parking brake FIAT 500 2018 Owner handbook (in English)

READ THIS CAREFULLY
REFUELLING
Petrol engines: Only refuel with unleaded petrol with octane rating (RON) not less than 95, in compliance with the European
specification EN228. Do not use petrol containing methanol or ethanol E85. Using these mixtures may cause misfiring and driving
issues, as well as damage fundamental components of the supply system.
Diesel engines: refuel only with Diesel fuel motor vehicles conforming to the European specification EN590. The use of other
products or mixtures may damage the engine beyond repair and consequently invalidate the warranty, due to the damage caused.
For further details on the use of the correct fuel see the “Refuelling the vehicle” paragraph in the “Starting and driving” chapter.
STARTING THE ENGINE
Versions with manual gearbox (petrol engines): make sure that the handbrake is engaged, put the gear in neutral, fully
depress the clutch without pressing the accelerator, then turn the ignition key to AVV and release it as soon as the engine has
started.
Versions with manual gearbox (diesel engines): make sure that the handbrake is engaged, put the gear in neutral, fully
depress the clutch pedal without pressing the accelerator, then turn the ignition key to MAR and wait for the
mwarning
lights to switch off. Turn the ignition key to AVV and finally release it as soon as the engine starts.
Versions with automatic transmission: make sure that the handbrake is engaged and that the gear lever is in P (Parking) or N
(Neutral), fully depress the brake pedal, then turn the ignition key to AVV.
PARKING ON FLAMMABLE MATERIAL
The catalytic converter develops high temperatures during operation. Do not park the car on grass, dry leaves, pine needles or
other flammable material: fire hazard.
RESPECTING THE ENVIRONMENT
The vehicle is fitted with a system that carries out a continuous diagnosis of the emission-related components in order to help
protect the environment.
ELECTRICAL ACCESSORIES
If, after buying the vehicle, you decide to add electrical accessories (with the risk of gradually draining the battery), contact a Fiat
Dealership. They can calculate the overall electrical requirement and check that the electric system of the vehicle can support the
required load.
SCHEDULED SERVICING
Correct maintenance of the car is essential for ensuring that it maintains its performance and its safety features, its environmental
friendliness and low running costs for a long time to come.
K



19
ESC SYSTEM (for versions/markets, where required)
The warning light switches on when the ignition key is turned to MAR, but it should switch off after a few seconds.
ESC system activation
Flashing of the warning light while driving indicates the intervention of the ESC system.
ESC system failure
If the warning light does not go off or stays on together with the LED on the ASR OFF button while driving.
The display will show a dedicated message.
Contact a Fiat Dealership.
Hill Holder failure
This warning light switches on, on some versions together with a dedicated message on the display, in the event of a Hill
Holder system fault.
In this case, contact a Fiat Dealership as soon as possible. Parking sensor fault
The warning light turns on and the dedicated message is shown on the display when a parking sensor fault is detected.
Start&Stop system fault (versions with multifunction display)
A fault of the system is indicated by the warning light switching on. A dedicated message will appears on the instrument
panel.
Airbag warning light fault (for versions/markets, where provided)
The warning light will blink when a fault of the
¬warning light is detected.
ESCESC
BRAKE PAD WEAR
The warning light switches on, together with a dedicated message on the display, if the front or rear brake pads (on
version/markets, where provided) are worn.
In this case have them replaced as soon as possible.
dd
POSSIBLE ICE ON ROAD
The symbol is shown on the display (on some versions together with a dedicated message) when the outside temperature
is equal to or below 3°C.
èè
(versions with
multifunction
display)
(versions with
multifunction
display)

STARTING AND DRIVING
120
PARKING THE
VEHICLE
When parking and leaving the car,
proceed as follows:
❒ engage a gear (1st gear if facing
uphill or reverse if facing downhill)
and leave the wheels turned;
❒ stop the engine and engage the
handbrake;
❒ always remove the key from the
starter switch.
Block the wheels with a wedge or a
stone if the car is parked on a steep
slope.
On versions equipped with automatic
transmission, wait for the letter P to be
displayed before releasing the brake
pedal.
IMPORTANT NEVER leave the car with
the gearbox in neutral (or, on versions
equipped with automatic transmission,
before putting the shift lever at P).
HANDBRAKE 27)
The handbrake lever fig. 86 is located
between the two front seats.
To use the handbrake pull the lever
upwards until the car cannot be
moved.
To release the handbrake, raise the
lever slightly and press the release
button A fig. 86; hold down the button
and lower the lever.
86DVDF0S162c
USING THE MANUAL
GEARBOX
28) 14)
To engage the gears, press the clutch
pedal fully and put the gear lever into
one of the required positions (the
diagram is shown on the knob fig. 87).
For cars provided with 6-speed
gearbox, to engage the 6
thgear,
operate the lever by pressing it
towards the right in order to avoid
engaging the 4
thgear by mistake. The
same applies to shifting from 6thto 5th
gear.
87DVDF0S0156c

