relay LAND ROVER FRELANDER 2 2006 Repair Manual

DT CDescriptionPossible CausesAction
B1D33-92Flame Int errupt ionDuri ng NormalOperat ion -performance orincorrect operat ion
No fuel pres ent at fuel fi redboos t er heat er modul eExhaus t sys t em blockedAir i nt ake blocked
Check vehicle fuel levelCheck fuel l ines t o fuel fired boos ter heatermodul e for bl ockage, ki nki ng or damageCheck exhaus t s yst em and ai r int ake forblockage, ki nki ng or damageCheck fuel for aerati on and correct fuel deliveryCheck vehicle i s not parked on an i ncl ine whenparking heater i s operatedUsi ng t he manufacturer approved diagnost icsys t em, record t hen clear any st ored di agnos ti ctroubl e codes t hen conduct the fuel fi redboos t er heater operation test (Set up andconfigurat ion/auxili ary heat er/operat ion t es t)Check for st ored di agnos ti c troubl e codesCheck for correct operat ion
B1D34-68Heater In Lock O utMode - eventinformat ion
Fuel fired boos t er heaters ys t em faul t• NOTE: For i nformati on onl y, recti fy ot her s t ored fuelfi red boos ter heat er diagnos t ic t rouble codes pri or tothi s diagnos t ic t rouble code
Usi ng t he manufacturer approved diagnost icsys t em, record t hen clear any st ored di agnos ti ctroubl e codes t hen conduct the fuel fi redboos t er heater operation test (Set up andconfigurat ion/auxili ary heat er/operat ion t es t)Check for st ored di agnos ti c troubl e codesCheck for correct operat ion
B1D63-11External ControlRelay - circui t s hortt o ground
Fuel fired boos t er heatermodule failureCheck and i ns t all a new fuel fi red boost erheat er modul e as requi redFor addit ional informati on, refer t o: Fuel FiredBoos t er Heat er (412-02B Auxil iary Climat eCont rol , Removal and Ins t allat ion).Refer to the warrant y policy and proceduresmanual , or det ermi ne if any prior approvalprogramme is in operat ion, pri or t o t heins tal lati on of a new modul e/component
B1D63-15External ControlRelay - circui t s hortt o batt ery or open
Fuel fired boos t er heatermodule failureCheck and i ns t all a new fuel fi red boost erheat er modul e as requi redFor addit ional informati on, refer t o: Fuel FiredBoos t er Heat er (412-02B Auxil iary Climat eCont rol , Removal and Ins t allat ion).Refer to the warrant y policy and proceduresmanual , or det ermi ne if any prior approvalprogramme is in operat ion, pri or t o t heins tal lati on of a new modul e/component
U0010-00Medium Speed CANCommunicati on Bus -no s ub t ypeinformat ion
Medium speed CANcommuni cat ion bus offUsi ng t he manufacturer approved diagnost icsys t em, compl et e a CAN network int egrit y t est
U0028-08VehicleCommunicati on BusA - Bus Si gnal /Mes sage Fail ures
Medium speed CANcommuni cat ion bus offFuel fired boos t er heatermodule failure
Usi ng t he manufacturer approved diagnost icsys t em, compl et e a CAN network int egrit y t est
U0300-00Int ernal Cont rolModule Soft wareIncompati bili ty - nos ub type i nformati on
Fuel fired boos t er heatermodule not configured orincorrect ly confi gured
Re-configure the fuel fi red boost er heat ermodul e us ing t he manufacturer approveddiagnos t ic s yst em (Moduleprogramming/Confi gure exis t ingmodul e/Auxil iary heat er control modul e)
U1A37-87Cras h St atusTelegram Bus Signal/ Mes sage Fail uresMis s ing mess age
Cras h s ignal received overCAN network• NOTE: Event i nformat ion - the rest rai nts controlmodul e has recorded a cras h event
Usi ng t he manufacturer approved diagnost icsys t em, check other modules for relat eddiagnos t ic t rouble codes
U2101-00Control ModuleConfigurat ionIncompati ble - nos ub type i nformati on
Fuel fired boos t er heatermodule not configured orincorrect ly confi guredCent ral junct ion box notconfigured correct ly
Usi ng t he manufacturer approved diagnost icsys t em, record t hen clear any st ored di agnos ti ctroubl e codes t hen conduct the fuel fi redboos t er heater operation test (Set up andconfigurat ion/auxili ary heat er/operat ion t es t)Check for reoccurrence of t he diagnost ic troubl ecodeIf t he diagnost ic troubl e code returnsUsi ng t he manufacturer approved diagnost icsys t em check and up-dat e t he car confi gurati onfi le as requi redRe-configure the Fuel fi red boos ter heatermodul e us ing t he manufacturer approveddiagnos t ic s yst em

DT CDescriptionPossible CauseAction
B1029-21Accel erator PedalSensor s ignalampli tude < mi ni mum
Accelerat or pedal s ens ors i gnal <3% of supply(5V)Carry out the pi npoint t es ts as s oci at ed t o t his DTCusi ng t he manufact urer approved diagnost ic s ys tem
B1029-22Accel erator PedalSensor s ignalampli tude >maximum
Accelerat or pedal s ens ors i gnal >=97% ofs upply(5V)
Carry out the pi npoint t es ts as s oci at ed t o t his DTCusi ng t he manufact urer approved diagnost ic s ys tem
B108A-23Start butt on - s ignals tuck l owSW 1 and SW 2 cons tant lyact iveCarry out the pi npoint t es ts as s oci at ed t o t his DTCusi ng t he manufact urer approved diagnost ic s ys tem
B108B-23Start Butt on Circui t"A" - si gnal s t uck l owSW 1 cons t ant ly act ive forl ong ti me whi le but tonpress det ect ed at SW 2
Carry out the pi npoint t es ts as s oci at ed t o t his DTCusi ng t he manufact urer approved diagnost ic s ys tem
B108B-24Start butt on circuit"A" - si gnal s t uck hi ghSW 1 never acti ve whil ebut ton press det ect ed atSW 2
Carry out the pi npoint t es ts as s oci at ed t o t his DTCusi ng t he manufact urer approved diagnost ic s ys tem
B108C-23Start butt on circuit"B" - si gnal s t uck l owSW 2 cons t ant ly act ive forl ong ti me whi le but tonpress det ect ed at SW 1
Carry out the pi npoint t es ts as s oci at ed t o t his DTCusi ng t he manufact urer approved diagnost ic s ys tem
B108C-24Start butt on circuit"B" - si gnal s t uck hi ghSW 2 never acti ve whil ebut ton press det ect ed atSW 1
Carry out the pi npoint t es ts as s oci at ed t o t his DTCusi ng t he manufact urer approved diagnost ic s ys tem
B108D-24Start butt on circuit"C" si gnal s t uck hi ghSW 3 never acti ve whil ebut ton press det ect ed atSW 1
