sensor DODGE NEON 1999 Service Manual PDF

IMMOBILIZER SYSTEM
CONTENTS
page page
DESCRIPTION AND OPERATION
IMMOBILIZER RECEIVER................ 1
IMMOBILIZER SYSTEM.................. 1
IMMOBILIZER TRANSMITTER............. 2
POWER-UP MODE...................... 2
DIAGNOSIS AND TESTING
IMMOBILIZER DIAGNOSIS............... 2SERVICE PROCEDURES
VEHICLE IMMOBILIZER SYSTEM.......... 3
REMOVAL AND INSTALLATION
IMMOBILIZER RECEIVER................ 3
DESCRIPTION AND OPERATION
IMMOBILIZER SYSTEM
The Immobilizer system includes the following
unique items:
²An immobilizer module receiver that controls
system operation and also controls the RKE and Illu-
minated entry systems, if equipped.
²An encoded Crankshaft Position Sensor for the
ignition system. The Immobilizer module decodes the
signal from the crankshaft so the PCM can recognize
it as a valid Crankshaft Position Sensor signal, and
allow the engine to run.
²A wiring harness that interconnects the crank-
shaft sensor, the immobilizer receiver, and the PCM.
²Two key fob transmitters.
The Immobilizer System prevents unauthorized
operation of the vehicle by disabling the engine and
starter. The system will NOT allow the vehicle to
start unless the UNLOCK button on the RKE trans-
mitter is pressed. The system will be activated after
turning the ignition switch to the OFF position and
using one of the following methods.
(1) Press the LOCK button on the RKE transmit-
ter.
(2) LOCK the doors by pressing a power lock but-
ton switch.
(3) LOCK the driver or passenger door using the
key.
²The Security light will flash, for about 16 sec-
onds, indicating that the engine and starter will be
disabled.
²The Security light remaining on, indicates the
system is not operational.
²The Immobilizer will activate automatically
within 10 minutes of the ignition switch being in the
OFF position, whether the vehicle has been locked or
unlocked.²An attempt to start the vehicle without pressing
the UNLOCK button on the RKE transmitter will
result in a warning chime and the Security light
flashing.
NOTE: The ignition switch must be in the OFF posi-
tion in order for the system to be activated, whether
the doors are closed or not.
IMMOBILIZER RECEIVER
The immobilizer receiver is programmed to
respond to the Lock and Unlock radio signals issued
by the immobilizer transmitters. The receiver will
only respond to the radio signals of transmitters (up
to four) whose vehicle access codes have been stored
in the receiver's electronic memory. The receiver is
programmed at the assembly plant with the vehicle
access codes of the two transmitters that are shipped
with the vehicle.
The immobilizer receiver also has a central pro-
cessing unit, which contains the immobilizer system
logic. The programming in the immobilizer receiver
allows the system to learn and retain transmitter
vehicle access codes, as well as to communicate with
the Powertrain Control Module (PCM) and/or the
DRB scan tool on the Chrysler Collision Detection
(CCD) data bus network.
The CCD data bus network allows the sharing of
sensor information. This helps to reduce wiring har-
ness complexity, reduce internal controller hardware,
and reduce component sensor current loads. At the
same time, the CCD data bus network provides
increased reliability and enhanced diagnostic capabil-
ities.
Each immobilizer transmitter has a different vehi-
cle access code, which must be programmed into the
memory of the immobilizer receiver in the vehicle in
order to operate the immobilizer system. A DRB scan
tool must be used to program new or additional
PLIMMOBILIZER SYSTEM 8Q - 1

transmitter vehicle access codes into the memory of
the immobilizer receiver. Refer to the Vehicle Theft
Security System menu item on the DRB scan tool for
the procedures.
The immobilizer receiver recognizes the Lock and
Unlock signals received from the programmed immo-
bilizer transmitters. If the code sent by the key fob
transmitter is recognized as valid by the Immobilizer
module, it will decode the Crankshaft Position Sensor
signal, enable the starter circuit, and allow the
engine to run.
