Window FIAT PANDA 2009 169 / 2.G Owner's Guide

187KNOW
YOUR VEHICLE
SAFETY
CORRECT USE
OF THE CAR
WARNING LIGHTS
AND MESSAGES
IN
AN EMERGENCYCAR
MAINTENANCETECHNICAL
SPECIFICATIONS
INDEX
F0Z0116m
fig. 188
F0Z0117m
fig. 189
Rear window washer fig. 189
Rear window washer jets are fixed.
The nozzle holder is on the rear window. SPRAY NOZZLES
Windscreen washer fig. 188
If the jet of fluid is inadequate, firstly check that there is
fluid in the reservoir: (see “Checking fluid levels” in this
chapter).
Then check that the nozzle holes are not clogged, if nec-
essary clean them using a needle.
The windscreen jets are directed by adjusting the nozzle
angle.
Fluid jets shall be directed at about
1/3height from the win-
dow upper edge.
169-190 PANDA EN 7-10-2009 14:15 Pagina 187

189KNOW
YOUR VEHICLE
SAFETY
CORRECT USE
OF THE CAR
WARNING LIGHTS
AND MESSAGES
IN
AN EMERGENCYCAR
MAINTENANCETECHNICAL
SPECIFICATIONS
INDEX
Glasses
To clean glasses, use specific window cleaner products.
Also use clean cloths to avoid scratching the glass or dam-
aging the transparency.
IMPORTANT Wipe the rear window inside gently with
a cloth in the direction of the filaments to avoid damag-
ing the heating device.
Engine compartment
At the end of the winter the engine compartment should
be carefully washed, without directing the jet against any
electronic control unit. Have this operation performed
at a specialised workshop.
IMPORTANT The washing should take place with the en-
gine cold and the ignition key in the
STOP
position. After
the washing operation, make sure that the various pro-
tections (e.g. rubber caps and guards) have not been re-
moved or damaged.
Front headlights
IMPORTANT Never use aromatic substances (e.g.: petrol)
or ketenes (e.g.: acetone) for cleaning front headlight plas-
tic lens. To correctly wash the vehicle, proceed as follows:
❒
remove the aerial from the roof to prevent damage to
it if the car is washed in an automatic system;
❒
wash the body using a low pressure jet of water;
❒
wipe a sponge with a slightly soapy solution over the
bodywork, frequently rinsing with the sponge;
❒
rinse well with water and dry with a jet of air or
a chamois leather.
Dry the less visible parts, such as the door frames, bonnet
and the headlight frames with special care, as in these ar-
eas water may stagnate more easily. The car should not
be taken to a closed area immediately, but left outside so
that residual water can evaporate.
Do not wash the car after it has been left in the sun or
with the bonnet hot: this may alter the shine of the paint-
work.
Exterior plastic parts must be cleaned in the same way as
the rest of the car.
Where possible, do not park under trees; the resinous
substance many species release give the paint a dull ap-
pearance and increase the possibility of triggering rust
processes.
IMPORTANT Bird droppings must be washed off imme-
diately and thoroughly as the acid they contain is particu-
larly aggressive.
Detergents cause water pollution. The vehi-
cle should be washed in areas equipped for
collecting and cleaning the liquid used in the
washing process.
169-190 PANDA EN 7-10-2009 14:15 Pagina 189