Carry out the pi npoint t es ts as s oci at ed t o t his DTCusi ng t he manufact urer approved diagnost ic s ys tem
B1095-12W i per On/Off Rel ay -circui t short to powerW iper On/O ff rel ay circuit -s hort t o powerRefer to electrical ci rcuit diagrams and check wi perOn/Off rel ay ci rcuit for short to power
B1095-14W i per On/Off Rel ay -circui t short to groundor open
W iper On/O ff rel ay circuit -s hort t o ground, openci rcuit
Refer to electrical ci rcuit diagrams and check wi perOn/Off rel ay ci rcuit for short to ground, open circui t
B1096-12W i per High/Low Rel ay- circui t short topower
W iper High/Low rel ayci rcuit - s hort t o powerRefer to electrical ci rcuit diagrams and check wi perHigh/Low relay ci rcuit for s hort t o power
B1096-14W i per High/Low Rel ay- circui t short toground or open
W iper High/Low rel ayci rcuit - s hort t o ground,open circui t
Refer to electrical ci rcuit diagrams and check wi perHigh/Low relay ci rcuit for s hort t o ground, open ci rcuit
B1097-12Heated W inds hieldRelay - circui t s hortt o power
Heat ed winds hield relayci rcuit - s hort t o powerRefer to electrical ci rcuit diagrams and check heatedwinds hield relay circui t for s hort t o power
B1097-14Heated W inds hieldRelay - circui t s hortt o ground or open
Heat ed winds hield relayci rcuit - s hort t o ground,open circui t
Refer to electrical ci rcuit diagrams and check heatedwinds hield relay circui t for s hort t o ground, open ci rcuit
B109B-11License Pl ate Li ght -circui t short to groundLi cens e plat e lamp circuit -s hort t o groundRefer to electrical ci rcuit diagrams and check li cens eplate lamp ci rcuit for short to ground
B109B-13License Pl ate Li ght -open circuitLi cens e plat e lamp circuit -open circui tRefer to electrical ci rcuit diagrams and check li cens eplate lamp ci rcuit for open circui t
B10A2-02Cras h Input - generals ignal fail ureIncorrect s ignal recei vedCarry out the pi npoint t es ts as s oci at ed t o t his DTCusi ng t he manufact urer approved diagnost ic s ys temB10A2-11Cras h Input - ci rcuits hort t o groundCrash input ci rcuit - s hortt o groundCarry out the pi npoint t es ts as s oci at ed t o t his DTCusi ng t he manufact urer approved diagnost ic s ys tem
B10A2-15Cras h s i gnal - circui ts hort t o power oropen
Crash s ignal circui t - s hortt o power, open circui tCarry out the pi npoint t es ts as s oci at ed t o t his DTCusi ng t he manufact urer approved diagnost ic s ys tem
B10A2-68Cras h s i gnal - eventinformat ionCrash s ignal - eventi nformati onCheck RCM for DTCs and refer to the relevant DTCIndex
B10A5-12Alarm Si ren - ci rcuits hort t o powerAl arm s iren ci rcuit - s hortt o powerRefer to electrical ci rcuit diagrams and check alarms iren ci rcuit for short to power
B10A5-14Alarm Si ren - ci rcuits hort t o ground oropen
Al arm s iren ci rcuit - s hortt o ground, open circuitRefer to electrical ci rcuit diagrams and check alarms iren ci rcuit for short to ground, open circuit
B10AC-86Crui se Cont rol Swi tch- Signal invalidSi gnal i nvali dCarry out the pi npoint t es ts as s oci at ed t o t his DTCusi ng t he manufact urer approved diagnost ic s ys temB10AC-87Crui se Cont rol Swi tch- Mi ss i ng mes sageMis si ng mes s ageCarry out the pi npoint t es ts as s oci at ed t o t his DTCusi ng t he manufact urer approved diagnost ic s ys tem
B10AC-95Crui se Cont rol Swi tch- W rong as sembl yMis -mat ch between CarConfigurat ion Fil e andvehicle
Check/up-dat e Car Configurat ion Fi le us i ng themanufacturer approved diagnost ic sys tem

DT CDescriptionPossible CauseAction
B10AD-04Rain Sens or - Sys t emInt ernal FailureInternal s ens or fail ureIns t al l a new rain s ens or, refer to newmodule/component i nst all at ion not e at t he top of t heDTC Index
B10AD-09Rain Sens or -Component Fail uresRai n s ens or incorrect lyi nst all edRai n s ens or int ernal fail ure
Check for correct ins tal lati on of rai n s ens or. Ins tall anew s ens or as requi red, refer t o newmodule/component i nst all at ion not e at t he top of t heDTC Index
B10BE-11Solar Sens or - circui ts hort t o groundSunload s ens or circui t -s hort t o groundRefer to electrical ci rcuit diagrams and check s unl oads ens or for s hort t o ground
B10BE-13Solar Sens or - opencircui tSunload s ens or circui t -open circui tRefer to electrical ci rcuit diagrams and check s unl oads ens or for open circuit
B10C0-12Fuel Pump PowerSuppl y - circui t shortt o power
Fuel pump power supplyci rcuit - s hort t o powerRefer to electrical ci rcuit diagrams and check fuel pumppower s upply circui t for s hort t o power
B10C0-14Fuel Pump PowerSuppl y - circui t shortt o ground or open
Fuel pump power supplyci rcuit - s hort t o ground,open circui t
Refer to electrical ci rcuit diagrams and check fuel pumppower s upply circui t for s hort t o ground, open ci rcuit
B10D7-94PATS Key -unexpected operat ionNo res pons e fromt rans ponder i n keyRepl ace key
B10E5-11PCM wake-up si gnal -circui t short to groundEngine Cont rol Module(ECM) wake-up s ignalci rcuit - s hort t o ground
Refer to electrical ci rcuit diagrams and check ECMwake-up s ignal ci rcuit for short to ground
B10E5-15PCM wake-up si gnal -circui t short to poweror open
Engine Cont rol Module(ECM) wake-up s ignalci rcuit - s hort t o power,open circui t
Refer to electrical ci rcuit diagrams and check ECMwake-up s ignal ci rcuit for short to power, open circui t
B10E7-12Igni ti on On Relay -circui t short to powerEJB i gni ti on On relaycontrol ci rcuit - s hort t opower
Refer to electrical ci rcuit diagrams and check EJBignit ion relay control ci rcuit for s hort t o power
B10E7-14Igni ti on On Relay -circui t short to groundor open
EJB i gni ti on On relaycontrol ci rcuit - s hort t oground, open circuit
Refer to electrical ci rcuit diagrams and check EJBignit ion relay control ci rcuit for s hort t o ground, openci rcuit
B10EA-12Posi ti ve t emperaturecoeffi ci ent heat er -circui t short to power
