DE) ......
EM-5
Angular tightening application(YD22DDTi) ..... EM-110
Antenna - See Power antenna ........................... AV-16
APPS - Wiring diagram ... EC-895,EC-1225,EC-1462
APPS1 - Wiring diagram ................... EC-357,EC-633
APPS2 - Wiring diagram ................... EC-363,EC-640
APPS3 - Wiring diagram ................... EC-375,EC-653
APRSW - Wiring diagram .............................. EC-1533
Audio .................................................................... AV-3
Auto air conditioner - Wiring diagram ............. ATC-38
Automatic amplifier ........................... ATC-44,ATC-57
Automatic transmission fluid replacement ....... MA-35,
MA-37
Axle ................................................................... MA-41
B
Back door ........................................................... BL-71
Back door trim ..................................................... EI-25
Back door window .............................................. GW-8
Back window ...................................................... GW-8
BACK/L - Wiring diagram ................................... LT-28
Back-up lamp .......................................... LT-28,LT-42
Back-up lamp switch (M/T) ............................... MT-12
Basic inspection ... EC-73,EC-465,EC-805,EC-1152,
EC-1412
Battery ................................................................. SC-3
Baulk ring (M/T) .................................... MT-18,MT-23
Blower motor ..... ATC-70,ATC-77,ATC-118,MTC-14,

IDX-4
ALPHABETICAL INDEX
Cylinder head bolt tightening(YD22DDTi) ....... EM-184
Cylinder head gasket selection(YD22DDTi) ... EM-185
Cylinder head(QR20DE•QR25DE) ................... EM-59
Cylinder head(YD22DDTi) .............................. EM-182
D
Data link connector .......... EC-424
,EC-745,EC-1111,
EC-1385
Data link connector for Consult ........... EC-96,EC-488,
EC-827
,EC-1174,EC-1431
Daytime light system ............................................. LT-9
Daytime running light - See Daytime light system LT-9
DEF - Wiring diagram ....................................... GW-15
Desiccant Assembly ....................... ATC-30,ATC-146
Diagnosis sensor unit ..................................... SRS-40
Diagnostic trouble code (DTC) ...................... EC-1406
Diagnostic trouble code (DTC) for OBD system EC-20,
EC-47
,EC-432,EC-454,EC-753,EC-779,EC-1119,
EC-1141
,EC-1393
Diagnostic trouble code (DTC) inspection priority chart
EC-70
,EC-463,EC-802,EC-1150
Differential gear (FF M/T) ..................... MT-21,MT-26
DLC - Wiring diagram ...... EC-424,EC-745,EC-1111,
EC-1385
Door glass ........................................... GW-44,GW-46
Door glass Fitting Adjustment ............. GW-44,GW-46
Door lock ................................................. BL-65,BL-68
Door mirror ........................................................ GW-49
Door trim ............................................................. EI-23
Door, front ............................................................ BL-8
Door, rear ............................................................. BL-8
Drive belt inspection(QR20DE•QR25DE) ......... MA-19
Drive belt inspection(YD22DDTi) ...................... MA-26
Drive belt(QR20DE•QR25DE) .......................... EM-12
Drive belt(YD22DDTi) ..................................... EM-118
Drive shaft (front) ............................................. FAX-11
Drive shaft (rear) ............................................... RAX-9
Driver air bag .................................................. SRS-29
Dropping resistor (A/T) ...................... AT-169,AT-402
DTC work support .............................. EC-103,EC-834
DTRL - Wiring diagram ......................................... LT-9
Dual pressure switch ........ ATC-18,ATC-85,ATC-143
Duct and grilles ............................... ATC-127,MTC-29
E
ECM input/output signal ....... EC-87
,EC-479,EC-819,
EC-1166
ECM power supply EC-116,EC-267,EC-507,EC-580,
EC-848
,EC-995,EC-1193,EC-1269,EC-1442
ECM relay ...................................................... EC-1538
ECM/PW - Wiring diagram . EC-268,EC-581,EC-996,
EC-1270
ECMRLY - Wiring diagram ............................ EC-1539
ECTS - Wiring diagram ...... EC-151,EC-525,EC-883,
