check engine CITROEN BERLINGO VAN 2019 Handbook (in English)

190
Diesel fuel additive level
(Diesel with particle filter)
orThe additive reser voir low level is
indicated by fixed illumination of this
warning lamp, accompanied by an
audible signal and a message that
the particle filter additive level is too
low.
To p p i n g u p
This additive must be topped up without delay
by a CITROËN dealer or a qualified workshop.
AdBlue level
An alert is triggered once the reser ve level is
reached.
To avoid the vehicle being immobilised as per
regulations, you must top up with AdBlue.
Checks
Unless otherwise indicated, check these
components in accordance with the
manufacturer's service schedule and according
to your engine.
Other wise, have them checked by a CITROËN
dealer or a qualified workshop.
12 V battery
The battery does not require any maintenance.
However, check regularly that the terminals
are correctly tightened (versions without quick
release terminals) and that the connections
are clean.
For more information on the precautions
to take before starting work on the 12
V
battery , refer to the corresponding
section.
Versions equipped with Stop & Start are
fitted with a 12
V lead-acid battery of
specific technology and specification.
Its replacement should be carried out
only by a CITROËN dealer or a qualified
workshop.
Air filter
Depending on the environment
(e.g. dusty atmosphere) and the
use of the vehicle (e.g. city driving),
replace it twice as often if
necessary .
Passenger compartment filter
Depending on the environment
(e.g. dusty atmosphere) and the
use of the vehicle (e.g. city driving),
replace it twice as often if
necessary.
A clogged passenger compartment
filter may have an adverse effect on
the per formance of the air conditioning
system and generate undesirable odours.
Oil filter
Change the oil filter each time the
engine oil is changed.
In winter (temperatures below zero), a fluid with
antifreeze must be used that is appropriate for
the prevailing conditions, in order to preser ve
the elements of the system (pump, tank, ducts,
e t c .) .
Filling with pure water is prohibited under all
circumstances (risk of freezing, limestone
deposits, etc.).
For more information on AdBlue and the SCR
system, and in particular topping it up, refer to
the corresponding section.
Practical information

194
If any AdBlue® is splashed, or if there are
any spillages on the side of the body, rinse
immediately with cold water or wipe with a
damp cloth.
If the fluid has crystallised, clean it off
using a sponge and hot water.
Access to the AdBlue®
tank
A blue cap behind the fuel filler flap indicates
access to the AdBlue® tank.
Read the following procedure carefully to
be able to top up properly.
F

S

witch off the ignition and remove the key.
F

W

ith the vehicle unlocked and the fuel filler
flap open, turn the AdBlue
® blue filler cap
anti-clockwise. F

O
btain an AdBlue
® container. After first
checking the use-by date, read the
instructions on the label carefully before
pouring the contents of the container into
your vehicle's AdBlue
® tank.
Or
F

I

nsert the AdBlue
® pump nozzle and refill
the tank until the nozzle stops automatically.
Important:
To avoid over flowing the AdBlue
® tank, it
i
s recommended:
F

T

o do a top-up between 10 and
13

litres using the AdBlue
® bottle.
Or
F

I

f filling in a ser vice station, stop after
the third automatic shut-off of the
nozzle.
F

A

fter refilling, carry out the same operations
in reverse order. Important: in the event of a top-up after
a breakdown because of a lack of
AdBlue,
you must wait around 5 minutes
before switching on the ignition, without
opening the driver’s door, unlocking
the vehicle, introducing the key into
the ignition switch, or introducing
the key of the
K
eyless Entr y and
Star ting system into the passenger
compartment .
Switch on the ignition, then wait for
10

seconds before starting the engine.
Never pour AdBlue
® into the Diesel fuel
tank.
Practical information

