warning light BMW MOTORRAD R 1150 RS 2002 Rider's Manual (in English)

i
2
Introduction
General information and con-
trols
General view, left side ........... 4
General view, right side ......... 5
Cockpit ................................. 6
Telltale and warning lights ..... 7
Ignition switch and steering
lock .................................... 8-9
Adjusting windshield ........... 10
Hazard warning flashers ...... 11
Left handlebar fitting ........... 12
Right handlebar fitting ......... 13
Adjusting handlebars ..... 14-15
Seat ............................... 16-17
System case .................. 18-19Safety check
Checklist ........................ 20-21
Engine oil ....................... 22-23
Fuel ................................ 24-25
Handlebar levers ............ 26-27
Brake system
- general ........................ 28-29
Brake system - without
BMW Integral ABS ......... 30-33
Brake system - with
BMW Integral ABS ......... 34-36
Clutch ................................. 37
Lights ............................. 38-42
Shock-absorber settings ..... 43
Spring preload .................... 44
Wheels ........................... 45-46
Accessories and tyres......... 47
Loading.......................... 48-49
Contents
10rsbkg2.book Seite 2 Dienstag, 19. November 2002 4:56 16

3
i
Introduction
Starting – Riding – Parking
First time out ................. 50-51
Important notes ............. 52-53
Side stand ..................... 54-55
Main (centre) stand ........ 56-57
Running in ..................... 58-59
Before you start ............. 60-61
Starting ......................... 62-63
Telltale and warning
lights ............................. 64-65
Rider Information
Display (FID) .................. 66-67
Riding and changing
gear ............................... 68-69
Brake system
- general ........................ 70-71
Brake system
- with BMW Integral ABS 72-78
BMW Integral ABS
- Troubleshooting chart ....... 79Arrive safely!
Arrive safely....................80-81
Service worldwide ............... 82
Environmental protection .... 83
BMW rider’s equipment ....... 84
BMW motorcycle equipment85
Training means extra safety. 86
Concluding thoughts ........... 87
Index ..............................88-92
Contents
10rsbkg2.book Seite 3 Dienstag, 19. November 2002 4:56 16

1
General information and controls
6
1Reset knob for
trip meter
2 Trip meter
3 Speedometer
4 Odometer
5 Adjusting knob for wind-
shield (
b 10)
6 Revolution counter (
b 58) 7
Rider Information Display
(FID) (
b 66, 67)
8 Telltale and warning lights
(
b 7)
9 Ignition switch and steering
lock (
b 8, 9)
( ) Figure in brackets
bpage number for description
Cockpit
1234567
98
10rsbkg2.book Seite 6 Dienstag, 19. November 2002 4:56 16

1
General information and controls
7
12435*67
98
1Telltale light, left turn indica-
tor repeater green
s
2 Warning light, battery
charge red
r (b 64)
3 Warning light, tank capac-
ity/when approx. 4 litres
(0.9 Imp. gal) remain in tank
orange
m (b 24, 25)
4 Telltale light, gearbox neu-
tral indicator green
k (b 61)
5 Warning light, ABS
l redOE
(
b 64)
OEOptional extra
*
n depending on national-market
specification
6 Warning light, engine oil
pressure red p (
b 65)
7 Telltale light, right turn indi-
cator repeater green
t
8General warning light
red
e (b 64)
9 High-beam headlight telltale
blue
q
( ) Figure in brackets
bpage number for description
Telltale and warning lights
10rsbkg2.book Seite 7 Dienstag, 19. November 2002 4:56 16

1
General information and controls
9
Key positions
d Warning:
Never turn the key to OFF or
I while riding the
motorcycle!
ON Operating position,
ignition, lights and all
electrical circuits
switched on
R * Ignition and lights off,
steering lock disengaged
(handlebars can be turned
freely to left or right)
* The key can be removed in these
positions
 Turn the handlebars to full left lock.
e Attention:
Engage the steering lock with
the handlebars in this position
only.
OFF* Ignition and lights off,
steering locked
I**Parking light on,
steering locked
L Note:
Switch the parking light on
only for limited periods. Note
state of battery charge.
Ignition switch and steering lock
10rsbkg2.book Seite 9 Dienstag, 19. November 2002 4:56 16