EC-1211
,EC-1457
EDU - Wiring diagram .................................... EC-1503
EGR function ................................................. EC-1551
EGR volume control valve ............................. EC-1551
EGRC/V - Wiring diagram .............................. EC-1553
Electric sunroof .................................................... RF-3
Electric throttle control actuator ....... EC-276,EC-278,
EC-584
,EC-586,EC-1010,EC-1012,EC-1273,
EC-1275
Electrical unit .................................................... PG-71
Electrical units location ..................................... PG-63
Electronic drive unit (EDU) ............................ EC-1501
Electronic fuel injection pump(YD22DDTi) ...... EM-147
Electronic ignition (EI) system EC-35,EC-445,EC-768,
EC-1132
Engine control circuit diagram EC-85,EC-477,EC-817,
EC-1164
,EC-1423
Engine control component parts location .......... EC-81,
EC-473
,EC-813,EC-1160
Engine control module (ECM) .......... EC-260,EC-573,
EC-988
,EC-1262,EC-1536
Engine control system diagram and chart ........ EC-31,
EC-441
,EC-763,EC-1127,EC-1398
Engine coolant temperature sensor (ECTS) ... EC-149,
EC-523
,EC-881,EC-1209,EC-1456
Engine coolant(QR20DE•QR25DE) .................... CO-9
Engine coolant(YD22DDTi) .............................. CO-29
Engine fail-safe system ........ EC-71,EC-464,EC-803,
EC-1151
Engine oil filter replacement(QR20DE•QR25DE) .........
MA-23
Engine oil filter replacement(YD22DDTi) .......... MA-33
Engine oil precautions .......................................... GI-7
Engine oil replacement(QR20DE•QR25DE) ..... MA-23
Engine oil replacement(YD22DDTi) .................. MA-32
Engine oil(QR20DE•QR25DE) ............................. LU-7
Engine oil(YD22DDTi) ....................................... LU-18
Engine removal(QR20DE•QR25DE) ................ EM-69
Engine removal(YD22DDTi) ........................... EM-193
ETC1 - Wiring diagram ..................... EC-280,EC-588
ETC2 - Wiring diagram ..................... EC-287,EC-595
ETC3 - Wiring diagram ..................... EC-292,EC-600
EVAP canister purge volume control solenoid valve ....
EC-244
,EC-425,EC-692,EC-746,EC-972,EC-1112,
EC-1340
,EC-1388
EVAP vapor lines inspection(QR20DE•QR25DE) ........
MA-25
Evaporative emission (EVAP) system EC-425,EC-746,
EC-1112
,EC-1386
Evaporator .................................................... ATC-145
Exhaust manifold(QR20DE•QR25DE) .............. EM-24
Exhaust manifold(YD22DDTi) ......................... EM-127
Exhaust system ................................................... EX-2
Exhaust system inspection ..................... EX-2,MA-35
Expansion valve ............................................ ATC-146
Exterior EI-13,EI-14,EI-16,EI-17,EI-18,EI-19,EI-21,
EI-22
F
F/FOG - Wiring diagram ......................... LT-33
,LT-34
F/PUMP - Wiring diagram EC-407,EC-728,EC-1094,

IDX-5
A
C
D
E
F
G
H
I
J
K
L B
IDX
ALPHABETICAL INDEX
EC-1368
Fan control amp. ............................. ATC-74,ATC-120
Fan switch ........................................ ATC-30,MTC-17
FIAR - Wiring diagram ................................... EC-1526
Final drive (FF M/T) .............................. MT-21,MT-26
Final drive disassembly ................................... RFD-11
Final drive removal and installation ................. RFD-11
Finisher, interior - See Trim ...................... EI-23,EI-25
Finisher, rear panel .............................................. EI-22
Floor trim ............................................................. EI-28
Flow charts ......................................................... GI-23
Fluid temperature sensor (A/T) ........................ AT-121
Fluorescent leak detector .............................. ATC-147
Flywheel (clutch) ................................................ CL-15
Flywheel runout(QR20DE•QR25DE) ................. EM-97
Flywheel runout(YD22DDTi) ............................ EM-218
Fog lamp, front ................................................... LT-33
Fork rod (M/T) ....................................... MT-20,MT-25
Freeze frame data EC-48,EC-455,EC-780,EC-1142
FRO2 - Wiring diagram .................... EC-672,EC-1321
FRO2/H - Wiring diagram ................ EC-658,EC-1308