205
Light-emitting diodes (LED)
For the replacement of this type of bulb,
you must contact a CITROËN dealer or a
qualified workshop.
Halogen bulbs
To ensure good quality lighting, check
that the bulb is correctly positioned in its
housing.In some weather conditions (e.g. low
temperature or humidity), the presence
of misting on the internal sur face of the
glass of the headlamps and rear lamps is
normal; it disappears after the lamps have
been on for a few minutes.
Types of bulb
Various types of bulb are fitted to your vehicle.
To remove them:
Ty p e A
Ty p e B Ty p e C
Ty p e D
Halogen bulbs must be changed with the
lamp off for a few minutes (risk of severe
burns). Do not touch the bulb directly, use
a lint-free cloth.
When each operation has been
completed, check the operation of the
lighting.
All glass bulb: pull gently as it is fitted by
pressure.
Bayonet bulb: press on the bulb then turn it
anti-clockwise. Halogen bulb: release the retaining spring from
its housing.
Halogen bulb: turn the bulb anti-clockwise.
Opening the bonnet /Access to bulbs
With the engine warm, proceed with
caution – risk of burns!
Take care with objects or clothing that
could be caught in the blades of the
cooling fan – risk of strangulation!
After changing a bulb
When refitting, close the protective cover
very carefully to guarantee the sealing of
the lamp.
8
In the event of a breakdown

214
Access to the battery
The battery is located under the bonnet.
F O pen the bonnet using the interior release
lever, then the exterior safety catch.
F

S
ecure the bonnet stay.
For more information on the Bonnet and
the Engine , refer to the corresponding
sections.
Starting using another
battery
When your vehicle's battery is flat, the engine
can be started using a backup battery (external
or from another vehicle) and jump leads or a
battery booster. Never try to start the engine by connecting
a battery charger.
Never use a 24
V or higher battery
b o o s t e r.
First check that the backup battery has
a nominal voltage of 12 V and a capacity
at least equal to that of the discharged
battery.
The two vehicles must not be in contact
with each other.
Switch off all the electrical consumers
on both vehicles (audio system, wipers,
lighting, etc.).
Make sure that the jump leads are not
close to moving parts of the engine (fan,
belts, etc.).
Do not disconnect the (+) terminal while
the engine is running.
The battery (-) terminal is not accessible.
A remote earth point is provided at the front of
the vehicle. F
S
tart the engine of the vehicle with the
good battery and leave it running for a few
minutes.
F
O
perate the starter on the broken down
vehicle and let the engine run.
If the engine does not start straight away,
switch off the ignition and wait a few moments
before trying again.
F
W
ait for it to return to idle.
F
D
isconnect the jump lead cables in reverse
order .
F
A
llow the engine to run for at least
30 minutes, by driving or with the vehicle
stationary, so that the battery reaches an
adequate state of charge.
Some functions, including Stop & Start,
are not available if the battery is not
sufficiently charged.
F
C
onnect the red cable to the (+) terminal of
flat battery A (at the metal elbow), then to
the (+) terminal of backup battery B or the
b o o s t e r. F

C
onnect one end of the green or black
cable to the (-) terminal of backup battery
B or the booster (or an earth point on the
other vehicle).
F
C
onnect the other end of the green or black
cable to earth point C on the broken down
vehicle.
In the event of a breakdown

215
Charging the battery using
a battery charger
For optimum ser vice life of the battery, it is
essential to maintain an adequate state of
charge.
In some circumstances it may be necessary to
charge the battery:
-
i
f you only use your vehicle for short
journeys,
-

i
f the vehicle is to be taken off the road for
several weeks.
Contact a CITROËN dealer or a qualified
workshop.
If you plan to charge your vehicle's battery
yourself, use only a charger compatible
with lead-acid batteries with a nominal
voltage of 12
V.
Follow the instructions provided by the
manufacturer of the charger.
Never reverse polarities.
It is not necessary to disconnect the
battery.
F

S
witch off the ignition.
F

S
witch off all electrical consumers (audio
system, lamps, wipers, etc.). F

S
witch off the charger B before connecting
the cables to the battery, so as to avoid any
dangerous sparks.
F