1
General information and controls
11
Hazard warning lights
L Note:
You cannot activate the hazard
warning flashers if the ignition is
switched off.
Do not use the hazard warning
flashers for longer than abso-
lutely necessary.
Note state of battery charge.
Switching on the hazard
warning lights
 Switching on the ignition
– Hazard warning lights switch 1 up  Operate hazard warning lights
switch 1
– Hazard warning lights in oper- ation
– The left/right flashing turn indicator repeater on the tell-
tale light panel (
b 7) flashes
 Switch off the ignition
– The hazard warning lights continue to operate
– The light in the hazard warn- ing flasher switch goes out
Switching off the hazard
warning lights
 Operate hazard warning lights switch 1
– Hazard warning lights switch off
– Left/right flashing turn indica- tor repeater on the telltale
light panel (
b 7) off
Hazard warning flashers
1
10rsbkg2.book Seite 11 Dienstag, 19. November 2002 4:56 16

1
General information and controls
12
d Warning:
To prevent air from entering
the clutch system:
 Do not turn the fitting on the
handlebar.
1 Lever for cold start
(fast idle) (
b 62, 63)
2 Hazard warning flasher
switch (
b 11) 3
Horn button
4 Left turn indicator switch
Press
– Turn indicators operate
To switch off turn indicators:
 Press turn indicator can-
cel switch 9
5 High/low (dipped) beam
headlight switch
FHigh-beam headlight
GLow (dipped) beam
FHeadlight flasher
Left handlebar fitting
12
5
4
3
10rsbkg2.book Seite 12 Dienstag, 19. November 2002 4:56 16

2
21
2
Safety check
For this reason, check the
details in the following sections
before you start the journey:
– Fuel level
– Positions of the handlebar levers
– Brake fluid level
– Clutch fluid level
–Brakes
– Warning lights and telltale lights
–Lights
– Shock-absorber setting and spring preload
– Condition of wheels and
tyres, tread depth and tyre
pressures
– Load, gross weight – Check regularly on the basis
of this checklist
(every refuelling stop):
– Engine oil level
(every 2nd/3rd refuelling
stop):
– Brake pads
If you encounter any problems
or difficulties, it is always best to
contact your authorised
BMW motorcycle dealer. He will
provide the necessary advice
and assistance.
Checklist
10rsbkg2.book Seite 21 Dienstag, 19. November 2002 4:56 16

2
23
2
Safety check
MAXMIN1
2
 Read off the oil level at the sight glass:
MAX top edge of
ring marking
MIN bottom edge of
ring marking
– The difference between the
two marks is approx. 0.5 litre
(0.8 Imp. pints)
 If necessary, remove oil filler plug 2 and top up the engine
oil through the oil filler 1
 Reinstall oil filler plug 2e Attention:
Warning light, engine oil pres-
sure red
p (b 7) indicates no
(or very little) oil pressure in
the lube-oil system; this light
m u s t n o t b e r e g a r d e d a s a n o i l
level check. Oil pressure
builds up after 1-2 seconds
and the warning light goes out
– the redengine oil pressure
warning light
p should re-
main off while the engine is
running.
Engine oil
BMW recommends Castrol
10rsbkg2.book Seite 23 Dienstag, 19. November 2002 4:56 16

2
25
2
Safety check
Refuel
– Refuel only with super (pre-mium) grade fuel to DIN
51607 standard or equivalent,
minimum octane number
95 (RON) and 85 (MON)
 Close the fuel filler cap
Capacity
L Note:
The fuel gauge and the FID
function only when the ignition
is on. – Usable tank capacity
22.5 litres (4.95 Imp. gal)
– When the reserve fuel quan-
tity is reached
(approx. 4 litres/0.9 Imp. gal),
the orange warning light 1
comes on
Fuel gauge 2 in FID(b 66)
L Note:
If only two bars still appear, ap-
prox. 4 litres (0.9 Imp. gal) of
fuel remain in the tank (addition-
al warning signal from orange
light 1).
Fuel
1
2
10rsbkg2.book Seite 25 Dienstag, 19. November 2002 4:56 16