The immobilizer receiver is mounted to the dash
panel with a hook and loop fastener patch. It is
located behind the instrument cluster and above the
heater-A/C housing. The receiver is connected to the
dash panel cross-body wiring harness. (Fig. 1)
For diagnosis of the vehicle immobilizer receiver or
the CCD data bus, a DRB scan tool is required. Refer
to the Vehicle Theft Security System menu item of
the DRB scan tool for the procedures. The immobi-
lizer receiver contains no servicable parts. If faulty,
the unit must be replaced.
IMMOBILIZER TRANSMITTER
The vehicle immobilizer system includes two trans-
mitters that are supplied with the vehicle when it isshipped from the factory. Each of the two transmit-
ters is equipped with two buttons labeled with Inter-
national Standards Organization (ISO) symbols for
Lock, and Unlock. Two spare batteries (enough for
one transmitter) are also shipped with the transmit-
ters. The transmitters are equipped with a key ring
and are designed to serve as a key fob. The operating
range of the radio frequency transmitter signal is up
to 7 meters (23 feet) from the immobilizer receiver.
Each transmitter has a different vehicle access
code, which must be programmed into the memory of
the immobilizer receiver in the vehicle in order to
operate the immobilizer system. The two transmit-
ters shipped with the vehicle have their vehicle
access codes programmed into the receiver at the fac-
tory. A DRB scan tool must be used to program new
or additional transmitter vehicle access codes into
the memory of the immobilizer receiver. Refer to the
Vehicle Theft Security System menu item on the
DRB scan tool for the procedures.
Each transmitter operates on two Duracell DL2016
(or equivalent) batteries. Typical battery life is from
one to two years.
POWER-UP MODE
When the vehicle immobilizer system senses that
the vehicle battery has been disconnected and recon-
nected, it enters its power-up mode. If the immobi-
lizer system was armed prior to the battery
disconnect, the system remains armed when the bat-
tery is reconnected.
If the immobilizer system was disarmed prior to
the battery disconnect, the system will remain dis-
armed if the battery is reconnected within five min-
utes. The system will passively arm itself when the
battery is reconnected more than five minutes after a
battery disconnect or failure. After any passive arm-
ing, the system will have to be actively disarmed
using one of the transmitters.
The power-up mode logic also applies if the battery
goes dead, and battery jump-starting is attempted.
The engine no-run feature will prevent the engine
from operating until the vehicle immobilizer system
has been actively disarmed.
DIAGNOSIS AND TESTING
IMMOBILIZER DIAGNOSIS
Refer to the 1998 PL Powertrain Diagnostic Man-
ual for complete diagnostic procedures of the immo-
bilizer system.