131
“Fix&Go” KIT
33) 31)
DESCRIPTION
The Fix&Go quick tyre repair kit fig. 105
is located in the luggage compartment,
inside a dedicated container, and
consists of:
❒ one cartridge 1 containing sealant
and fitted with: transparent tube for
injecting the sealant 4 and sticker 3
with the wording “Max 80 km/h” to
be placed in a clearly visible position
(e.g. on the dashboard) after
repairing the tyre;
❒ one compressor 2;
❒ one leaflet containing instructions
for using the kit;
❒ a pair of gloves located in the hose
compartment of the cartridge 4.
REPAIR PROCEDURE
Proceed as follows:
❒ stop the car in a position that is not
dangerous for oncoming traffic
where you can carry out the
procedure safely. The ground must
be flat and sufficiently compact;
❒ stop the engine, engage the hazard
warning lights and the parking
brake;
❒ wear the reflective safety jacket
before getting out of the car (in any
case, comply with the laws in force
in the country you are driving in);
105DVDF0S0230
❒ insert the cartridge 1 containing the
sealant into the dedicated
compartment on the compressor 2
and press it down hard fig. 105.
Remove the adhesive speed label 3
and apply it in a clearly visible
position fig. 106;
❒ wear the gloves;
❒ remove the valve cap from the
punctured tyre and screw the
transparent sealant hose 4 fig. 105
onto the valve. If a 250 ml cartridge
is present the housing of the
transparent tube is provided with
removable ring to facilitate
extraction. Make sure that the
ON-OFF button 5 fig. 107 is in the
off position (button not pressed);
106DVDF0S0234

IN AN EMERGENCY
142
FuseAmpereDescription
F13 5 •
Left dipped headlight and headlight alignment control unit power supply
F36 15 Diagnosis socket, radio, climate control, EOBD
F37 5 Brake light switch, instrument panel node
F38 15 Central door locking
F43 15 Windscreen/rear window washer pump
F47 20 Driver’s side power window
F48 20 Passenger’s side power window
F49 5 Parking sensor, control backlighting, electric mirrors
F51 7.5 Climate control, brake lights, clutch, sunroof, electric mirrors
F53 5 Instrument panel node
•
For versions/markets, where provided
ENGINE COMPARTMENT
JUNCTION BOX
The fuse box is located on the right
side of the engine compartment.
To access the fuses, proceed as
follows:
❒ Fully press the screw A fig. 130;
❒ at the same time slowly rotate the
screw anticlockwise, until resistance
is encountered (do not overtighten);
❒ slowly release the screw;
❒ opening is indicated by the entire
screw head coming out of its
housing;
❒ remove cover B, sliding it upwards
on the side guides, as indicated in
the figure.
❒ after replacing the fuse, refit the
cover, making sure that it is closed
properly.
130DVDF0S0201c