Front bumper ......................................................... EI-6
Front disc brake ................................................. BR-21
Front door ............................................................. BL-8
Front Door Trim ................................................... EI-23
Front fog lamp .................................................... LT-33
Front passenger air bag .................................. SRS-35
Front seat ............................................................ SE-7
Front seat belt ...................................................... SB-3
Front seat belt pre-tensioner .... SB-2,SRS-3,SRS-39
Front side air bag ............................................. SRS-36
Front suspension ............................................... FSU-5
Front washer ...................................................... WW-4
Front wiper ......................................................... WW-4
FTS - Wiring diagram .................................... EC-1497
Fuel check valve ................ EC-425,EC-746,EC-1112
Fuel cut control (at no load high engine speed) EC-37,
EC-447
,EC-769,EC-1133,EC-1401
Fuel filler lid ........................................................ BL-75
Fuel filter ........................................................ EC-1404
Fuel filter replacement(QR20DE•QR25DE) .......... FL-4
Fuel filter replacement(YD22DDTi) ....... FL-15,MA-31
Fuel gauge .................................................. DI-4,DI-24
Fuel injection control system ......................... EC-1399
Fuel injection system .......... EC-200,EC-206,EC-934,
EC-940
Fuel injector ................................................... EC-1472
Fuel injector adjustment resistor .................... EC-1525
Fuel injector and fuel tube(QR20DE•QR25DE) . EM-32
Fuel injector and fuel tube(YD22DDTi) ............ EM-144
Fuel leak ........................................................ EC-1529
Fuel line inspection(QR20DE•QR25DE) . FL-3,MA-22
Fuel line inspection(YD22DDTi) ............ FL-14,MA-30
Fuel pressure check EC-42,EC-452,EC-775,EC-1139
Fuel pressure release ........... EC-42,EC-452,EC-775,
EC-1139
Fuel pressure relief valve .............................. EC-1405
Fuel pump ......... EC-405,EC-726,EC-1092,EC-1366
Fuel pump and gauge(QR20DE•QR25DE) .......... FL-4
Fuel system(QR20DE•QR25DE) .......................... FL-3
Fuel system(YD22DDTi) ..................................... FL-14
Fuel tank(QR20DE•QR25DE) ............................... FL-9
Fuel tank(YD22DDTi) ......................................... FL-21
Fuel temperature sensor ................................ EC-1496
Fuse ................................................................... PG-12
Fuse and fusible link box ................................... PG-75
Fusible link ......................................................... PG-12
G
Gear components (M/T) ........................ MT-18
,MT-23
Generator ........................................................... SC-12
Generator - See Alternator ................................ SC-12
Generic scan tool (GST) .................... EC-104,EC-836
Glass ................................................... GW-44,GW-46
GLOW - Wiring diagram ................................ EC-1545
Glow plug ....................................................... EC-1544
Glow plug(YD22DDTi) .................................... EM-138
Glow relay ...................................................... EC-1544
Grille - See Exterior ............................................ EI-11
Ground distribution ............................................ PG-13
G-sensor ............................................................ TF-50
H
H/AIM - Wiring diagram ...................................... LT-15
H/LAMP - Wiring diagram ........................... LT-4,LT-5
H/MIRROR - Wiring diagram ............................ GW-15
Harness connector ............................................. PG-68
Harness layout ................................................... PG-29
Headlamp ............................................................. LT-4
Headlamp aiming control .................................... LT-15
Headlamp leveler - See Headlamp aiming control .......