Fig. 1 Immobilizer Module Location
8Q - 2 IMMOBILIZER SYSTEMPL
DESCRIPTION AND OPERATION (Continued)

8W-02 COMPONENT INDEX
Component Page
A/C Compressor Clutch..................8W-42
A/C Compressor Clutch Relay.............8W-42
A/C Cycling Switch.....................8W-42
A/C Heater Blower Motor................8W-42
A/C Heater Control.....................8W-42
A/C Pressure Switches...................8W-42
ABS Warning Lamp Relay................8W-35
Airbag Control Module...................8W-43
Airbags..............................8W-43
Antenna..............................8W-47
Ash Receiver Lamp.....................8W-44
Automatic Shut Down Relay..............8W-30
Back-Up Lamp Switch...................8W-51
Back-Up Lamps........................8W-51
Battery..............................8W-20
Battery Temperature Sensor..............8W-30
Blower Motor Resistor Block..............8W-42
Brake Warning Lamp Switch...........8W-40, 50
Camshaft Position Sensor................8W-30
Center High Mounted Stop Lamp..........8W-51
Cigar Lighter Relay.....................8W-41
Cigar Lighter/Power Outlet...............8W-41
Circuit Breakers.......................8W-11
Clockspring.....................8W-30, 41, 61
Clutch Pedal Position Switch...........8W-10, 21
Combination Flasher....................8W-52
Controller Anti-Lock Brake...............8W-35
Crankshaft Position Sensor...............8W-30
Data Link Connector....................8W-30
Daytime Running Lamp Module...........8W-50
Diode No. 1........................8W-15, 42
Diode No. 2......................8W-10, 11, 44
Diode No. 3......................8W-11,44,70
Dome Lamp...........................8W-44
Door Ajar Switches.....................8W-44
Door Jamb Switches....................8W-44
Door Lock Motors......................8W-61
Door Lock Motors......................8W-61
Door Lock Switches.....................8W-61
Duty Cycle Evap/Purge Solenoid...........8W-30
EGR Transducer Solenoid................8W-30
Engine Coolant Temperature Sensor........8W-30
Engine Oil Pressure Switch...............8W-40
Engine Starter Motor....................8W-21
Engine Starter Motor Relay...............8W-21
Fog Lamp Relays....................8W-50, 51
Fog Lamp Switches..................8W-50, 51
Fog Lamps.........................8W-50, 51
Fuel Injectors..........................8W-30
Fuel Pump Module.....................8W-30
Fuel Pump Relay.......................8W-30
Fuse Block............................8W-11Component Page
Fuses (FB)............................8W-11
Fuses (PDC)...........................8W-10
Fusible Link........................8W-20, 21
Generator.............................8W-20
Glove Box Lamp And Switch..............8W-44
Grounds..............................8W-15
Halo Lamp............................8W-44
Headlamp Dimmer And Optical Horn Switch .8W-50
Headlamp Leveling Motors...............8W-50
Headlamp Leveling Switch...............8W-50
Headlamp Switch.......................8W-50
Headlamps............................8W-50
High Speed Warning Module..............8W-40
Horn Relay...........................8W-41
Horn Switches.........................8W-41
Horns................................8W-41
IAT/Map Sensor........................8W-30
Idle Air Control Motor...................8W-30
Ignition Coil Pack......................8W-30