E
nsure that the charger cables are in good
condition.
F

R
aise the plastic cover, if your vehicle has
one, on the (+) terminal.
F

C
onnect the cables of charger B as follows:
-

t
he positive (+) red cable to the (+)
terminal of battery A ,
-

t
he negative (-) black cable to earth point
C on the vehicle.
F

A
t the end of the charging operation, switch
off charger B before disconnecting the
cables from battery A . Never try to charge a frozen battery – risk
of explosion!
If the battery has frozen, have it checked
by a CITROËN dealer or by a qualified
workshop who will check that the internal
components have not been damaged and
that the container has not cracked, which
would mean a risk of toxic and corrosive
acid leaking.
Disconnecting the battery
In order to maintain an adequate state
of charge for starting the engine, it is
recommended that the battery be disconnected
if the vehicle is taken out of ser vice for a long
period.
Before disconnecting the battery:
F

c
lose all of the accesses (doors, tailgate,
windows, roof), If this label is present, it is essential to
use only a 12
V charger to avoid causing
irreversible damage to the electrical
components related to the Stop & Start
system.
8
In the event of a breakdown

15
QUESTIONRESPONSESOLUTION
With the engine off, the audio system switches
off after a few minutes of use. When the engine is switched off, the audio
system operating time depends on the state of
charge of the battery.
The switch-off is normal: the audio system
switches to economy mode and switches off to
prevent discharging the vehicle's battery.Turn the ignition on to increase the charge of
the battery.
The message "the audio system is overheated"
appears on the display. In order to protect the installation if the
surrounding temperature is too high, the audio
system switches to an automatic thermal
protection mode leading to a reduction in
volume or the CD play stopping.Switch the audio system off for a few minutes
to allow the system to cool.
Radio
QUESTION
RESPONSESOLUTION
There is a difference in sound quality between
the different audio sources (radio, CD, etc.). To allow for optimal listening quality, the audio
settings (Volume, Bass, Treble,Ambience,
Loudness) can be tailored to different
sound sources, which can generate audible
differences when changing source (radio, CD,
e t c .) .Check that the audio settings (Volume, Bass,
Treble, Ambience and Loudness) are adapted
to the sources listened to. It is advisable to set
the audio functions (Bass, Treble, Front-Rear
Balance and Left-Right Balance) to the middle
position, select the musical ambience "None"
and set the loudness correction to the "Active"
position in CD mode or to the "Inactive"
position in radio mode.
.
Bluetooth® audio system

22
Settings
QUESTIONRESPONSESOLUTION
When changing the setting of treble and bass,
the ambience setting is deselected.
When changing the ambience setting, the
treble and bass settings are reset. The selection of an ambience setting imposes
the settings for treble and bass and vice versa.
Modify the treble and bass or ambience
settings to obtain the desired musical
ambience.
When changing the balance setting,
distribution is deselected.
When changing the distribution setting, the
balance setting is deselected. The selection of a distribution setting imposes
the balance settings and vice versa.
Modify the balance setting or the distribution
setting to obtain the desired sound quality.
There is a difference in sound quality between
the different audio sources. To allow for optimal listening quality, the
audio settings can be tailored to different
sound sources, which can generate audible
differences when changing source.Check that the audio settings are adapted
to the sources listened to. Adjust the audio
functions to the middle position.
When the engine is off, the system switches off
after several minutes of use.
When the engine is switched off, the system's
operating time depends on the state of charge of
the battery.
The switch-off is normal: the system automatically
goes into energy economy mode and switches off
to maintain an adequate charge in the battery.Start the engine to increase the charge of the
battery.
CITROËN Connect Radio