IMPORTANT INFORMATION AND RECOMMENDATIONS
190(CONTINUES)
PERSONAL SAFETY
(CONTINUED)
•The HH system is not a parking brake, therefore do not leave
the vehicle without activating the handbrake, switching off the
engine, and engaging first gear, with the vehicle parked in safe
conditions.
•There may be situations on small gradients
(less than 8%), with car laden or a trailer attached to it (where
provided), in which the HH system may not activate, causing a
slight reversing motion and increasing the risk of collision with
another vehicle or object.
The driver is, in any case, responsible for safe driving.
•The HBA system cannot increase tyre grip on the road over
the limits imposed by laws of physics: always drive carefully
according to the conditions of the road surface.
•The HBA system is an aid for the driver, who must always pay
full attention while driving.
The responsibility always rests with the driver.
16) ENGINE BONNET
•Before opening the bonnet, check that windscreen wiper
arm is not lifted from the windscreen.
•The bonnet may drop suddenly if the supporting rod is not
positioned correctly.
Only perform these operations when the car is stationary.
•Be careful working inside engine compartment when the
engine is hot to avoid burning yourself. Do not place your
hands near the engine fan as it may be activated even when
the key is removed. Wait until the engine has cooled.
•Be very careful not to allow scarves, neck ties and other
loose articles of clothing from touching, even accidentally, any
moving parts. This may cause the clothing to be pulled into the
part, resulting in serious injury to the wearer. •For safety reasons, the bonnet must always be properly closed
while the car is travelling. Make sure that the bonnet is properly
closed and that the lock is engaged. If you notice when driving
that the bonnet has not been properly locked, stop immediately
and close the bonnet correctly.
•Use both hands to lift the bonnet. Before lifting, check that the
windscreen wiper arms are not raised from the windscreen, that
the vehicle is stationary and that the handbrake is engaged.
17) CONTROLS
•It is absolutely forbidden to carry out any after-market operation
involving steering system or steering column modifications
(e.g. installation of anti-theft device) that could adversely affect
performance and safety, invalidate the warranty and also result in
non-compliance of the vehicle with type-approval requirements.
•Before performing any maintenance operations, always stop
the engine and remove the key from the ignition to lock the
steering column (especially when the car wheels are not touching
the ground). If this is not possible (for example if the key needs to
be turned to MAR or the engine must be running), remove the
main fuse that protects the electric power steering.
18) PARKING SENSORS
Parking manoeuvres, however, are always the driver’s
responsibility. While carrying out these manoeuvres, always make
sure that no people (especially children) or animals are in the area
concerned.
The parking sensors are used to assist the driver, who must
never allow his attention to lapse during potentially dangerous
manoeuvres, even those executed at low speeds.

195
•Remember that the servo-brake and power steering are not
operational until the engine has been started, therefore much
effort than usual is required on the brake pedal and steering
wheel.
•For vehicles featuring a Dualogic gearbox, if the engine is not
started with a gear engaged, a warning is sounded to notify
the driver of the potential danger due to the gear being
automatically put into neutral.
•This starting procedure must be performed by expert
personnel because incorrect actions could cause electrical
discharge of considerable intensity. Furthermore, battery fluid
is poisonous and corrosive: avoid contact with skin and eyes.
Keep naked flames and lighted cigarettes away from the
battery and do not cause sparks.
•Remove any metal objects (e.g. rings, watches, bracelets),
that might cause an accidental electrical contact and cause
serious injury.
•Do not attempt to charge a frozen battery: it must be thawed
first, otherwise it may explode.
If freezing has occurred, the battery should be checked by
skilled personnel to make sure that the internal elements are
not damaged and that the body is not cracked, with the risk of
leaking poisonous and corrosive acid.
27) HANDBRAKE
• The car should be braked after a few clicks of the lever, if it is
not, contact a Fiat Dealership to have it adjusted.
• Never leave children in the unattended car. Always remove
the ignition key when leaving the car and take it out with you. • In the case of parking manoeuvres on roads on a gradient, the
front wheels must be steered towards the pavement
(when parking downhill), or in the opposite direction if the vehicle
is parked uphill. Block the wheels with a wedge or a stone if the
car is parked on a steep slope.
28) USING THE MANUAL GEARBOX
Press the clutch pedal fully to change gears correctly. It is
therefore essential that there is nothing under the pedals: make
sure the mats are lying flat and do not get in the way of the pedals.
29) TOWING TRAILERS
•The ABS with which the car is equipped will not control the
braking system of the trailer. Particular caution is required on
slippery roads.
•Do not, under any circumstances, modify the vehicle braking
system to control the trailer breaking system.
The towing braking system must be completely independent of the
vehicle’s hydraulic system.
30) SNOW TYRES
The maximum speed for snow tyres marked
“Q” is 160 km/h, while it is 190 km/h for “T” tyres and 210 km/h for
“H” tyres.
The highway code speed limits must however always be complied
with.
31) WARNING LIGHTS AND MESSAGES
•If the warning light
xturns on when travelling (on certain
versions together with the message on the display) stop the car
immediately and contact a Fiat Dealership.
(CONTINUES)
PERSONAL SAFETY
(CONTINUED)