Ignition Switch........................8W-10
Illumination Lamps.....................8W-40
Immobilizer...........................8W-61
Immobilizer Engine Sensor............8W-30, 61
Indicator Lamps........................8W-40
Instrument Cluster.....................8W-40
Intermittent Wipe/Wash Switch............8W-53
Key-In Switch.........................8W-40
Knock Sensor..........................8W-30
License Lamps.........................8W-51
Map/Reading Lamps....................8W-44
Noise Supressor.....................8W-10, 30
Oxygen Sensors........................8W-30
Park Brake Switch...................8W-40, 50
Park/Neutral Position Switch...........8W-30, 51
Park/Turn Signal Lamps..............8W-50, 52
Power Distribution Center................8W-10
Power Folding Mirror Relay...............8W-62
Power Mirror Fuse Holder................8W-62
Power Mirrors.........................8W-62
Power Steering Pressure Switch...........8W-30
Power Sunroof Motor....................8W-64
Power Window Motors...................8W-60
Power Window Switches.................8W-60
Powertrain Control Module...............8W-30
PRNDL Lamp.........................8W-44
Radiator Fan Motor.....................8W-42
Radio................................8W-47
Rear Window Defogger..................8W-48
Rear Window Defogger Switch.............8W-48
Remote Keyless Entry Module.............8W-61
Remote Keyless Entry Program
Module Connector....................8W-61
PL8W - 02 COMPONENT INDEX 8W - 02 - 1

Component Page
Repeater Lamps.....................8W-50, 52
Seat Belt Switch.......................8W-40
Side Marker Lamps..................8W-50, 52
Solid State Fan Relay...................8W-42
Speakers.............................8W-47
Splice Information......................8W-70
Stop Lamp Switch......................8W-30
Sunroof Switches.......................8W-64
Tail/Stop Lamps........................8W-51
Tail/Stop/Turn Signal Lamps..............8W-51
Throttle Position Sensor.................8W-30
Time Delay Relay....................8W-11,44
Time Out Relay.....................8W-11,44
Torque Converter Clutch Solenoid..........8W-30Component Page
Trunk Lamp...........................8W-44
Trunk Switch..........................8W-44
Turn Signal Lamps.....................8W-52
Turn Signal/Hazard Switch...............8W-52
Underhood Lamp.......................8W-44
Vapor Canister Leak Detector.............8W-30
Vehicle Speed Control...................8W-30
Vehicle Speed Sensor....................8W-30
Visor/Vanity Lamps.....................8W-44
Warning Lamps........................8W-40
Wheel Speed Sensors....................8W-35
Windshield Washer Pump Motor...........8W-53
Wipe/Wash Switch......................8W-53
Wiper Motor...........................8W-53
8W - 02 - 2 8W - 02 COMPONENT INDEXPL

8W-10 POWER DISTRIBUTION
Component Page
A/C Compressor Clutch.............8W-10-14, 15
A/C Compressor Clutch Relay........8W-10-14, 15
Automatic Shut Down Relay............8W-10-16
Battery...........................8W-10-5, 6
Capacitor..........................8W-10-16
Circuit Breaker.......................8W-10-8
Clutch Pedal Position Switch.......8W-10-9, 10, 11
Controller Anti-Lock Brake.......8W-10-12, 14, 15
Data Link Connector..................8W-10-16