39
Settings
QUESTIONRESPONSESOLUTION
When changing the setting of treble and bass,
the ambience setting is deselected.
When changing the ambience setting, the
treble and bass settings are reset. The selection of an ambience setting imposes
the settings for treble and bass and vice versa.
Modify the treble and bass or ambience
settings to obtain the desired musical
ambience.
When changing the balance setting,
distribution is deselected.
When changing the distribution setting, the
balance setting is deselected. The selection of a distribution setting imposes
the balance settings and vice versa.
Modify the balance setting or the distribution
setting to obtain the desired sound quality.
There is a difference in sound quality between
the different audio sources. To allow for optimal listening quality, the
audio settings can be tailored to different
sound sources, which can generate audible
differences when changing source.Check that the audio settings are adapted to
the sources listened to. It is recommended
that the audio settings (Bass, Treble, Balance)
be adjusted to the middle position, select the
"None" musical ambience and set the loudness
correction to the "Active" position in CD mode
or to the "Inactive" position in radio mode.
When the engine is off, the system switches off
after several minutes of use.
When the engine is switched off, the system's
operating time depends on the state of charge of
the battery.
The switch-off is normal: the system automatically
goes into energy economy mode and switches off
to maintain an adequate charge in the battery.Start then vehicle’s engine to increase the
charge of the battery.
The date and time cannot be set. Setting of the date and time is only available
if the synchronisation with the satellites is
deactivated.Settings menu/Options/Time-Date setting.
Select the "Time" tab and deactivate the "GPS
synchronisation" (UTC).
.
CITROËN Connect Nav

227
AABS ........................................................................\
.... 94
Accessories ........................................................ 91,
1 25
Access to the 3rd row
................................................. 61
Access to the spare wheel

......................................2

01
Active Safety Brake
.................................... 18,

15
6 -15 8
AdBlue
® ................................................. 23, 31, 19 2-193
AdBlue® tank ............................................................ 193
Additive, Diesel ................................................... 21,
19 1
Adjusting headlamp beam height
............................. 87
Ad

justing head restraints
.......................................... 62
Ad

justing seats
.................................................... 56,


61
Ad

justing the air distribution .................................71
-7

2
Adjusting the air flow


............................................ 71
-7

2
Adjusting the date
........................................... 36,


17,


32
A

djusting the height and reach of the steering wheel


......................................................... 53
Adjusting the lumbar support


.................................... 56
Adjusting the temperature
.................................... 71-7

2
Adjusting the time
.......................................... 36,


17,


33
Adv

anced Grip Control ......................................... 97
-
9
8
Advice on driving


.............................................. 120 -121
Airbags


............................................... 19,

10
3,

10
5,

10
7
Airbags, curtain
............................................... 10

5,

10
8
Airbags, front


..................................... 104 -105,

10
7-108
Airbags, lateral


................................................. 104 -105
Air conditioning


.............................................. 71,

72,


75
A

ir conditioning, automatic

....................................... 79
Air conditioning, dual-zone automatic


.................71
-7

2
Air conditioning, electronic (with display screen)
...... 75
A

ir conditioning, manual

..........................70
-71,


74,


79
A

ir intake

............................................................... 71
-7

3
Alarm


.................................................................... 49,

51
A

nti-lock braking system (ABS) ................................94
Anti-slip regulation (ASR)


......................................... 94
Anti-theft/Immobiliser


.............................................. 126
Apple CarPlay connection


................................... 12,

18
A

rmrest

...................................................................... 57
Armrest, front


............................................................. 63
Assistance, emergency braking


.......................94,

15
8
Assistance call ...................................................... 92 -9 3
Audio streaming (Bluetooth) ........................9,
9,
2 5- 26
BBattery .............................................. 185, 19 0, 21 3 -216
Battery, 12 V .............................................................213
Battery, charging
...................................................... 2

15
Battery, remote control


..................................44
-45,


78
B

lind spot detection

......................................... 162,

16
4
BlueHDi
.............................................................. 31,


19
6
Bluetooth (hands-free)


...................1 0
-11,


1
3
-
14,

2
7 -
2
8
Bluetooth (telephone)