Pos it ive t emperat urecoefficient heater circuit -s hort t o power
Refer to electrical ci rcuit diagrams and check posi ti vetemperat ure coeffici ent heater circui t for s hort t o power
B10EA-14Posi ti ve t emperaturecoeffi ci ent heat er -circui t short to groundor open
Pos it ive t emperat urecoefficient heater circuit -s hort t o ground, openci rcuit
Refer to electrical ci rcuit diagrams and check posi ti vetemperat ure coeffici ent heater circui t for s hort t oground, open circui t
B10EB-77Driver door doubl elocking mot or -commanded pos i ti onnot reachabl e
Incorrect feedback fromDDMCheck for Los t Communicati ons DTCs and carry outass ociated pi npoi nt tes t us ing manufacturer approveddiagnos t ic s ys tem. If no los t communicati on DTC, checkdoubl e locking mechani s m for mechanical fail ureB10EC-77Pass enger doordoubl e l ocking mot or- commanded pos i ti onnot reachabl e
Incorrect feedback fromPDMCheck for Los t Communicati ons DTCs and carry outass ociated pi npoi nt tes t us ing manufacturer approveddiagnos t ic s ys tem. If no los t communicati on DTC, checkdoubl e locking mechani s m for mechanical fail ureB10ED-77Rear door dri ver s i dedoubl e l ocking mot or- commanded pos i ti onnot reachabl e
Incorrect feedback fromrear door dri ver s i deCheck DDM for Los t Communicat ions DTCs and carryout as s oci ated pi npoi nt t es t usi ng manufacturerapproved di agnos ti c s yst em. If no los t communi cat ionDTC, Carry out t he pinpoint t est s as sociat ed t o thi sDTC us ing t he manufacturer approved diagnos ti cs ys t em, check doubl e locking mechanis m formechanical fai lure
B10EE-77Rear door pas sengers ide double l ocki ngmot or - commandedposi ti on notreachabl e
Incorrect feedback fromrear door pas senger si deCheck PDM for Lost Communi cat ions DTCs and carry outass ociated pi npoi nt tes t us ing manufacturer approveddiagnos t ic s ys tem. If no los t communicati on DTC, Carryout the pi npoint t es ts as s oci at ed t o t his DTC us ing themanufacturer approved diagnost ic sys tem, check doublelocki ng mechani sm for mechanical fail ureB10EF-12Sunroof Speed Out put- circui t short topower
Sunroof s peed out putci rcuit - s hort t o powerRefer to electrical ci rcuit diagrams and check s unroofs peed out put circui t for s hort t o power
B10EF-14Sunroof Speed Out put- circui t short toground or open
Sunroof s peed out putci rcuit - s hort t o ground,open circui t
Refer to electrical ci rcuit diagrams and check s unroofs peed out put circui t for s hort t o ground, open ci rcuit
B10F2-12Sunroof cont rol -circui t short to powerSunroof cont rol circui t -s hort t o powerRefer to electrical ci rcuit diagrams and check s unroofcont rol circuit for s hort to power

DT CDescriptionPossible CauseAction
B10F2-14Sunroof cont rol -circui t short to groundor open
Sunroof cont rol circui t -s hort t o ground, openci rcuit
Refer to electrical ci rcuit diagrams and check s unroofcont rol circuit for s hort to ground, open circui t
B10F3-11Left front posi ti onli ght - ci rcuit s hort t oground
Left front pos it ion l ightci rcuit - s hort t o groundRefer to electrical ci rcuit diagrams and check left frontpos i ti on li ght circui t for s hort t o ground
B10F4-11Right front posi ti onli ght - ci rcuit s hort t oground
Ri ght front pos it ion l ightci rcuit - s hort t o groundRefer to electrical ci rcuit diagrams and check right frontpos i ti on li ght circui t for s hort t o ground
B10F5-11Left rear pos it ionli ght - ci rcuit s hort t oground
Left rear pos i ti on li ghtci rcuit - s hort t o groundRefer to electrical ci rcuit diagrams and check left rearpos i ti on li ght circui t for s hort t o ground
B10F5-12Left Rear Pos i ti onli ght – s hort circuit topower
Left rear pos i ti on li ghtci rcuit - s hort t o powerRefer to electrical ci rcuit diagrams and check left rearpos i ti on li ght circui t for s hort t o power
B10F6-11Right rear pos it ionli ght - ci rcuit s hort t oground
Ri ght rear pos i ti on li ghtci rcuit - s hort t o groundRefer to electrical ci rcuit diagrams and check right rearpos i ti on li ght circui t for s hort t o ground
B10F6-12Right rear pos it ionli ght - short ci rcuit t opower
Ri ght rear pos i ti on li ghtci rcuit - s hort t o powerRefer to electrical ci rcuit diagrams and check right rearpos i ti on li ght circui t for s hort t o power
B1101-12Comfort rel ay - circuits hort t o powerComfort relay controlci rcuit - s hort t o powerRefer to electrical ci rcuit diagrams and check comfortrel ay cont rol ci rcuit for short to power
B1101-14Comfort rel ay - circuits hort t o ground oropen
Comfort relay controlci rcuit - s hort t o ground,open circui t
Refer to electrical ci rcuit diagrams and check comfortrel ay cont rol ci rcuit for short to ground, open circui t
B1108-77Driver door cent rallocking mot or -commanded pos i ti onnot reachabl e
Incorrect feedback fromDDMCheck for Los t Communicati ons DTCs and carry outass ociated pi npoi nt tes t us ing manufacturer approveddiagnos t ic s ys tem. If no los t communicati on DTC, checkcent ral locking mechani s m for mechanical fai lure
B1109-77Pass enger doorcent ral l ocking motor- commanded pos i ti onnot reachabl e
Incorrect feedback fromPDMCheck for Los t Communicati ons DTCs and carry outass ociated pi npoi nt tes t us ing manufacturer approveddiagnos t ic s ys tem. If no los t communicati on DTC, checkcent ral locking mechani s m for mechanical fai lure
B110A-77Rear door dri ver s i decent ral l ocking motor- commanded pos i ti onnot reachabl e
Incorrect feedback fromrear door dri ver s i deCheck DDM for Los t Communicat ions DTCs and carryout as s oci ated pi npoi nt t es t usi ng manufacturerapproved di agnos ti c s yst em. If no los t communi cat ionDTC, Carry out t he pinpoint t est s as sociat ed t o thi sDTC us ing t he manufacturer approved diagnos ti cs ys t em, check cent ral l ocking mechanis m formechanical fai lure
B110B-77Rear door pas sengers ide central locki ngmot or - commandedposi ti on notreachabl e