Diode No. 1......................8W-10-14, 15
Diode No. 2.........................8W-10-13
Dome Lamp........................8W-10-13
Downstream Heated Oxygen Sensor......8W-10-16
Engine Starter Motor..................8W-10-7
Engine Starter Motor Relay......8W-10-7, 9, 10, 11
Fog Lamp Relay.....................8W-10-17
Fuel Injector No. 1...................8W-10-16
Fuel Injector No. 2...................8W-10-16
Fuel Injector No. 3...................8W-10-16
Fuel Injector No. 4...................8W-10-16
Fuel Pump Module...................8W-10-16
Fuel Pump Relay....................8W-10-16
Fuse 1 (FB)..........................8W-10-8
Fuse 2 (FB)..........................8W-10-8
Fuse 2 (PDC).....................8W-10-5, 6, 7
Fuse 3 (FB)..........................8W-10-8
Fuse 3 (PDC).....................8W-10-5, 6, 8
Fuse 4 (FB)..........................8W-10-8
Fuse 5 (FB)..........................8W-10-8
Fuse 5 (PDC)....................8W-10-5, 6, 12
Fuse 6 (FB)..........................8W-10-8
Fuse 7 (FB)..........................8W-10-8
Fuse 8 (FB)..........................8W-10-8
Fuse 8 (PDC)....................8W-10-5, 6, 12
Fuse 9 (FB).......................8W-10-9, 10
Fuse 10 (FB)...................8W-10-9, 10, 11
Fuse 10 (PDC)...................8W-10-5, 6, 12
Fuse 11 (FB)...................8W-10-9, 10, 11
Fuse 11 (PDC)....................8W-10-5, 6, 7
Fuse 12 (FB)........................8W-10-11
Fuse 13 (PDC)...................8W-10-5, 6, 13
Fuse 14 (FB)...................8W-10-9, 10, 11
Fuse 15 (FB)...................8W-10-9, 10, 11
Fuse 16 (FB)...................8W-10-9, 10, 11Component Page
Fuse 16 (PDC).....................8W-10-6, 17
Fuse 18 (PDC)................8W-10-5, 6, 14, 15
Fuse 20 (PDC)................8W-10-5, 6, 14, 15
Fuse 21 (PDC)...................8W-10-5, 6, 16
Fuse 23 (PDC)................8W-10-5, 6, 14, 15
Fuse 25 (PDC)................8W-10-5, 6, 14, 15
Fuse Block...................8W-10-8, 9, 10, 11
G101...............................8W-10-9
G204...............................8W-10-7
Generator..........................8W-10-16
Glove Box Lamp And Switch............8W-10-13
Headlamp Switch.....................8W-10-8
High Speed Warning Module...........8W-10-13
Horn..............................8W-10-14
Horn No. 1.........................8W-10-15
Horn No. 2.........................8W-10-15
Horn Relay......................8W-10-14, 15
Ignition Coil Pack....................8W-10-16
Ignition Switch.............8W-10-7, 8, 9, 10, 11
Immobilizer......................8W-10-10, 11
Instrument Cluster.................8W-10-7, 13
Left Fog Lamp......................8W-10-17
Left Visor/Vanity Lamps...............8W-10-13
Map/Reading Lamps..................8W-10-13
Noise Supressor.....................8W-10-16
Power Distribution
Center.....8W-10-5, 6, 7, 8, 12, 13, 14, 15, 16, 17
Power Mirror Switch..................8W-10-13
Powertrain Control Module...........8W-10-9, 16
Radiator Fan Motor..................8W-10-12
Radio..............................8W-10-13
Rear Fog Lamp Switch................8W-10-17
Rear Window Defogger Switch..........8W-10-12
Right Fog Lamp.....................8W-10-17
Right Visor/Vanity Lamps..............8W-10-13
Solid State Fan Relay.................8W-10-12
Stop Lamp Switch.................8W-10-14, 15
Time Delay Relay....................8W-10-13