................................13
-

15,

2
7 -
2
8
Bonnet


............................................................... 18 6 -187
Boot lid
................................................................. 40,

43
B

rake discs

....................................................... 191-192
Brake lamps


............................................................. 209
Brakes


......................................................... 14,

19
1-192
Braking, automatic emergency


..................18,

15
6 -15 8
Braking, emergency


................................................ 129
Braking assistance system


.......................................94
Brightness


................................................................... 16
Bulbs


........................................................................\
205
Bulbs (changing)


............................................... 204-206
Bulbs (changing, type)
............................................. 20

5
CCable, audio ............................................................... 25
Cable, Jack ................................................................ 25
C
ap, fuel filler .................................................... 18 0 -181
Capacity, fuel tank


............................................ 18 0 -181
CD


...................................................................... 9,

9,


25
C

D, MP3
............................................................ 9,


9,


25
C

entral locking

..................................................... 38,

40
C

hanging a bulb
............................................... 20

4-208
Changing a fuse
................................................ 21

1-213Changing a wheel
.....................................
19
6 -197
,
20
0
Changing a wiper blade

.......................................
88
-89
C
hanging the remote control battery ........................
44
Charger, wireless ....................................................... 66
Checking the engine oil level

....................................
30
Checking the levels

..........................................
187-189
Checking tyre pressures (using the kit)

...........
197-19 9
Checks

......................................................
187,
19
0 -192
Checks, routine ................................................. 19 0 -192
Child lock

..................................................................
11 9
Child lock, electric

....................................................
11 9
Children

......................................................
113,
11
5 -117
Children (safety)
....................................................... 11
9
Child seats

...........
102-103 ,
10
6 -107
,
111
,

11
3
,
11
6 -11 8
Child seats, conventional
......................................... 111
C
hild seats, i-Size ....................................................
117
Child seats, ISOFIX

...........................................
115 -117
CITROËN Connect Nav ...............................................
1
CITROËN Connect Radio
............................................ 1
Cl
osing the doors

................................................
38,
40
C
ollision Risk Alert
.....................................
18,

15
6 -157
Configuration, vehicle

...............................................
29
Connection, Bluetooth ..............11,
1
3
-
15
,
21-2
2
,
2
7 -
2
8
Connection, MirrorLink ....................................11
-1
2
,
19
C
onnection, Wi-Fi network

.......................................
22
Control, back-up boot release ..................................
43
Control, back-up door release ...................................
42
Control, heated seats
................................................ 58
C
ontrol stalk, lighting

...........................................
81,
83
C
ontrol stalk, wipers .............................................
87 -9 0
Cour tesy lamp, front ..................................................80
Cour tesy lamp, rear
...................................................80
Courtesy lamps
......................................................... 80
C

over, luggage

..........................................................69
Cruise control


............................142,

1
4 5 -151,

15
4 -15 6
Cruise control, adaptive


...................................148 -149
Cruise control, adaptive with Stop function ........................................... 142,

1
4 8 -151,

15
4
Cruise control by speed limit recognition


................142
Cup holder
................................................................. 63
.
Alphabetical index

229
JJack .................................................................... 200, 25
J ump starting ............................................................ 214
KKey ................................................................. 37, 40, 45
K ey, electronic ............................................ 37,
12 5 -126
Keyless Entry and
Starting


............................. 37
-
4
0,

42,


45-4
6,

12
3,

12
5
Key with remote control
..................................37,

40,


42
K

it, hands-free

................................ 1 0
-11,


1
3
-
14,

2
7 -
2
8
Kit, temporary puncture repair


.........................19 6 -19 9
LLabels .................................................................... 4, 61
L abels, identification ............................................... 226
Lamps, front


...................................................... 206-208
Lamps, parking


.......................................................... 83
Lamps, rear


.............................................................. 209
Lane Depar ture Warning System, Active