Incorrect feedback fromrear door pas senger si deCheck PDM for Lost Communi cat ions DTCs and carry outass ociated pi npoi nt tes t us ing manufacturer approveddiagnos t ic s ys tem. If no los t communicati on DTC, Carryout the pi npoint t es ts as s oci at ed t o t his DTC us ing themanufacturer approved diagnost ic sys tem, checkcent ral locking mechani s m for mechanical fai lure
B1115-11High Mount edStopl amp cont rol -circui t short to ground
Hi gh mounted st oplampcontrol ci rcuit - s hort t oground
Refer to electrical ci rcuit diagrams and check highmounted s t opl amp cont rol circui t for s hort t o ground
B1115-13High Mount edStopl amp cont rol -circui t open
Hi gh mounted st oplampcontrol ci rcuit - open circui tRefer to electrical ci rcuit diagrams and check highmounted s t opl amp cont rol circui t for open circui t
B112A-12Igni ti on On Relay B -circui t short to powerRJB i gni ti on On relayci rcuit - s hort t o powerRefer to electrical ci rcuit diagrams and check RJBignit ion O n rel ay ci rcuit for short to power
B112A-14Igni ti on On Relay B -circui t short to groundor open
RJB i gni ti on On relayci rcuit - s hort t o ground,open circui t
Refer to electrical ci rcuit diagrams and check RJBignit ion O n rel ay ci rcuit for short to ground, open circui t
B112B-07Steering W heelModule - MechanicalFailures
Any pos it ion or but ton onwiper st alk act ive for moret han 60 s econds (180s econds for s peed controlbut tons )Swi tch i nternal fai lure
Check for st uck wiper or speed control but tons . Ins tal la new s wi tch as requi red, refer to newmodule/component i nst all at ion not e at t he top of t heDTC Index
B112B-88Steering W heelModule - Bus offLos t communicat ions wi ths t eering wheel moduleCarry out di agnos ti c s trategy as s ociat ed wi th t his DTCusi ng manufacturer approved diagnos ti c sys t em
B112C-88Int eri or Moti on Sens or- Bus offLos t communicat ions wi thi nterior mot ion s ensorCarry out di agnos ti c s trategy as s ociat ed wi th t his DTCusi ng manufacturer approved diagnos ti c sys t em
B1130-07Light s wit ch module -Mechani cal FailuresAny but tons on t he LightSwi tch Module act ive formore t han 60 s econds orExt erior Light Swit ch ini ll egal combinati on
Check for st uck li ght s wi tch butt ons. Ins tall a new li ghts wit ch as required, refer t o new module/componentins tal lati on note at the t op of the DTC Index

DT CDescriptionPossible CauseAction
Swi tch i nternal fai lure
B1130-88Light Swit ch Modul e -Bus offLos t communicat ions wi thl ight ing s wit ch moduleCarry out di agnos ti c s trategy as s ociat ed wi th t his DTCusi ng manufacturer approved diagnos ti c sys t em
B1131-88W i per Mot or Modul e -Bus offLos t communicat ions wi thwiper motor moduleCarry out di agnos ti c s trategy as s ociat ed wi th t his DTCusi ng manufacturer approved diagnos ti c sys t em
B113C-11Hazard s wi tchil lumi nat ion - ci rcuits hort t o ground
Hazard swit ch ill uminat ionci rcuit - s hort t o groundRefer to electrical ci rcuit diagrams and check hazards wit ch ill uminat ion circui t for s hort t o ground
B113C-15Hazard s wi tchil lumi nat ion - ci rcuits hort t o power oropen
Hazard swit ch ill uminat ionci rcuit - s hort t o power,open circui t
Refer to electrical ci rcuit diagrams and check hazards wit ch ill uminat ion circui t for s hort t o power, openci rcuit
B113D-12Sunroof GlobalOpen/Cl os e Cont rol -circui t short to power
Roof openi ng panel globalopen/clos e control ci rcuit -s hort t o power
Refer to electrical ci rcuit diagrams and check roofopeni ng panel global open/cl os e control ci rcuit for shortto power
B113D-14Sunroof GlobalOpen/Cl os e Cont rol -circui t short to groundor open
Roof openi ng panel globalopen/clos e control ci rcuit -s hort t o ground, openci rcuit
Refer to electrical ci rcuit diagrams and check roofopeni ng panel global open/cl os e control ci rcuit for shortto ground, open circui t
B1182-51Tire Pres s ureMonit ori ng Sys t em(TPMS) - NotProgrammed
TPMS modul e inTrans port /Factory modeEnt er TPMS module i nto cus tomer mode us i ngmanufacturer approved diagnost ic sys tem
B11BC-11Extended acces soryrel ay - circuit short toground
Ext ended acces s ory relayci rcuit - s hort t o groundRefer to electrical ci rcuit diagrams and check extendedacces sory rel ay ci rcuit for short to ground
B11BC-15Extended acces soryrel ay - circuit short topower or open
Ext ended acces s ory relayci rcuit - s hort t o power,open circui t
Refer to electrical ci rcuit diagrams and check extendedacces sory rel ay ci rcuit for short to power, open ci rcuit
B1A79-11Rear Fog Lamp -circui t short to groundRear fog lamp supplyci rcuit - s hort t o groundRefer to electrical ci rcuit diagrams and check rear foglamp supply ci rcuit for s hort t o ground
B1A79-13Rear Fog Lamp -circui t openRear fog lamp supplyci rcuit - open circuitRefer to electrical ci rcuit diagrams and check rear foglamp supply ci rcuit for open circui t
B1A84-41Car Configurat ionData - generalchecks um fai lure
Checks um errorConfigure the CJB as a 'NEW ' module usi ng t hemanufacturer approved diagnost ic sys tem
B1A99-04Power On Res et -Syst em Int ernalfai lure
The DTC wil l be set i f theres et counter reaches themaxi mum val ue (current ly5)
Ins t al l a new CJB, refer t o t he new module/componentins tal lati on note at the t op of the DTC Index
B1C96-11Alarm LED Ci rcuit -circui t short to groundAl arm LED circuit - short togroundRefer to electrical ci rcuit diagrams and check alarm LEDci rcuit for short to ground
B1C96-15Alarm LED Ci rcuit -circui t short to poweror open
Al arm LED circuit - short topower, open circui tRefer to electrical ci rcuit diagrams and check alarm LEDci rcuit for short to power, open ci rcuit
B1D00-11Left -hand Low BeamCircui t - circuit shortt o ground
Left-hand low beam ci rcuit- short to groundRefer to electrical ci rcuit diagrams and check left-handlow beam circuit for s hort to ground
B1D00-13Left -hand Low BeamCircui t - circuit openLeft-hand low beam ci rcuit- open circui tRefer to electrical ci rcuit diagrams and check left-handlow beam circuit for open ci rcuit