Time Out Relay......................8W-10-13
Trunk Lamp........................8W-10-13
Turn Signal/Hazard Switch..........8W-10-14, 15
Underhood Lamp....................8W-10-13
Upstream Heated Oxygen Sensor........8W-10-16
PL8W - 10 POWER DISTRIBUTION 8W - 10 - 1

21FUSE20A
21
52
55
60
57
BATT A0
POWER
DISTRIBUTION
CENTER
72
A14
16
RD/WT
A14
16
RD/WT
POWERTRAIN
CONTROL
MODULE
A14
18
RD/WT
5C105
A141
16
DG/WT
A141
18
DG/WT
4
FUEL
PUMP
MODULE
A142
18
DG/OR
S105
22
FUEL
PUMP
RELAYAUTOMATIC
SHUT
DOWN
RELAY
6C161
DG/OR18 A142
GENERATOR
A142
18
DG/ORA142
18
DG/OR
POWERTRAIN
CONTROL
MODULE
SENSOR OXYGEN
HEATED
UPSTREAM
A142
18
DG/ORA142
18
DG/OR
A142
18
DG/OR
A142
18
DG/OR A142
18
DG/ORDG/OR18 A142
DG/OR18 A142 A142
18
DG/OR
IGNITION
COIL
PACKSUPRESSOR
NOISE
S139S121
S122
2
DG/OR18 A142
DG/OR18 A142
2222
2161C2
58
FUEL
INJECTOR
NO. 1 NO. 2INJECTOR
FUEL FUEL
INJECTOR
NO. 3FUEL
INJECTOR
NO. 4
CONNECTORLINK DATA
46C116
(2.0L)
SENSOR
OXYGEN
HEATED
DOWNSTREAM
BUILT-UP-EXPORT) (EXCEPT
CAPACITOR
(8W-30-2) (8W-30-11)(8W-10-5)
(8W-30-11)
(8W-30-2)(8W-10-5)
(8W-10-6)
(8W-20-2)
(8W-30-2)
(8W-30-3)
(8W-30-5) (8W-30-5) (8W-30-5) (8W-30-5) (8W-30-5)(8W-30-4)
(8W-30-3)
8W - 10 - 16 8W-10 POWER DISTRIBUTIONPL
J988W-18205

8W-15 GROUND DISTRIBUTION
Component Page
A/C Compressor Clutch...............8W-15-5, 6
A/C Compressor Clutch Relay..........8W-15-5, 6
A/C Heater Control....................8W-15-9
ABS Warning Lamp Relay............8W-15-7, 8
Airbag Control Module...............8W-15-7, 8
Ash Receiver Lamp................8W-15-10, 11
Battery...........................8W-15-7, 8
Brake Warning Lamp Switch..........8W-15-2, 3
Center High Mounted Stop Lamp.....8W-15-12, 14
Cigar Lighter Relay...................8W-15-11
Cigar Lighter/Power Outlet..........8W-15-10, 11
Clockspring..........................8W-15-7
Combination Flasher.................8W-15-7, 8
Controller Anti-Lock Brake............8W-15-2, 3
Data Link Connector..................8W-15-4
Daytime Running Lamp Module..........8W-15-7
Diode No. 1........................8W-15-5, 6
Downstream Heated Oxygen Sensor.....8W-15-2, 3
Driver Door Lock Switch................8W-15-9
Driver Power Window Switch............8W-15-9
Engine Starter Motor Relay...........8W-15-2, 3
Fog Lamp Relay......................8W-15-3
Fog Lamp Switch....................8W-15-10
Front Fog Lamp Switch...............8W-15-11
Fuel Pump Module................8W-15-12, 13
G101.............................8W-15-2, 3
G102...............................8W-15-4
G103.............................8W-15-5, 6
G104.............................8W-15-7, 8
G105.............................8W-15-7, 8
G110.............................8W-15-7, 8
G111...............................8W-15-8
G201.............................8W-15-7, 8
G202.............................8W-15-7, 8
G203...............................8W-15-9
G204...........................8W-15-10, 11
G301...........................8W-15-12, 13
G302...........................8W-15-12, 14
G303...........................8W-15-12, 13
Glove Box Lamp And Switch.........8W-15-10, 11
Halo Lamp......................8W-15-10, 11
Headlamp Leveling Switch.............8W-15-11
Headlamp Switch.................8W-15-10, 11
High Speed Warning Module............8W-15-8
Horn...............................8W-15-2
Horn No. 1..........................8W-15-6