.........2

0, 159
LEDs - Light-emitting diodes


............................83,

20
5
Level, brake fluid
..................................................... 189
Level, Diesel additive


....................................... 19 0 -191
Level, engine coolant


...................................28
-3

0,

18
9
Level, engine oil
.......................................... 30,


18
8 -189
Level, screenwash fluid
..................................... 88,


18
9
Levels and checks
............................................ 187-189
Light-emitting diodes - LEDs


............................83,

20
5
Lighting
....................................................................... 81
L

ighting, cornering ................................................ 86
-87
L

ighting, guide-me home
.......................................... 84
L

ighting, welcome ...................................................... 84
Loading


.................................................................... 185
Load reduction mode
.............................................. 18

5
Locating your vehicle


................................................. 42
Locking
........................................................... 37,


40,


45
Locking from the inside .............................................46
L ow fuel level .................................................... 18 0 -181
Lumbar
....................................................................... 56
MMarkings, identification ........................................... 226
Mat ..................................................................... 63,
12 3
Memorising a speed


......................................... 15 5 -15 6
Menu
........................................................................\
... 12
M

enu, main

................................................................... 4
Menus (audio)


................................................... 4
-
5,


4
-
5
M

essages
.................................................................. 30
M

essages, quick ........................................................ 30
Mirror, child surveillance
........................................... 54
M

irror, rear view

......................................................... 54
Mirrors, door


.................................. 53
-5

4,

75,


16
2,

16
4
Misfuel prevention


.................................................... 181
Mountings, ISOFIX


........................................... 114,

11
6
MP3 CD
........................................................................\
9
NNet ........................................................................\
. 6 9- 70
Net, high load retaining ............................................. 68
N
umber plate lamps

................................................. 210
OObstacle detection .................................................. 166
Oil, engine ......................................................... 188 -189
Oil change


......................................................... 188 -189
Oil consumption


................................................ 188 -189
Opening the bonnet


.......................................... 18 6 -187
Opening the boot


........................................................ 37
Opening the doors


...................................................... 37
Opening the fuel filler flap
.......................................18 0
PPads, brake ....................................................... 19 1-192
Paint colour code ..................................................... 226
Park Assist
................................................................ 17

1
Parking brake


........................................... 126,

19
1-192
Parking brake, electric
............. 16,


20,


24-2
5,

1
26 -129
Parking sensors, audible and visual


.......................166
Parking sensors, front


............................................. 167
Parking sensors, rear


.............................................. 166
Petrol
................................................................. 22

0-221
Plates, identification
................................................ 2

26
Player, Apple
® .................................................. 10, 9, 26
P
layer, MP3 CD ..................................................... 9,
25
P
l aye r, U S B ......................................................... 7,

9,


25
P

ower steering
............................................................ 15
P

re-heater, Diesel
...................................................... 18
P

ressures, tyres
.............................. 19

1,

20
0,

20
4,

2
26
Pre-tensioning seat belts
................................. 10

2-103
Priming the fuel system


........................................... 19 6
Profiles
................................................................. 16,


31
P

rogrammable cruise control
................................. 1

45
Protecting children


....104 ,

10
6 -108,

111,


11
3,

11
5 -11 8
Puncture ............................................................ 197-2 0 0
RRadio ................................................. 4 -5, 6- 7, 9, 23, 25
R adio, digital (Digital Audio Broadcasting - DA B)


................................................................ 6,

8,


24
R

ange, AdBlue

..................................................... 31
-3

2
RDS


................................................................... 7,

2
3
-24
R

ear screen, demisting

.............................................. 75
Recharging the battery


............................................ 215
Recirculation, air
................................................... 71-7

3
Reduction of electrical load

....................................18

5
Regeneration of the particle filter
............................ 19

1
Reinitialisation of the under-inflation detection system


.................................................... 17 7
Reinitialising the remote control


...............................44
Reminder, key in ignition


.......................................... 124
.
Alphabetical index