B1D01-11Right -hand Low BeamCircui t - circuit shortt o ground
Ri ght -hand l ow beamci rcuit - s hort t o groundRefer to electrical ci rcuit diagrams and check right-handlow beam circuit for s hort to ground
B1D01-13Right -hand Low BeamCircui t - circuit openRi ght -hand l ow beamci rcuit - open circuitRefer to electrical ci rcuit diagrams and check right-handlow beam circuit for open ci rcuit
B1D06-11Left Turn Indicator -circui t short to groundLeft turn indicator circui t -s hort t o groundRefer to electrical ci rcuit diagrams and check left turnindicator circui t for s hort t o ground
B1D06-13Left Turn Indicator -circui t openLeft turn indicator circui t -open circui tRefer to electrical ci rcuit diagrams and check left turnindicator circui t for open circuit
B1D07-11Right Turn Indicator -circui t short to groundRi ght turn indicator circui t- short to groundRefer to electrical ci rcuit diagrams and check right turnindicator circui t for s hort t o ground
B1D07-13Right Turn Indicator -circui t openRi ght turn indicator circui t- open circui tRefer to electrical ci rcuit diagrams and check right turnindicator circui t for open circuit
B1D17-00Batt ery BackedSounder - GeneralFailure Informat ion
Internal i ncl inati on s ens orfaultCarry out the pi npoint t es ts as s oci at ed t o t his DTCusi ng t he manufact urer approved diagnost ic s ys tem

DT CDescriptionPossible CauseAction
B1D17-88Batt ery BackedSounder - bus offLos t communicat ions wi thbat tery backed s ounderCarry out the net work t est as s oci ated wi th thi s DTCusi ng t he manufact urer approved diagnost ic s ys tem
B1D17-96Batt ery BackedSounder - componentint ernal fai lure
Bat tery backed s ounder -i nternal failureIns t al l a new bat tery backed s ounder, refer t o newmodule/component i nst all at ion not e at t he top of t heDTC IndexB1D18-96Volumet ri c Sens orCircui t - componentint ernal fai lure
Interior mot ion s ensor -i nternal failureIns t al l a new i nteri or moti on s ens or, refer t o newmodule/component i nst all at ion not e at t he top of t heDTC Index
B1D21-62Remote Cont rolSwit ch - Signalcompare failure
A request from aprogrammed remote keywas recei ved and theroll ing count er wasi ncorrect
Re-s ynchroni se the remote key by us i ng the key t os tart the vehicle
B1C55-12Horn Rel ay CoilCircui t - circuit shortt o power
Horn rel ay cont rol circui t -s hort t o powerRefer to electrical ci rcuit diagrams and check horn relaycont rol circuit for s hort to power
B1C55-14Horn Rel ay CoilCircui t- ci rcuit s hortt o ground or open
Horn rel ay cont rol circui t -s hort t o ground, openci rcuit
Refer to electrical ci rcuit diagrams and check horn relaycont rol circuit for s hort to ground, open circui t
B1C82-12Headlamp W asherRelay Coil Ci rcuit -circui t short to power
Headlamp washer rel aycontrol ci rcuit - s hort t opower
Refer to electrical ci rcuit diagrams and check headl ampwasher rel ay cont rol circui t for s hort t o power
B1C82-14Headlamp W asherRelay Coil Ci rcuit -circui t short to groundor open
Headlamp washer rel aycontrol ci rcuit - s hort t oground, open circuit
Refer to electrical ci rcuit diagrams and check headl ampwasher rel ay cont rol circui t for s hort t o ground, openci rcuit
B1C84-12Heated Rear W i ndowRelay Out put Ci rcuit -circui t short to power
Heat ed rear wi ndow relaycontrol ci rcuit - s hort t opower
Refer to electrical ci rcuit diagrams and check heatedrear window relay control ci rcuit for s hort t o power
B1C84-14Heated Rear W i ndowRelay Out put Ci rcuit -circui t short to groundor open
Heat ed rear wi ndow relaycontrol ci rcuit - s hort t oground, open circuit
Refer to electrical ci rcuit diagrams and check heatedrear window relay control ci rcuit for s hort t o ground,open ci rcuit
B1C90-12Auxili ary DrivingLamps Relay CoilCircui t - circuit shortt o power
Auxil iary dri vi ng lampsrelay control ci rcuit - s hortt o power
Refer to electrical ci rcuit diagrams and check auxi li arydri vi ng lamps relay control ci rcuit for s hort t o power
B1C90-14Auxili ary DrivingLamps Relay CoilCircui t - circuit shortt o ground or open
Auxil iary dri vi ng lampsrelay control ci rcuit - s hortt o ground, open circuit
Refer to electrical ci rcuit diagrams and check auxi li arydri vi ng lamps relay control ci rcuit for s hort t o ground,open ci rcuit
B1D13-12Int eri or Li ght s #1Circui t - circuit shortt o power
Ins trument panel int eriorl ight s ci rcuit - s hort t opower
Refer to electrical ci rcuit diagrams and checkins trument panel int eri or l ights ci rcuit for short topower
B1D13-14Int eri or Li ght s #1Circui t - circuit shortt o ground or open
Ins trument panel int eriorl ight s ci rcuit - s hort t oground, open circuit
Refer to electrical ci rcuit diagrams and checkins trument panel int eri or l ights ci rcuit for short toground, open circui t
B1D1A-12Int eri or Li ght s Ci rcuit'C' - circui t s hort topower
Roof cons ole int erior l ightsci rcuit - s hort t o powerRefer to electrical ci rcuit diagrams and check roof panelint erior l ights ci rcuit for s hort t o power
B1D1A-14Int eri or Li ght s Ci rcuit'C' - circui t s hort toground or open
Roof cons ole int erior l ightsci rcuit - s hort t o ground,open circui t
Refer to electrical ci rcuit diagrams and check roof panelint erior l ights ci rcuit for s hort t o ground, open circuit
B1D35-24Hazard Swi tch -Signal st uck highHazard swit ch is acti vemore t han 60 s econdsCarry out the pi npoint t es ts as s oci at ed t o t his DTCusi ng t he manufact urer approved diagnost ic s ys tem
C0023-11Stop Lamp Cont rol -circui t short to groundSt op lamp cont rol circui t -s hort t o groundRefer to electrical ci rcuit diagrams and check s top lampcont rol circuit for s hort to ground
C0023-13Stop Lamp Cont rol -circui t openSt op lamp cont rol circui t -open circui tRefer to electrical ci rcuit diagrams and check s top lampcont rol circuit for open ci rcuit
C1108-11Pedal Sens or(s )Suppl y Volt age -circui t short to ground