Horn No. 2..........................8W-15-3
Horn Switches.......................8W-15-7
Ignition Switch...................8W-15-10, 11Component Page
Immobilizer..........................8W-15-8
Instrument Cluster................8W-15-10, 11
Intermittent Wipe/Wash Switch........8W-15-7, 8
Left Back-Up Lamp................8W-15-12, 14
Left Fog Lamp.....................8W-15-5, 6
Left Headlamp.....................8W-15-2, 3
Left Headlamp Leveling Motor...........8W-15-3
Left License Lamp...................8W-15-14
Left Park/Turn Signal Lamp...........8W-15-2, 3
Left Rear Fog Lamp..................8W-15-14
Left Repeater Lamp...................8W-15-3
Left Tail/Stop Lamp..................8W-15-14
Left Tail/Stop/Turn Signal Lamp.........8W-15-12
Left Turn Signal Lamp................8W-15-14
License Lamp.......................8W-15-12
Map/Reading Lamps...............8W-15-10, 11
Power Folding Mirror Relay.............8W-15-9
Power Mirror Switch...................8W-15-9
Power Steering Pressure Switch..........8W-15-4
Power Sunroof Motor..................8W-15-9
Powertrain Control Module..............8W-15-4
PRNDL Lamp....................8W-15-10, 11
Radiator Fan Motor.................8W-15-2, 3
Radio.............................8W-15-7, 8
Rear Fog Lamp Switch................8W-15-11
Rear Window Defogger.............8W-15-12, 13
Rear Window Defogger Switch.........8W-15-7, 8
Remote Keyless Entry Module...........8W-15-7
Right Back-Up Lamp...............8W-15-12, 13
Right Fog Lamp....................8W-15-5, 6
Right Headlamp....................8W-15-5, 6
Right Headlamp Leveling Motor..........8W-15-6
Right License Lamp..................8W-15-14
Right Park/Turn Signal Lamp..........8W-15-5, 6
Right Rear Fog Lamp.................8W-15-13
Right Repeater Lamp..................8W-15-6
Right Tail/Stop Lamp.................8W-15-13
Right Tail/Stop/Turn Signal Lamp.......8W-15-12
Right Turn Signal Lamp...............8W-15-13
Seat Belt Switch..................8W-15-12, 14
Solid State Fan Relay................8W-15-2, 3
Stop Lamp Switch.....................8W-15-4
Sunroof Vent Switch...................8W-15-9
Underhood Lamp...................8W-15-2, 3
Upstream Heated Oxygen Sensor.......8W-15-2, 3
Vehicle Speed Control Servo.............8W-15-2
Vehicle Speed Control Switch............8W-15-7
Windshield Washer Pump Motor........8W-15-2, 3
PL8W - 15 GROUND DISTRIBUTION 8W - 15 - 1

2
RADIATOR
FAN
MOTOR
1
SOLID
STATE
FAN
Z1
18
BKZ1
14
BK
1
Z1
20
BK
HORN
Z1
14
BK
S111
2
2
SENSOR OXYGEN
HEATED
DOWNSTREAM
UPSTREAM
HEATED
SENSOR OXYGEN
Z1
18
BKZ1
18
BK
Z1
18
BK
1C161
Z1
20
BK
31
Z1
18
BK
4
SERVO CONTROL
SPEED
VEHICLE
Z1
20
BK
3LAMP SIGNAL
TURN
PARK/
LEFT
Z1
18
BK
B2
Z1
18
BK
Z1
18
BK
HEADLAMP LEFT
SWITCH LAMP
WARNING
BRAKE
S107 S119
824
CONTROLLER
ANTI-LOCK
BRAKE
B
Z1
12
BKZ1
12
BKZ1
18
BK
MOTOR PUMP
WASHER
WINDSHIELD
Z1
14
BK
Z1
18
BK
G101 S108(MTX) RELAY
MOTOR
STARTER
ENGINE RELAY
1
Z1
18
BK
LAMP UNDERHOOD
C104
2
BK18Z1(8W-21-2)
(8W-53-2)
(8W-53-3) (8W-35-2) (8W-40-7)(8W-50-5)
(8W-52-4) (8W-30-14) (8W-30-3)(8W-30-3) (8W-41-2)
(8W-42-5) (8W-42-5)
(8W-44-7)
8W - 15 - 2 8W-15 GROUND DISTRIBUTION
EXCEPT BUILT-UP-EXPORTPL
J988W-18230

2
RADIATOR
FAN
MOTOR
1
SOLID
STATE
FAN
Z1
18
BKZ1
14
BK
1
Z1
20
BK
Z1
14
BK
S111
22
SENSOR OXYGEN
HEATED
DOWNSTREAM UPSTREAM
HEATED
SENSOR OXYGEN
Z1
18
BKZ1
18
BK
Z1