Unleaded petrol with no less
than 95 R.O.N.
(▲)Diesel fuel for motor vehi-
cles (EN 590 standard)
Mixture of 50% distilled water
and PARAFLU
UP
50% (❑)
SELENIA 20K
(●) SELENIA WR
TUTELA CAR ZC 75 SYNTH
TUTELA TOP 4
Mixture of water and
TUTELA PROFESSIONAL SC
35
203KNOW
YOUR VEHICLE
SAFETY
CORRECT USE OF THE
CAR
WARNING LIGHTS
AND MESSAGES
IN
AN EMERGENCY
CAR
MAINTENANCETECHNICAL
SPECIFICATIONSINDEX
35 (▲)
5 (▲)
4.6
2.8 (●)
3.0 (●)
1.65
0.55
0.40
1.8
35
5
4.6
2.5
2.8
1.65
0.55
0.40
1.8
35
5
4.6
3.1
3.5
1.65
0.55
0.40
1.8
CAPACITIES
1.1 1.2 1.3 Specified fuels and
Multijet recommended products
Fuel tank: litres
including a reserve of: litresEngine cooling system:
litres
Engine sump: litres
Engine sump and filter: litres
Gearbox/differential casing:
litres
Hydraulic brake circuit:
– with ABS kg
– without ABS kg
Windscreen and rear window
washer fluid reservoir: litres
(❑) When the vehicle is used under particularly harsh climate conditions, we recommend using a mixture of 60% PARAFLU
UP
and 40% dem-
ineralised water.
191-214 PANDA EN 7-10-2009 14:18 Pagina 203

Front
mechanicalgear-box
and differentials
Rear differential
4×4 versions
Wheel side
constant velocity
joints
Differential side
constant velocity
joints
Hydraulic brakes
and hydraulic
clutch controls
Cooling circuits Util-
isation percentage:
50% water
50% PARAFLU
UP
To be mixed with
diesel (25 cc per
10 litres)
To be used undiluted
or diluted in wind-
screen/rear window
washer/ wiper systems
Synthetic lubricant, SAE 75W-85 grade.
FIAT 9.55550-MX3specifications
Synthetic lubricant, SAE 75W-85 grade.
FIAT 9.55550-DA4specifications
Molybdenum disulphide grease for high tempera-
tures. Consistency NLGI 1-2 FIAT 9.55580speci-
fications
Polyurea based synthetic grease for high tempera-
tures. Consistency NLGI 2. FIAT 9.55580specifi-
cations
Synthetic fluid for brake and clutch systems. It pass-
es the specifications: FMVSS no. 116 DOT 4,
ISO 4925, SAE J 1704. FIAT 9.55597 specifications
Red protective agent with antifreeze action, based
on inhibited monoethylene glycol with organic for-
mula. It passes CUNA NC 956-16, ASTM D 3306
specifications. FIAT 9.55523specifications
Antifreeze additive for diesel fuel, protecting
Diesel engines
Mixture of alcohol and surfactants
CUNA NC 956-11. FIAT 9.55522specifications
TUTELA CAR
TECHNYX Contractual Technical
Reference no. F010.B05TUTELA CAR
CROSS Contractual Technical
Reference no. F804.D08TUTELA ALL
STARContractual Technical
Reference no. F702.G07TUTELA STAR
325Contractual Technical
Reference no. F301.D03TUTELA TOP 4Contractual Technical
Reference no. F001.A93PARAFLU
UP
Contractual Technical
Reference no. F101.M01TUTELA DIESEL
ARTContractual Technical
Reference no. F601.L06TUTELA PROFES-
SIONAL SC 35Contractual Technical
Reference no. F201.D02
Use Quality specifications of fluids and lubricants Fluids and lubricants Applications
for correct car operation recommended
Lubricants and
greases for drive transmission
systemBrake fluidProtective agent
for radiatorsFuel additiveWindscreen/
rear screen
washer fluidIMPORTANT Do not use fluids with different specifications for topping-up or mixing
205KNOW
YOUR VEHICLE
SAFETY
CORRECT USE OF THE
CAR
WARNING LIGHTS
AND MESSAGES
IN
AN EMERGENCY
CAR
MAINTENANCETECHNICAL
SPECIFICATIONSINDEX
191-214 PANDA EN 7-10-2009 14:18 Pagina 205