Pedal sens or(s ) supplyvolt age circui t - short toground
Refer to electrical ci rcuit diagrams and check pedals ens or(s ) supply vol tage circui t for s hort t o ground
C1108-15Pedal Sens or(s )Suppl y Volt age -circui t short to poweror open
Pedal sens or(s ) supplyvolt age circui t - short topower, open circui t
Refer to electrical ci rcuit diagrams and check pedals ens or(s ) supply vol tage circui t for s hort t o power,open ci rcuit
C1A41-21Clut ch Pedal Sensor -s ignal amplit ude s i gnal <3% of s uppl y(5V)Carry out the pi npoint t es ts as s oci at ed t o t his DTCusi ng t he manufact urer approved diagnost ic s ys tem

DT CDescriptionPossible CauseAction
B1B86-11Seat Hei ght Motor Relay -Circui t s hort to groundSeat height motorcircui t s hort circuit t oground
Refer to t he elect rical circuit di agrams andcheck seat height mot or ci rcuit for s hort ci rcuitt o ground
B1B86-15Seat Hei ght Motor Relay -Circui t s hort to bat t ery oropen
Seat height motorcircui t s hort circuit t opower, open circui t
Refer to t he elect rical circuit di agrams andcheck seat height mot or ci rcuit for s hort ci rcuitt o power, open circui t
B1B87-31Seat Hei ght MotorSpeed/Pos i ti on Sens or -No s i gnal
Seat height motors peed/posi ti on s ens orcircui t open ci rcuit , highresi s tanceSeat height motors peed/posi ti on s ens ori nternal fai lure
Refer to t he elect rical circuit di agrams andcheck seat height mot or speed/pos it ion s ensorci rcuit for open circui t, hi gh res is t anceCheck and ins t al l new s eat hei ght mot ors peed/pos it ion s ensor as requi red. Refer to thewarrant y policy and procedures manual, ordet ermi ne if any prior approval programme i s inoperat ion, pri or to t he i ns t allat ion of a newmodul e/ component
B1B88-11Seat Sl ide Mot or Relay -Circui t s hort to groundSeat s lide motor circui ts hort circui t to groundRefer to t he elect rical circuit di agrams andcheck seat s li de mot or ci rcuit for s hort circui tt o ground
B1B88-15Seat Sl ide Mot or Relay -Circui t s hort to bat t ery oropen
Seat s lide motor circui ts hort circui t to power,open circui t
Refer to t he elect rical circuit di agrams andcheck seat s li de mot or ci rcuit for s hort circui tt o power, open circui t
B1B89-31Seat Sl ide Mot orSpeed/Pos i ti on Sens or -No s i gnal
Seat s lide motors peed/posi ti on s ens orcircui t open ci rcuit , highresi s tanceSeat s lide motors peed/posi ti on s ens ori nternal fai lure
Refer to t he elect rical circuit di agrams andcheck seat s li de mot or s peed/pos it ion s ensorci rcuit for open circui t, hi gh res is t anceCheck and ins t al l new s eat s l ide mot ors peed/pos it ion s ensor as requi red. Refer to thewarrant y policy and procedures manual, ordet ermi ne if any prior approval programme i s inoperat ion, pri or to t he i ns t allat ion of a newmodul e/ component
B1B90-11Seat Ti lt Mot or Rel ay -Circui t s hort to groundSeat ti lt mot or circuits hort circui t to groundRefer to t he elect rical circuit di agrams andcheck seat t il t motor circui t for s hort circui t toground
B1B90-15Seat Ti lt Mot or Rel ay -Circui t s hort to bat t ery oropen
Seat ti lt mot or circuits hort circui t to power,open circui t
Refer to t he elect rical circuit di agrams andcheck seat t il t motor circui t for s hort circui t topower, open circui t
B1B91-31Seat Ti lt Mot orSpeed/Pos i ti on Sens or -No s i gnal
Seat ti lt mot ors peed/posi ti on s ens orcircui t open ci rcuit , highresi s tanceSeat ti lt mot ors peed/posi ti on s ens ori nternal fai lure
Refer to t he elect rical circuit di agrams andcheck seat t il t motor s peed/posi ti on s ens orci rcuit for open circui t, hi gh res is t anceCheck and ins t al l new s eat t il t mot ors peed/pos it ion s ensor as requi red. Refer to thewarrant y policy and procedures manual, ordet ermi ne if any prior approval programme i s inoperat ion, pri or to t he i ns t allat ion of a newmodul e/ component
B1B92-11Seat Recli ne Mot or Rel ay- Circui t s hort t o groundSeat recli ne mot orcircui t s hort circuit t oground
Refer to t he elect rical circuit di agrams andcheck seat recl ine mot or ci rcuit for short ci rcuitt o ground
B1B92-15Seat Recli ne Mot or Rel ay- Circui t s hort t o batt eryor open
Seat recli ne mot orcircui t s hort circuit t opower, open circui t
Refer to t he elect rical circuit di agrams andcheck seat recl ine mot or ci rcuit for short ci rcuitt o power, open circui t
B1B93-31Seat Recli ne Mot orSpeed/Pos i ti on Sens or -No s i gnal
Seat recli ne mot ors peed/posi ti on s ens orcircui t open ci rcuit , highresi s tanceSeat recli ne mot ors peed/posi ti on s ens ori nternal fai lure
Refer to t he elect rical circuit di agrams andcheck seat recl ine mot or speed/pos it ion s ens orci rcuit for open circui t, hi gh res is t anceCheck and ins t al l new s eat recl ine motors peed/pos it ion s ensor as requi red. Refer to thewarrant y policy and procedures manual, ordet ermi ne if any prior approval programme i s inoperat ion, pri or to t he i ns t allat ion of a newmodul e/ component
B1B94-24Seat Hei ght Up Swit ch -Signal st uck highSeat height up s wit chcircui t s hort circuit t opower
Refer to t he elect rical circuit di agrams andcheck seat height up s wit ch circui t short ci rcuitt o power
B1B95-24Seat Hei ght Down Swit ch- Signal s tuck highSeat height downs wi tch circui t shortcircui t to power
Refer to t he elect rical circuit di agrams andcheck seat height down s wit ch circuit shortci rcuit t o power
B1B96-24Seat Sl ide Forward Swi tch- Signal s tuck highSeat s lide forwards wi tch circui t shortcircui t to power
Refer to t he elect rical circuit di agrams andcheck seat s li de forward swi tch circui t s hortci rcuit t o power

DT C
Description Possible Cause Action
P0814-42 Trans mis s ion range dis play
circuit - general memory
fai lure Int ernal t rans mi ss i on cont rol
modul e (TCM) fault Int ernal gear s elect or module
(GSM) faul t Refer to the warrant y pol icy and procedures
manual i f a module i s s uspect.