LT-15
Headlamp washer ............................................ WW-19
Headlining - See Roof trim .................................. EI-29
Heated oxygen sensor 1 .... EC-163,EC-169,EC-178,
EC-295
,EC-301,EC-534,EC-671,EC-899,EC-905,
EC-914
,EC-1023,EC-1029,EC-1229,EC-1320
Heated oxygen sensor 1 heater ........ EC-128,EC-657,
EC-860
,EC-1307
Heated oxygen sensor 2 .... EC-185,EC-192,EC-307,
EC-315
,EC-677,EC-921,EC-927,EC-1035,EC-1042,
EC-1326
Heated oxygen sensor 2 heater ........ EC-133,EC-662,
EC-865
,EC-1312
Heated seat ............................................... SE-3,SE-5
HEATER - Wiring diagram ................................ MTC-6
Heater and cooling unit (Heater core) ............ ATC-122
Heater mirror ..................................................... GW-15
Heater system - Wiring diagram ....................... MTC-6
Heater unit (heater core) .. ATC-126,MTC-24,MTC-26
HFC134a (R134a) system precaution ............... ATC-4
HFC134a (R134a) system service procedure ATC-129
HFC134a (R134a) system service tools .......... ATC-15
HFC134a system service equipment precaution ..........
ATC-10
HO2S1 - Wiring diaram ...... EC-130,EC-165,EC-172,

IDX-7
A
C
D
E
F
G
H
I
J
K
L B
IDX
ALPHABETICAL INDEX
Molding - See Exterior ................... EI-14,EI-16,EI-17
Mud guard - See Exterior .................................... EI-16
MULTI - Wiring diagram ..................................... BL-57
Multiport fuel injection (MFI) system ... EC-33,EC-443,
EC-765
,EC-1129
Multiport fuel injection precautions ....................... GI-6
Multi-remote control system ............................... BL-55
N
NATS - Wiring diagram ....................................... BL-83
NATS (Nissan anti-theft system) ........................ BL-80
NATS (Nissan anti-theft system) precautions ....... GI-3
NVH troubleshooting (BR) ......................... BR-5,PB-2
NVH troubleshooting (CL) ................................... CL-4
NVH troubleshooting (EM)(QR20DE•QR25DE) EM-10
NVH troubleshooting (EM)(YD22DDTi) ........... EM-116
NVH troubleshooting (M/T) .................................. MT-7
NVH troubleshooting (PR) ................................. FAX-6
NVH troubleshooting (RA) ................................. RAX-5
NVH troubleshooting (RAX) ............................... RAX-5
NVH troubleshooting (RSU) ............................. RSU-4
NVH troubleshooting (Transfer) ............................ TF-7
O
Oil cooler (engine)(QR20DE•QR25DE) ............. LU-13
Oil cooler (engine)(YD22DDTi) .......................... LU-25
Oil filter(QR20DE•QR25DE) ................................ LU-9
Oil filter(YD22DDTi) ........................................... LU-20
Oil pan (engine)(QR20DE•QR25DE) ................. EM-26
Oil pan (engine)(YD22DDTi) ........................... EM-133
Oil pressure (engine)(QR20DE•QR25DE) ........... LU-7
Oil pressure (engine)(YD22DDTi) ..................... LU-18
Oil pump (engine)(QR20DE•QR25DE) .............. LU-10
Oil pump (engine)(YD22DDTi) .......................... LU-23
Oil pump regulator valve (engine)(QR20DE•QR25DE)
LU-11
Oil pump regulator valve (engine)(YD22DDTi) .. LU-24
Oil seal replacement (engine)(QR20DE•QR25DE) ......