216KNOW
YOUR VEHICLE
SAFETY
CORRECT USE
OF THE CAR
WARNING LIGHTS
AND MESSAGES
IN
AN EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONSINDEX
– interior ..................................... 158
Bulb types ...................................... 150
Bulbs
– bulb types ................................ 150
– generals instructions for
replacement ............................ 149Car inactivity ............................... 122
Car maintenance..................... 169
Car speed indicator
(speedometer) ........................... 14
Car washing
– engine compartment ............ 189
– exterior ................................... 189
– interior ..................................... 190
Carrying children ......................... 98
Ceiling light switching-on/off ..... 68
Central locking ............................. 61
Cigar lighter .................................. 55
Climate control system .............. 43
Climate control system
controls .................................. 41-44
Climate control system vents ... 41
Clock adjustment ................... 16-18Clock
– adjustment ........................... 16-18
Clutch
– technical specifications ......... 195
CO
2emissions ............................. 207
CODE card ................................... 6
Control buttons ........................... 53
Controls (pushbuttons) ............. 53
Correct use of the car.......... 111
Current sockets ........................... 58
Changing a wheel ......................... 137
– general information
and warnings ........................... 137
– tyre and wheel types ............ 199
– tyre inflation pressure .......... 199
Child lock ...................................... 62
Child seats ..................................... 103
– fitness for child seat use ...... 101
– preparation for child seats .. 103
Children (carrying in safety) ..... 98
– preparation for Isofix seat
mounting ................................. 103
Dashboard .................................... 3Defrosting-demisting
– rear window ........................... 40
– windscreen and front side
windows ........................... 39-42-46
Demisting-defrosting
– door mirrors .......................... 36
– rear window ........................... 40
– windscreen and side
front windows ............... 39-42-46
Diesel particulate filter (DPF) ... 90
Digital display ................................ 16
– control buttons ...................... 16
– standard screen ..................... 16
– warning light test .................... 17
Dipped headlights (lights)
– bulb replacement ................... 153
– switching-on ........................... 48
Dipped headlights
– bulb replacement ................... 153
– switching on ............................ 48
Direction indicator
– front bulb replacement ........ 154
– rear bulb replacement .......... 155
– switching on ............................ 49
215-224 PANDA EN 7-10-2009 15:09 Pagina 216

219KNOW
YOUR VEHICLE
SAFETY
CORRECT USE
OF THE CAR
WARNING LIGHTS
AND MESSAGES
IN
AN EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONSINDEX
Fuse replacement
– fuse location
(control units) ............. 161-162
– general information
and warnings ........................... 160
– list .......................... 163-164-165
Fuse summary
table ...............................163-164-165
Fuses:
– fuse location
(central units) ...................161-162
– general instructions
and warnings ........................... 160G
earbox use ................................ 114
Gearbox ......................................... 114
– technical specifications ......... 195
Gearshifting lever ........................ 114
Glove compartment ................... 57
Glove compartments .................. 57
Gloveboxes ................................... 56
H
andbrake ................................... 113
Handbrake lever .......................... 113Hazard warning lights
– switching on ............................ 53
Headlight aiming
(corrector) ................................. 72
Headlight
– alignment corrector .............. 72
– bulb replacement ................... 153
– bulbs (type) ............................. 150
Headlights
(switching on controls) ............ 48
Headlights ...................................... 72
– adjusting the headlights when
abroad ...................................... 73
– beam adjustment ................... 72
– bulb replacement ................... 153
– headlight beam aiming .......... 72
Headrests
– front ......................................... 33
– rear ........................................... 34
Headrests
– front ......................................... 33
– rear ........................................... 34
Heated rear window....... 54-55-72
Heating and ventilation system ... 37Heating and ventilation .............. 37
– adjustable side and
centre vents ............................ 37
– controls ................................... 38
– front window
defrosting/demisting ............. 39
– passenger compartment
heating and ventilation ......... 39
– rear window defrosting/
demisting ................................. 40
Hill holder system ....................... 76
Ignition barrel .............................. 10
Ignition switch .............................. 10
Ignition switch and steering
column lock ................................ 9-10
Ignition switch .............................. 9
In an emergency..................... 135
Installing the tow hook .............. 118
Instrument panel .......................... 11
Interior equipment ...................... 55
Interior fittings ............................. 55
Interiors (cleaning) ...................... 190
Internal lighting ............................. 52
215-224 PANDA EN 7-10-2009 15:09 Pagina 219