P0814-49 Trans mis s ion range dis play
circuit - internal el ect ronic
fai lure Int ernal t rans mi ss i on cont rol
modul e (TCM) fault Int ernal gear s elect or module
(GSM) faul t P081711
Starter dis able ci rcuit open St art l ock out put control
ci rcuit : short ci rcuit t o ground St art l ock out put control
ci rcuit : open ci rcuit Check t he s tarter dis able circui ts . Refer t o t he
el ect ri cal guides . Rect ify as neces s ary.
P0817-12 Starter dis able ci rcuit open St art l ock out put control
ci rcuit : short ci rcuit t o power P081C-49
Park i nput circui t - int ernal
electroni c fai lure Int ernal t rans mi ss i on cont rol
modul e (TCM) fault Int ernal gear s elect or module
(GSM) faul t Refer to the warrant y pol icy and procedures
manual i f a module i s s uspect.
P0826-01 Up and down s wi tch circui t Int ernal t rans mi ss i on cont rol
modul e (TCM) fault Int ernal gear s elect or module
(GSM) faul t Refer to the warrant y pol icy and procedures
manual i f a module i s s uspect.
P085A-00 Gear shi ft module B
communicat ion ci rcuit Local interconnect net work
(LIN) ci rcuit faul t bet ween
the gear s el ect or modul e
(GSM) and t rans mis s ion
control modul e (TCM) Check t he local interconnect net work (LIN)
ci rcuit s. Refer to t he elect rical guides. Recti fy
as neces sary.
P0860-11 Gear shi ft module A
communicat ion ci rcuit Local interconnect net work
(LIN) ci rcuit faul t bet ween
the gear s el ect or modul e
(GSM) and t rans mis s ion
control modul e (TCM) Check t he local interconnect net work (LIN)
ci rcuit s. Refer to t he elect rical guides. Recti fy
as neces sary.
P0860-12 Gear shi ft module A
communicat ion ci rcuit Local interconnect net work
(LIN) ci rcuit faul t bet ween
the gear s el ect or modul e
(GSM) and t rans mis s ion
control modul e (TCM) P0860-13
Gear shi ft module A
communicat ion ci rcuit Local interconnect net work
(LIN) ci rcuit faul t bet ween
the gear s el ect or modul e
(GSM) and t rans mis s ion
control modul e (TCM) P0860-87
Gear shi ft module A
communicat ion ci rcuit -
mi ss ing mess age Local interconnect net work
(LIN) ci rcuit faul t bet ween
the gear s el ect or modul e
(GSM) and t rans mis s ion
control modul e (TCM) P088513
Trans mis s ion control
module (TCM) power relay
cont rol circui t open TCM power relay control
ci rcuit : open ci rcuit TCM power relay faul t Check t he TCM relay and circui ts . Refer t o the
el ect ri cal guides . Rect ify as neces s ary.
P0886-11 Trans mis s ion control
module (TCM) power relay
cont rol circui t low TCM power relay control
ci rcuit : short ci rcuit t o ground TCM power relay faul t
P0894-68
Trans mis s ion component
s lippi ng Transmis si on fluid level l ow Mechanical fault i n the
trans mi ss i on Carry out a compl ete read for related DTCs .
Rect ify as neces s ary. Check t he transmis s ion
fl ui d l evel and condit ion. Recti fy as necess ary.
Refer to the warrant y pol icy and procedures
manual i f the t rans mis s ion is s us pect.
P0895-00 Shift ti me t oo s hort Int ernal t rans mi ss i on cont rol
fault (TCM) Hydraul ic faul t in the
trans mi ss i on Refer to the warrant y pol icy and procedures
manual i f the t rans mis s ion or a modul e i s
sus pect .
P0896-00 Shift ti me t oo long Int ernal t rans mi ss i on cont rol
fault (TCM) Hydraul ic faul t in the
trans mi ss i on

Publi s hed: 11-May-2011
Steering Column Switches - Steering Column Switches
Diagnosi s and Tes ti ng
Principles of Operation
For a detail ed descripti on of the st eering col umn s wit ches , refer to t he relevant Des cript ion and O perati on sect ion i n theworks hop manual .REFER to: St eering Col umn Swit ches (211-05 St eering Col umn Swit ches , Des cript ion and Operat ion).
Inspection and Verification
CAUTION: Di agnos is by s ubs ti tut ion from a donor vehicle is NO T acceptabl e. Subs ti tut ion of cont rol modules doesnot guarant ee confirmat ion of a faul t, and may als o caus e addit ional fault s i n t he vehi cl e being t est ed and/or t he donorvehi cl e.
1. Verify t he cus t omer concern.1.
2. Vis ually ins pect for s ys tem int egrit y and obvi ous s igns of mechanical or el ect ri cal damage.2.
Visual InspectionMechanicalElectrical
Swit chesFus e(s)Electrical connect or(s)W i ri ng Harness
3. If an obvious cause for an obs erved or report ed concern is found, correct t he caus e (if pos s ible) beforeproceeding t o t he next s t ep.3.
4. If t he caus e is not vis ually evi dent , check Central Junct ion Box (CJB) for Diagnost ic Troubl e Codes (DTCs ) andrefer t o t he DTC Index.4.
DTC Index
• NOTE: If the control modul e or a component i s s us pect and the vehicle remains under manufacturer warrant y, refer t o theW arranty Pol icy and Procedures manual (s ect ion B1.2), or determine i f any pri or approval programme is in operat ion, pri ort o the ins tall ati on of a new module/component.
• NOTE: Generic scan t ool s may not read the codes li st ed, or may read only fi ve digit codes . Mat ch the five di git s from t hes can tool to the firs t fi ve di git s of the seven digi t code l is ted to ident ify t he faul t (t he las t t wo digi ts gi ve ext rainformat ion read by the manufact urer-approved diagnost ic s ys tem).
• NOTE: W hen performing volt age or res is t ance t est s , always use a digi tal mult imeter (DMM) accurat e t o t hree deci malplaces and wit h a current cal ibrat ion cert ificate. W hen tes ti ng res i st ance, always take the res is tance of the DMM l eads i ntoaccount.
• NOTE: Check and recti fy bas ic faul ts before beginni ng diagnos t ic rout ines i nvol vi ng pinpoint t es t s.
• NOTE: If DTCs are recorded and, aft er performi ng the pi npoi nt tes ts , a fault is not present , an int ermi tt ent concern maybe t he caus e. Always check for loose connect ions and corroded terminals .