EM-37
,EM-59,EM-73
On board diagnostic system . EC-44,EC-454,EC-777,
EC-1141
Operating cylinder (clutch) ................................. CL-11
Out side mirror .................................................. GW-49
Overdrive control switch ..................... AT-246,AT-349
Overheat ........................................................ EC-1508
Oversize piston(QR20DE•QR25DE) ................. EM-93
Oversize piston(YD22DDTi) ............................ EM-214
P
Park/Neutral position switch ............. EC-345
,EC-705,
EC-1064
,EC-1353,EC-1562
Park/neutral position switch (A/T) .................... AT-110
Park/neutral position switch (M/T) ..................... MT-12
PCV (positive crankcase ventilation) EC-428,EC-749,
EC-1115
,EC-1389
PGC/V - Wiring diagram .................... EC-246,EC-974
PHASE - Wiring diagram ... EC-235,EC-559,EC-964,
EC-1248
Pilot bushing replacement - See Pilot
converter(QR20DE•QR25DE) .......................... EM-73
Piston assembly(QR20DE•QR25DE) ............... EM-93
Piston pin inspection(QR20DE•QR25DE) ........ EM-89
Piston pin inspection(YD22DDTi) ................... EM-206
Piston ring inspection(QR20DE•QR25DE) ....... EM-90
Piston ring inspection(YD22DDTi) .................. EM-211
Piston to bore clearance(QR20DE•QR25DE) ... EM-93
Piston to bore clearance(YD22DDTi) ............. EM-214
PNP/SW - Wiring diagram EC-347,EC-1066,EC-1563
PNPSW1 - Wiring diagram .............. EC-706,EC-1354
POS - Wiring diagram ........ EC-229,EC-553,EC-958,
EC-1242
POWER - Wiring diagram .................................... PG-3
Power antenna ................................................... AV-16
Power door lock ................................................. BL-11
Power socket ................................................... WW-27
Power steering fluid level ........................ PS-5,MA-40
Power steering gear ........................................... PS-12
Power steering oil pressure switch ................ EC-1568
Power steering oil pump .................................... PS-24
Power steering pressure (PSP) sensor .......... EC-255,
EC-568
,EC-983,EC-1257
Power supply routing ........................................... PG-2
Power window ................................................... GW-23
Precations for Leak detection dye ................... ATC-12
Precautions (General) ........................................... GI-4
Pressure plate - See Clutch cover ..................... CL-15
PRGVLV - Wirng diagram ................ EC-694,EC-1342
Propeller shaft ...................................................... PR-2
Propeller shaft on vehicle service ........................ PR-2
PS/SEN - Wiring diagram .. EC-257,EC-570,EC-985,
EC-1259
PST/SW - Wiring diagram .............................. EC-1569
Q
Quick-glow system ......................................... EC-1544
R
R/FOG - Wiring diagram ..................................... LT-37
Radiator fan - See Cooling fan(QR20DE•QR25DE) .....