220KNOW
YOUR VEHICLE
SAFETY
CORRECT USE
OF THE CAR
WARNING LIGHTS
AND MESSAGES
IN
AN EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONSINDEX
Isofix (child seat)
– fitness for child seat use........ 101
– preparation for child
seat use .................................... 103Jack
– warnings .................................. 137
– use ...................................... 137-143
Jets
– windscreen/rear window
washer ..................................... 187Keys ............................................... 6
– door opening/closing with
remote control ...................... 8
– key with remote control ..... 7
– key without remote
control ..................................... 7
– replacing the battery of
the remote control ............... 9
– request for additional keys
with remote controls ........... 8
Know your vehicle................... 3Level check .................................. 175
– brake fluid ............................... 179– engine coolant ........................ 177
– engine oil ................................. 176
– windscreen/rear window
washer fluid .............................. 178
Lifting of vehicle
– with arm lift ............................ 167
– with the jack ........................... 137
– with workshop lift ................. 167
Light units
– installation ............................... 208
Liquids (specifications) ............... 204
Load limiters ................................. 95
Low consumption
driving style ................................ 116
Lubricants (specifications) ......... 204
Luggage compartment
ceiling light .................................. 53
– bulb replacement ................... 159
Luggage compartment
volume ......................................... 201
Luggage compartment
– boot extension ................... 67-68
– opening with remote control. 8
M
ain beam headlights
– bulb replacement ................... 153
– switching on ............................ 48
Main beam headlights
– bulb replacement ................... 153
– flashing ..................................... 48
– switching on ............................ 48
Maintenance and care ................. 169
– check of fluid level ................ 217
– heavy usage of the car .......... 216
– scheduled servicing
programme ...................... 170-171
– scheduled servicing ............... 172
Maintenance and cleaning
– bodywork ................................ 189
– engine compartment ............ 189
– fabric seats .............................. 190
– interior ..................................... 190
– plastic parts ............................. 190
– windows .................................. 50
Manual climate
control system ........................... 41
– controls ................................... 41
215-224 PANDA EN 7-10-2009 15:09 Pagina 220

221KNOW
YOUR VEHICLE
SAFETY
CORRECT USE
OF THE CAR
WARNING LIGHTS
AND MESSAGES
IN
AN EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONSINDEX
– passenger compartment
ventilation and heating ......... 42
– system servicing ..................... 43
– windscreen and front side
window demisting/
defrosting ................................ 42
Mirror adjustment ....................... 36
MSR (system) ................................ 78
MSR system ................................... 78
Multifunction display ................... 17
– control buttons ...................... 19
– setup menu ............................. 20
– standard screen ..................... 17N
umber plate lights
– bulb replacement ................... 156
O
n board instruments (panel) .. 14
Paint (maintenance) ................... 188
– bodywork colour plate ........ 192
Paraflu
– level check and top-up ......... 177
– specifications .......................... 205Parking (sensors) ......................... 82
Parking lights ................................. 48
Parking sensors ............................ 82
Parking the vehicle ...................... 113
Passenger compartment light
adjustment .................................. 52
Performance ................................. 201
Pollen filter .................................... 181
Power sun roof ............................ 58
– opening/closing ...................... 59
Power windows ........................... 63
Preparation for child seats ........ 103
Q
uality specifications of fluid
and lubricants ................... 204-205
Radio transmitters and mobile
phones ......................................... 87
Radio transmitters and mobile
phones ......................................... 87
Rear door locking
emergency device ..................... 62
Rear fog light
– bulb replacement ................... 155– switching on ............................ 54
Rear fog lights ............................... 54
Rear fog lights
– bulb adjustment ..................... 156
– switching on ............................ 54
Rear light units
– bulb replacement ................... 155
Rear seats
– cleaning .................................... 190
– headrests ................................. 32
Rear view mirrors
– inside ........................................ 35
– outside ..................................... 36
Rear window washer ................... 51
– fluid level check
and top-up ............................... 178
– jet .............................................. 187
– operation ................................. 51
Rear window wiper
– blade replacement .................. 186
– operation .................................. 51
– rear window washer fluid
features ..................................... 179
215-224 PANDA EN 7-10-2009 15:09 Pagina 221

