number light FIAT PANDA 2009 169 / 2.G User Guide

156KNOW
YOUR VEHICLE
SAFETY
CORRECT USE
OF THE CAR
WARNING LIGHTS
AND MESSAGES
IN
AN EMERGENCYCAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
F0Z0099m
fig. 155
F0Z0098m
fig. 154
F0Z0100m
fig. 156
NUMBER PLATE LIGHTS
To change the bulb, proceed as follows:❒
use a screwdriver to remove the retaining spring as
shown fig. 155 and remove the lens A-fig. 156; take out
the bulb B from the bulb-holder;
❒
replace the 12 V - 5 W pressure-fit bulb in the bulb-
holder and refit the lens. Figure 154
D 12 V – 21 W bulb for reversing light on right light unit;
❒
rear fog light on left light unit;
❒
on right-hand drive versions, reversing light in the
left rear light unit and rear fog lamp in the right rear
light unit;
E 12 V – 21 W bulb for the direction indicators;
F 12 V – 21/5 W double-light bulb for stop light and tail
lights.
135-168 PANDA EN 7-10-2009 14:07 Pagina 156

161KNOW
YOUR VEHICLE
SAFETY
CORRECT USE
OF THE CAR
WARNING LIGHTS
AND MESSAGESIN
AN EMERGENCYCAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
FUSE LOCATION
Fuse-boxes are located on the steering wheel left-hand
side fig. 166 and 167.
To gain access to the fuse-boxes, undo the cover F fas-
tening screw E.
G wired control unit.
H body-computer control unit.
D fuse extracting pliers.
The number identifying the electrical component corre-
sponding to each fuse is on the cover back.
fig. 167 fig. 166
F37
18
9
16
F0Z0139m
F0Z0260m
135-168 PANDA EN 7-10-2009 14:07 Pagina 161

162KNOW
YOUR VEHICLE
SAFETY
CORRECT USE
OF THE CAR
WARNING LIGHTS
AND MESSAGES
IN
AN EMERGENCYCAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
A second fuse-box is located on the right-hand of the en-
gine compartment, next to the battery; to reach it re-
lease the spring I, the tabs M and remove the lid L.
The number identifying the electrical component corre-
sponding to each fuse is on the cover back.
fig. 168
fig. 169
F0Z0652m
F0Z0704m
Fuses in the engine compartment fig. 168 and 169
135-168 PANDA EN 7-10-2009 14:07 Pagina 162

191KNOW
YOUR VEHICLE
SAFETY
WARNING LIGHTS
AND MESSAGES
IN
AN EMERGENCY
CAR
MAINTENANCETECHNICAL
SPECIFICATIONSINDEX
TECHNICAL SPECIFICATIONS
IDENTIFICATION DATAIt is advisable to take note of the identification codes. The
identification data stamped and shown on the data plates
and their position are the following fig. 190:
1 Identification data plate.
2 Chassis marking.
3 Bodywork paint identification plate.
4 Engine marking.
IDENTIFICATION DATA PLATE fig. 191
The data plate is located on the left side of the boot floor
and it bears the following identification data:B
Type-approval number.
C
Vehicle type identification code.
CORRECT USE OF THE
CAR
D
Chassis manufacture progressive number.
E
Maximum allowed vehicle weight fully loaded.
F
Maximum allowed vehicle weight fully loaded with trail-
er.
G
Maximum allowed weight on first axle (front).
H
Maximum allowed weight on second axle (rear).
I
Engine type.
L
Bodywork version code.
M
Spare part number.
N
Smoke opacity index (for diesel engines).
F0Z0219m
fig. 190
F0Z0702m
fig. 191
191-214 PANDA EN 7-10-2009 14:17 Pagina 191

192
KNOW YOUR
VEHICLE
SAFETY
CORRECT USE OF
THE CAR
WARNING LIGHTS
AND MESSAGES
IN
AN EMERGENCY
CAR
MAINTENANCETECHNICAL
SPECIFICATIONS
INDEX
F0Z0114m
fig. 192
F0Z0220m
fig. 193
CHASSIS MARKING fig. 193
The plate is located on the right side of the boot floor and
it bears the following identification data:❒
vehicle type (ZFA 169000);
❒
the chassis progressive number.
ENGINE MARKING
Engine marking is stamped on the cylinder block and in-
cludes the model and the chassis progressive number. BODYWORK PAINT IDENTIFICATION PLATE
fig. 192
The plate is applied on the external tailgate post (left side)
and it bears the following data:
A
Paint manufacturer.
B
Colour name.
C
Fiat colour code.
D
Paint respray and touch-up code.
191-214 PANDA EN 7-10-2009 14:17 Pagina 192