CO-12
Radiator fan - See Cooling fan(YD22DDTi) ...... CO-33
Radiator(QR20DE•QR25DE) ................ CO-11,CO-14
Radiator(YD22DDTi) ............................. CO-32,CO-35
Radio - See Audio ................................................ AV-3
Rear air spoiler ................................................... EI-21
Rear bumper ......................................................... EI-9
Rear cover packing replacement diff. ............. RFD-10
Rear disc brake .................................................. BR-26
Rear door ............................................................. BL-8
Rear fog lamp ..................................................... LT-37
Rear panel finisher .............................................. EI-22
Rear seat ........................................................... SE-11
Rear seat belt ...................................................... SB-4

IDX-9
A
C
D
E
F
G
H
I
J
K
L B
IDX
ALPHABETICAL INDEX
Throwout bearing - See Clutch release bearing CL-13
Time control system .......................................... BCS-3
Timing chain(QR20DE•QR25DE) ...................... EM-37
Timing chain(YD22DDTi) .................. EM-167,EM-172
TM/RLY - Wiring diagram .............. EC-1020,EC-1283
Torque converter installation .............. AT-419,AT-514
TPS - Wiring diagram ...................... EC-889,EC-1218
TPS1 - Wiring diagram ...................... EC-214,EC-543
TPS2 - Wiring diagram ...................... EC-156,EC-530
TPS3 - Wiring diagram ...................... EC-369,EC-647
Transfer control unit inspection table ...... TF-42,TF-49
Transmission case (M/T) ...................... MT-17,MT-22
Trouble diagnoses ................................................ GI-9
Turbocharger charge air cooler(YD22DDTi) .... EM-122
Turbocharger precautions .................................... GI-6
Turbocharger(YD22DDTi) ............................... EM-127
TURN - Wiring diagram .......................... LT-17,LT-19
Turn signal lamp ..................................... LT-17,LT-42
Two trip detection logic ......... EC-44,EC-454,EC-777,
EC-1141
V
Vacuum hose (brake system) ............................ BR-19
Vacuum hose drawing (Engine control) ............ EC-32,
EC-442
,EC-764,EC-1128
Vacuum pump(YD22DDTi) .............................. EM-139
Valve clearance(QR20DE•QR25DE) ................. EM-53
Valve clearance(YD22DDTi) ........................... EM-163
Valve guide(QR20DE•QR25DE) ....................... EM-65
Valve guide(YD22DDTi) .................................. EM-189
Valve lifter(QR20DE•QR25DE) ......................... EM-46
Valve lifter(YD22DDTi) .................................... EM-161
Valve seat(QR20DE•QR25DE) ......................... EM-66
Valve seat(YD22DDTi) .................................... EM-190
Valve spring(QR20DE•QR25DE) ...................... EM-67
Valve spring(YD22DDTi) ................................. EM-192
Variable induction air control system (VIAS) .. EC-393,
EC-714
VDC -Wiring diagram ...................................... BRC-69
Vehicle speed sensor (VSS) EC-250,EC-563,EC-978,
EC-1252
,EC-1489
Ventilation air filter ......................................... ATC-121
VIAS - Wiring diagram ....................... EC-395,EC-716
VSS - Wiring diagram ......... EC-252,EC-565,EC-980,
EC-1254
,EC-1490
W
WARN - Wiring diagram ........................... DI-44
,DI-50
Warning chime .................................................... DI-58
Warning lamps .................................................... DI-43
Washer, front ..................................................... WW-4
Washer, rear .................................................... WW-13
Water control valve(QR20DE•QR25DE) ........... CO-20
Water pump(QR20DE•QR25DE) ....................... CO-18
Water pump(YD22DDTi) ................................... CO-39
Water temperature gauge ........................... DI-4,DI-24
Weatherstrip - See Exterior ................................ BL-10
Wheel alignment (front) ..................................... FSU-6
Wheel alignment (rear) ..................................... RSU-6
Wheel balance ........................................ WT-4,MA-38
Wheel bearing (front axle) ................................. FAX-7
Wheel bearing (rear) ......................................... RAX-6
Wheel hub (front) ............................................... FAX-7
Wheel hub (rear) ............................................... RAX-6
Wheel sensor (VDC) ..................................... BRC-121
Wheel sensors (ABS) ..................................... BRC-49
WINDOW - Wiring diagram ............................... GW-27
Window, back ..................................................... GW-8
Window, back door ............................................. GW-8
Window, door ...................................... GW-44,GW-46
Window, rear side ............................................... GW-6
Window, side - See Rear side window ............... GW-6
WIP/R - Wiring diagram ................................... WW-13
WIPER - Wiring diagram .................................... WW-6
Wiper and washer .............................................. WW-4
Wiper, front ........................................................ WW-4
Wiper, rear ....................................................... WW-13
Wiring Diagram (Cell code) list .......................... PG-60
Wiring diagrams .................................................. GI-13
Withdrawal lever (clutch) ................................... CL-13
Wrist pin - See Piston pin inspection(QR20DE•QR25DE)
...........................................................................EM-89