Reconfigurable multifunction
display .......................................... 19
– control buttons ...................... 19
– set up menu ............................ 20
– standard screen ..................... 19
Refuelling
– diesel engines ......................... 88
– petrol engines ......................... 87
– technical specifications
(quantity) ................................. 203
Remote control ........................... 7
– additional remote control ... 8
– battery replacement ............. 9
– remote door opening/
closing ...................................... 8
– tailgate opening ...................... 8
Replacing the battery of
the key with remote control .. 9
Rev counter .................................. 14
Reversing light
– bulb replacement ................... 155
Reversing light
– bulb replacement ................... 156Roof rack – ski rack
(preparation) .............................. 71
Roof rack bar fasteners .............. 71
Roof rack/ski-rack bars
(preparation) .............................. 71
Rubber pipes ................................. 185
Safety........................................... 91
Safety belts .................................... 91
– carrying children safely ........ 98
– general instructions .............. 95
– load limiters ............................ 95
– pretensioners ......................... 94
– SBR ........................................... 91
– seat belt height
adjustment .............................. 92
– seat belt maintenance ........... 97
– using the seat belts ............. 91-93
SBR system .................................... 91
Scheduled servicing ..................... 172
Scheduled Servicing
Programme ......................... 170-171
Seat adjustment ...................... 31-32Seat belt pretensioners .............. 94
– load limiters ............................ 95
Side air bags
(side bag - window bag) ........... 107
– general warnings .................... 109
Side light
– front bulb replacement ........ 152
– rear bulb replacement .......... 155
– switching on ............................ 48
Smart washing
(windscreen wiper) ................... 50
Snow chains ..................................
Sound system
(preparation system) ................ 84
Sound system presetting ............ 84
Space-saver wheel ....................... 137
– technical specifications ......... 199
Spark plugs (type) ........................ 194
Speedometer ................................ 14
Steering column lock .................. 10
Steering wheel adjustment ........ 34
Steering wheel levers .............. 48-50
Steering wheel
– adjustment lever .................... 34
222KNOW
YOUR VEHICLE
SAFETY
CORRECT USE
OF THE CAR
WARNING LIGHTS
AND MESSAGES
IN
AN EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONSINDEX
215-224 PANDA EN 7-10-2009 15:09 Pagina 222

Wheels and tyres.......................... 183
– tyre and wheel types ............ 199
– tyre inflation pressure .......... 199
– wheel replacement ................ 137
– winter tyres ............................ 122
Window winders ......................... 64
Windows
– cleaning .................................... 50
Windows
– washing .................................... 50
– windscreen washer fluid
(specifications) ....................... 205
Windscreen washer
– fluid level check
and top-up ............................... 178
– jets ............................................ 187
– operation ................................. 50
– smart washing function ........ 50– windscreen washer fluid
specifications .......................... 205
Windscreen wiper blades
– replacement ............................ 186
Windscreen/rear window
washer fluid
– specifications .......................... 205
– level check and top-up ......... 178
Windscreen
– blade replacement ................. 186
– jet .............................................. 187
– operation ................................. 50
– windscreen washer
fluid features ............................... 179
Winter period
– snow chains ............................ 122
– winter tyres ............................ 122
Fiat Group Automobiles S. p. A.
Customer Services – Technical Services – Service Engineering
Largo Senatore G. Agnelli, 5 – 10040 Volvera – Torino (Italia)
Stampato n. 603.81.649 – 10/2009 – 1 edizione
224KNOW
YOUR VEHICLE
SAFETY
CORRECT USE
OF THE CAR
WARNING LIGHTS
AND MESSAGES
IN
AN EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONSINDEX
215-224 PANDA EN 7-10-2009 15:09 Pagina 224