DT CDescriptionPossible CauseActionB109512W iper On/Off Relay -circui t s hort t o powerW iper On/Off rel ay ci rcuit - s hort t opowerRefer t o el ect ri cal circui t di agrams andcheck wiper On/Off rel ay ci rcuit fors hort t o power
B109514W iper On/Off Relay -circui t s hort t o ground oropen
W iper On/Off rel ay ci rcuit - s hort t oground, open circuitRefer t o el ect ri cal circui t di agrams andcheck wiper On/Off rel ay ci rcuit fors hort t o ground, open ci rcuit
B109612W iper High/Low Rel ay -circui t s hort t o powerW iper High/Low relay ci rcuit - s hort t opowerRefer t o el ect ri cal circui t di agrams andcheck wiper High/Low relay ci rcuit fors hort t o powerB109614W iper High/Low Rel ay -circui t s hort t o ground oropen
W iper High/Low relay ci rcuit - s hort t oground, open circuitRefer t o el ect ri cal circui t di agrams andcheck wiper High/Low relay ci rcuit fors hort t o ground, open ci rcuit
B10AC86Cruis e Control Swi tch -Si gnal invali dSi gnal invali dCarry out t he pinpoint t es t s as sociat edt o t his DTC us i ng the manufact urerapproved diagnost ic sys tem
B10AC87Cruis e Control Swi tch -Mi s si ng mes s ageMi s si ng mes s ageCarry out t he pinpoint t es t s as sociat edt o t his DTC us i ng the manufact urerapproved diagnost ic sys temB10AC95Cruis e Control Swi tch -W rong as s emblyMi s -mat ch between Car Configurat ionFi le and vehicleCheck/up-date Car Configurat ion Fil eus ing the manufact urer approveddi agnos ti c s ys t em
B112B07St eering W heel Module -Mechani cal Fail uresAny pos it ion or butt on on wi per st alkacti ve for more t han 60 s econds (180s econds for speed control but tons )Swi tch i nternal fai lure
Check for s t uck wi per or s peed cont rolbut tons . Ins tal l a new s wit ch asrequi red.REFER t o: St eeri ng ColumnMul ti functi on Swit ch (211-05 St eeringCol umn Swit ches , Removal andIns tall ati on).

SymptomPossible CauseAction
REFER t o: Elect roni c Engi ne Cont rol s(303-14A Elect ronic Engine Cont rols - I63.2L Petrol , Diagnosi s and Test ing).For fuel s yst em tes ts .REFER t o: Fuel Tank and Lines (310-01AFuel Tank and Li nes - I6 3.2L Petrol,Di agnos is and Tes t ing).For purge valve t es ts .REFER t o: Evaporat ive Emi ss i ons (303-13Evaporati ve Emis s ions , Diagnosi s andTes ti ng).
Di fficul t hot st artInjector leakElectronic engine controlPurge valveFuel pumpIgni ti on s ys t em
Check for i njector leak, ins tal l newi njector as neces s ary.REFER t o: Fuel Inject or (303-04A FuelChargi ng and Control s - I6 3.2L Pet rol ,Removal and Ins t al lat ion).Read DTCs and refer t o DTC Index forel ect ronic engine cont rol tes t s.REFER t o: Elect roni c Engi ne Cont rol s(303-14A Elect ronic Engine Cont rols - I63.2L Petrol , Diagnosi s and Test ing).For purge valve t es ts .REFER t o: Evaporat ive Emi ss i ons (303-13Evaporati ve Emis s ions , Diagnosi s andTes ti ng).For fuel s yst em tes ts .REFER t o: Fuel Tank and Lines (310-01AFuel Tank and Li nes - I6 3.2L Petrol,Di agnos is and Tes t ing).For igni ti on sys t em t est s .REFER t o: Engi ne Ignit ion (303-07AEngine Ignit ion, Diagnosi s and Test ing).
Di fficul t t o s tart aft er hot s oak(vehi cl e s tanding, engi ne off, aft erengine has reached operati ngt emperature)
Injector leakElectronic engine controlPurge valveFuel pumpIgni ti on s ys t em
Check for i njector leak, ins tal l newi njector as neces s ary.REFER t o: Fuel Inject or (303-04A FuelChargi ng and Control s - I6 3.2L Pet rol ,Removal and Ins t al lat ion).Read DTCs and refer t o DTC Index forel ect ronic engine cont rol tes t s.REFER t o: Elect roni c Engi ne Cont rol s(303-14A Elect ronic Engine Cont rols - I63.2L Petrol , Diagnosi s and Test ing).For purge valve t es ts .REFER t o: Evaporat ive Emi ss i ons (303-13Evaporati ve Emis s ions , Diagnosi s andTes ti ng).For fuel s yst em tes ts .REFER t o: Fuel Tank and Lines (310-01AFuel Tank and Li nes - I6 3.2L Petrol,Di agnos is and Tes t ing).For igni ti on sys t em t est s .REFER t o: Engi ne Ignit ion (303-07AEngine Ignit ion, Diagnosi s and Test ing).
Engine s t al ls s oon after s tartBreat her s ys temdis connected/res trictedECM relayElectronic engine controlIgni ti on s ys t emAir i ntake s yst em res trictedAir l eakageFuel l ines
Ens ure the engine breat her sys tem isfree from rest ri ct ion and is correct lyi nst all edRead DTCs and refer t o DTC Index forel ect ronic engine cont rol tes t s.REFER t o: Elect roni c Engi ne Cont rol s(303-14A Elect ronic Engine Cont rols - I63.2L Petrol , Diagnosi s and Test ing).For igni ti on sys t em t est s .REFER t o: Engi ne Ignit ion (303-07AEngine Ignit ion, Diagnosi s and Test ing).Check for bl ockage in ai r fi lt er el ementand ai r int ake s ys temCheck for ai r leakage i n air i ntakes ys temFor fuel s yst em tes ts .REFER t o: Fuel Tank and Lines (310-01AFuel Tank and Li nes - I6 3.2L Petrol,Di agnos is and Tes t ing).
Engine hes it at es /poor accelerat ionFuel press ure, fuel pump, fuell inesInjector leakAir l eakageElectronic engine controlThrot tl e mot orRes tricted accelerat or pedalt ravel (carpet, et c)
For fuel s yst em tes ts .REFER t o: Fuel Tank and Lines (310-01AFuel Tank and Li nes - I6 3.2L Petrol,Di agnos is and Tes t ing).Check for i njector leak, ins tal l newi njector as neces s ary.REFER t o: Fuel Inject or (303-04A FuelChargi ng and Control s - I6 3.2L Pet rol ,