roof NISSAN NOTE 2016 Service Repair Manual

AV-10
< SYSTEM DESCRIPTION >[BASE AUDIO]
COMPONENT PARTS
Bluetooth® Antenna
INFOID:0000000012432866
Receives the TEL voice signal from cellular phone and outputs it to
the Bluetooth
® control unit.
Steering Wheel Audio Control SwitchesINFOID:0000000012432867
• Operations for audio and hands-free phone are possible.
• Switch is connected to the Bluetooth
® control unit.
MicrophoneINFOID:0000000012432868
• The microphone is installed in the roof in front of the map lamp assembly.
• Power is supplied from the Bluetooth
® control unit.
Rod Antenna, Antenna Amp. and Antenna FeederINFOID:0000000012432869
RADIO ANTENNA
AM/FM radio rod antenna and antenna base is located on the rear of the roof. The antenna amp. is built into
the antenna base.
ANTENNA FEEDER LAYOUT
JSNIA4237ZZ
AWNIA4137ZZ
JPNIA1448ZZ
AWNIA3059GB
Revision: August 2015 2016 Versa Note

cardiagn.com

AV
SYSTEMAV-13
< SYSTEM DESCRIPTION > [BASE AUDIO]
C
D
E
F
G H
I
J
K L
M B A
O P
• Adjust the volume of calls
Microphone
The microphone is located in the roof console asse mbly. The microphone sends a signal to the Bluetooth®
control unit. The microphone can be actively tested during self-diagnosis.
Audio Unit
The audio unit receives signals from the Bluetooth® control unit and sends audio signals to the speakers.
SPEED SENSITIVE VOLUME SYSTEM
Volume level of this system goes up and down automatica lly in proportion to the vehicle speed. The control
level can be selected by the customer. Refer to Owner's Manual for operating instructions.
Revision: August 2015 2016 Versa Note

cardiagn.com

AV-60
< REMOVAL AND INSTALLATION >[BASE AUDIO]
ROD ANTENNA
ROD ANTENNA
Exploded ViewINFOID:0000000012432897
Removal and InstallationINFOID:0000000012432898
REMOVAL
1. Lower the rear portion of the headlining. Refer to
INT-31, "Removal and Installation".
2. Disconnect the harness connectors from t he antenna (satellite radio model shown).
3. Remove the antenna nut (A) and remove the antenna.
INSTALLATION
Installation is in the reverse order of removal.
CAUTION:
If the antenna nut is tightened less than the specified torque this will lower the sensitivity of the
antenna. If the antenna nut is tightened more than the specified torque this will deform the roof panel.
AWNIA3124ZZ
1. Antenna rod 2. Antenna base A. Antenna nut
AWNIA3115ZZ
Revision: August 2015 2016 Versa Note

cardiagn.com

AV
COMPONENT PARTSAV-67
< SYSTEM DESCRIPTION > [DISPLAY AUDIO]
C
D
E
F
G H
I
J
K L
M B A
O P
Steering Wheel Audio Control SwitchesINFOID:0000000012432955
• Operations for audio and hands-free phone are possible.
• Switch is connected to the audio unit.
MicrophoneINFOID:0000000012432956
• The microphone is installed in the roof in front of the map lamp assembly.
• Power is supplied from the audio unit.
Rear View Camera INFOID:0000000012432957
• The rear view camera is installed to the back door finisher.
• Power is supplied from the audio unit.
Rod Antenna, Antenna Amp., Satellite Antenna and Antenna FeederINFOID:0000000012432958
RADIO ANTENNA AND SATELLITE ANTENNA
AM/FM radio rod antenna, antenna base and satellite antenna are located on the rear of the roof. The antenna
amp. and satellite antenna are built into the antenna base.
ALNIA1659ZZ
JPNIA1448ZZ
JPNIA1452ZZ
Revision: August 2015 2016 Versa Note