18
BK
1C161
Z1
20
BK
31
Z1
18
BK
3LAMP SIGNAL
TURN
PARK/
LEFT
Z1
18
BK
2
3
Z1
18
BK
Z1
20
BK
HEADLAMP LEFT
SWITCH LAMP
WARNING
BRAKE
S107 S119
824
CONTROLLER
ANTI-LOCK
BRAKE
B
Z1
12
BKZ1
12
BKZ1
18
BK
MOTOR PUMP
WASHER
WINDSHIELD
3
Z1
22
BK
Z1
14
BKZ1
18
BK
G101 S108 RELAYNO. 2 HORN
MOTOR
LEVELING
HEADLAMP
LEFT
S127
BK18Z1
BK18Z1
LEFT
REPEATER
LAMP
2
FOG
LAMP
RELAY
(IN PDC)
46
BK18Z1
UNDERHOOD
LAMP
(LHD)
2
BK18Z1
(MTX) (IN PDC)
RELAY
MOTOR
STARTER
ENGINE
(8W-42-5)
(8W-42-5)(8W-30-3) (8W-30-3)
(8W-52-5) (8W-50-6)
(8W-40-9)
(8W-35-2)
(8W-53-2)
(8W-53-3) (8W-41-3)
(8W-50-7)
(8W-50-8) (8W-52-5)(8W-50-13)
(8W-44-7)
(8W-21-3)
(8W-21-4)
PL8W-15 GROUND DISTRIBUTION
BUILT-UP-EXPORT8W - 15 - 3
8231J988W-1

8W-30 FUEL/IGNITION SYSTEMS
Component Page
A/C Compressor Clutch Relay...........8W-30-12
A/C High Pressure Switch..............8W-30-12
Airbag Control Module.................8W-30-4
Automatic Shut Down Relay...........8W-30-2, 3
Battery Temperature Sensor...........8W-30-3, 7
Camshaft Position Sensor............8W-30-7, 16
Center High Mounted Stop Lamp........8W-30-15
Clockspring.........................8W-30-14
Controller Anti-Lock Brake...........8W-30-4, 15
Crankshaft Position Sensor...........8W-30-7, 16
Data Link Connector.................8W-30-2, 4
Downstream Heated Oxygen Sensor.......8W-30-3
Duty Cycle Evap/Purge Solenoid.......8W-30-9, 10
EGR Transducer Solenoid............8W-30-9, 10
Engine Coolant Temperature Sensor.......8W-30-7
Engine Starter Motor Relay............8W-30-13
Fuel Injector No. 1....................8W-30-5
Fuel Injector No. 2....................8W-30-5
Fuel Injector No. 3....................8W-30-5
Fuel Injector No. 4....................8W-30-5
Fuel Pump Module...................8W-30-11
Fuel Pump Relay.....................8W-30-11
Fuse 10 (FB)...................8W-30-9, 10, 11
Fuse 21 (PDC).................8W-30-2, 3, 4, 11
Fuse 25 (PDC).......................8W-30-15
Fuse Block.....................8W-30-9, 10, 11
G101............................8W-30-3, 14
G102.......................8W-30-2, 4, 14, 15Component Page
G202..............................8W-30-14
G303..............................8W-30-11
Generator..........................8W-30-12
Iat/Map Sensor.......................8W-30-6
Idle Air Control Motor.................8W-30-8
Ignition Coil Pack.....................8W-30-5
Immobilizer.....................8W-30-3, 8, 16
Immobilizer Engine Sensor.............8W-30-16
Instrument Cluster............8W-30-7, 8, 11, 12
Knock Sensor........................8W-30-6
Noise Supressor......................8W-30-5
Park/Neutral Position Switch...........8W-30-13
Power Distribution Center.....8W-30-2, 3, 4, 11, 15
Power Steering Pressure Switch..........8W-30-4
Powertrain Control
Module..........8W-30-2, 3, 4, 5, 6, 7, 8, 9, 10,
11, 12, 13, 14, 15, 16
Solid State Fan Relay.................8W-30-12
Stop Lamp Switch.................8W-30-14, 15
Throttle Position Sensor................8W-30-6
Torque Converter Clutch Solenoid......8W-30-9, 10
Turn Signal/Hazard Switch.............8W-30-15
Upstream Heated Oxygen Sensor.........8W-30-3
Vapor Canister Leak Detector............8W-30-9
Vehicle Speed Control Servo.........8W-30-14, 15
Vehicle Speed Control Switch...........8W-30-14
Vehicle Speed Sensor................8W-30-8, 16
PL8W - 30 FUEL/IGNITION SYSTEMS 8W - 30 - 1