187A1000
Otto
4 in line
70 × 72
1108
9.6 : 1
40
54
5000
88
9.0
2750
NGK DCPR7E-N-10
BOSCH YR7DEU
Unleaded petrol
95 R.O.N.
169A1000
Diesel
4 in line
69.6 × 82
1248
17.6 : 1
55
75
4000
145
14.8
1500
–Diesel fuel for
motor vehicles
(EN 590 standard)
188A8000
Diesel
4 in line
69.6 × 82
1248
18 : 1
51
70
4000
145
14.8
1500
–Diesel fuel for
motor vehicles
(EN 590 standard)
169A4000
Otto
4 in line
70.8 × 78.86
1242
11.1 : 1
51
69
5500
102
10.4
3000NGK ZKR7A-10
Unleaded petrol
95 R.O.N.
188A4000
Otto
4 in line
70.8 × 78.86
1242
9.8 : 1
44
60
5000
102
10.4
2500
NGK DCPR7E-N-10
BOSCH YR7DEU
Unleaded petrol
95 R.O.N.
194
KNOW YOUR
VEHICLE
SAFETY
CORRECT USE OF
THE CAR
WARNING LIGHTS
AND MESSAGES
IN
AN EMERGENCY
CAR
MAINTENANCETECHNICAL
SPECIFICATIONS
INDEX
ENGINEGENERAL INFORMATIONType codeCycleNumber and layout of cylindersPiston bore and stroke mmTotal displacement cm
3
Compression ratio
Max power (EEC) kW
HP corresponding speed rpm
Max. torque (EEC) Nm
kgm corresponding speed rpm
Spark plugs Fuel
1.1 1.2
(Euro 4)1.2
(Euro 5)1.3 Multijet
70 HP1.3 Multijet
75 HP
191-214 PANDA EN 7-10-2009 14:17 Pagina 194

198
KNOW YOUR
VEHICLE
SAFETY
CORRECT USE OF
THE CAR
WARNING LIGHTS
AND MESSAGES
IN
AN EMERGENCY
CAR
MAINTENANCETECHNICAL
SPECIFICATIONS
INDEX
UNDERSTANDING RIM MARKING fig. 197
Example: 5,00 B × 13 H2
5,00 = rim width in inches
1.
B = rim drop centre outline (side projection where the
tyre bead rests)
2.
13 = rim nominal diameter in inches (corresponds to di-
ameter of the tyre to be mounted)
3= Ø.
H2 = shape and number of humps (contour used for
withholding tubeless tyre beads on the rim). Maximum speed rating
Q = up to 160 km/h.
R = up to 170 km/h.
S = up to 180 km/h.
T = up to 190 km/h.
U = up to 200 km/h.
H = up to 210 km/h.
V = up to 240 km/h.
Maximum speed rating for
snow tyres
QM + S = up to 160 km/h.
TM + S = up to 190 km/h.
HM + S = up to 210 km/h.
Load rating (capacity)
70 = 335 kg 78 = 425 kg 86 = 530 kg
71 = 345 kg 79 = 437 kg 87 = 545 kg
72 = 355 kg 80 = 450 kg 88 = 560 kg
73 = 365 kg 81 = 462 kg 89 = 580 kg
74 = 375 kg 82 = 475 kg 90 = 600 kg
75 = 387 kg 83 = 487 kg 91 = 615 kg
76 = 400 kg 84 = 500 kg
77 = 412 kg 85 = 515 kg
191-214 PANDA EN 7-10-2009 14:17 Pagina 198

217KNOW
YOUR VEHICLE
SAFETY
CORRECT USE
OF THE CAR
WARNING LIGHTS
AND MESSAGES
IN
AN EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONSINDEX
Electric and electronic device
installation ................................... 86
– radio transmitters and
mobile phones ........................ 87
Electrical/electronic devices ...... 86
Emergency starting ...................... 113
– starting with auxiliary
battery ..................................... 135
– with inertia bumps.................. 136
Engine code ................................... 193
Engine compartment
– bonnet opening/closing ........ 69
– level check .............................. 175
– washing .................................... 189
Engine coolant level .................... 15
– engine coolant type ............... 203
Engine coolant
– level check and top-up ......... 177
– specifications .......................... 205
Engine coolant
– level check and top-up ......... 177
– specifications .......................... 205
– temperature gauge and
warning light ........................... 15Engine cooling
– level check and top-up .......... 177
– specifications .......................... 205
Engine marking ............................. 192
Engine oil consumption .............. 203
Engine oil check ........................... 176
– consumption ........................... 203
– engine oil specifications ....... 203
Engine oil top-up .......................... 176
– specifications .......................... 203
Engine oil
– consumption ........................... 176
– level check and top-up ......... 176
– technical specifications ......... 203
Engine revolution number
indicator (rev counter) ............ 14
Engine starting .............................. 111
– emergency starting ......... 113-135
– engine heating ........................ 112
– engine switching off .............. 113
– ignition switch ........................ 10
– procedure for Diesel
versions ................................... 112 Direction indicators
– front bulb replacement ........ 152
– rear bulb replacement .......... 155
– side bulb replacement .......... 154
– switching on ............................ 49
Direction indicators
– front bulb replacement ........ 154
– rear bulb replacement .......... 155
– switching on ............................ 49
Door locking ................................ 61
Doors
– central locking ........................ 61
– child lock ................................. 62
– locking/unlocking from
the inside ................................. 61
– locking/unlocking from the
outside ..................................... 61
– remote control ...................... 7
– remote opening/closing ....... 7
DPF (diesel particulate filter) ..... 90
Dualdrive electric power
steering .................................... 53-80
215-224 PANDA EN 7-10-2009 15:09 Pagina 217