cardiagn.com

AV
ROD ANTENNAAV-123
< REMOVAL AND INSTALLATION > [DISPLAY AUDIO]
C
D
E
F
G H
I
J
K L
M B A
O P
ROD ANTENNA
Exploded ViewINFOID:0000000012432988
Removal and InstallationINFOID:0000000012432989
REMOVAL
1. Lower the rear portion of the headlining. Refer to INT-31, "Removal and Installation".
2. Disconnect the harness connectors from the antenna (satellite radio model shown).
3. Remove the antenna nut (A) and remove the antenna.
INSTALLATION
Installation is in the reverse order of removal.
CAUTION:
If the antenna nut is tightened l ess than the specified torque this will lower the sensitivity of the
antenna. If the antenna nut is tight ened more than the specified torque this will deform the roof panel.
AWNIA3124ZZ
1. Antenna rod 2. Antenna baseA. Antenna nut
AWNIA3115ZZ
Revision: August 2015 2016 Versa Note

cardiagn.com

AV
COMPONENT PARTSAV-131
< SYSTEM DESCRIPTION > [NAVIGATION]
C
D
E
F
G H
I
J
K L
M B A
O P
USB Interface and AUX In JackINFOID:0000000012433002
• USB Interface and AUX in jack is installed in the console.
•iPod
® and USB memory can be connected to the AV control unit
through the USB interface.
• An external audio device can be connected to the AV control unit through the AUX in jack.
Steering Wheel Audio Control SwitchesINFOID:0000000012433003
• Steering wheel audio control switches are installed in the steering
wheel.
• Operations for audio and hands-free phone are possible.
• Switch is connected to the AV control unit.
MicrophoneINFOID:0000000012433004
• The microphone is installed in the roof in front of the map lamp
assembly.
• Power is supplied from the AV control unit.
Around View Monitor Control UnitINFOID:0000000012433005
• The around view monitor control unit is installed underneath the passenger seat.
• Vehicle width guide lines, predicted course line, vehicle front guid- ing line and vehicle side line, and vehicle icon are displayed and
combined with camera images.
ALNIA1523ZZ
ALNIA1659ZZ
JPNIA1448ZZ
JSNIA5395ZZ
Revision: August 2015 2016 Versa Note

cardiagn.com

AV
COMPONENT PARTSAV-133
< SYSTEM DESCRIPTION > [NAVIGATION]
C
D
E
F
G H
I
J
K L
M B A
O P
AM/FM radio rod antenna, antenna base and satellite antenna are located on the rear of the roof. The antenna
amp. and satellite antenna are built into the antenna base.
ANTENNA FEEDER LAYOUT
AWNIA3133GB
1. Antenna base (antenna amp. and
satellite antenna) 2. Rod Antenna 3. M351
4. M352 5. M110, M3536. M67, M350
7. M111 8. M73
ALNIA1520ZZ
Revision: August 2015 2016 Versa Note

cardiagn.com

AV
ROD ANTENNAAV-255
< REMOVAL AND INSTALLATION > [NAVIGATION]
C
D
E
F
G H
I
J
K L
M B A
O P
ROD ANTENNA
Exploded ViewINFOID:0000000012433108
Removal and InstallationINFOID:0000000012433109
REMOVAL
1. Lower the rear portion of the headlining. Refer to INT-31, "Removal and Installation".
2. Disconnect the harness connectors from the antenna (satellite radio model shown).
3. Remove the antenna nut (A) and remove the antenna.
INSTALLATION
Installation is in the reverse order of removal.
CAUTION:
If the antenna nut is tightened l ess than the specified torque this will lower the sensitivity of the
antenna. If the antenna nut is tight ened more than the specified torque this will deform the roof panel.
AWNIA3124ZZ
1. Antenna rod 2. Antenna baseA. Antenna nut
AWNIA3115ZZ
Revision: August 2015 2016 Versa Note

cardiagn.com

BRM-1
BODY EXTERIOR, DOORS, ROOF & VEHICLE SECURITY
C
DE
F
G H
I
J
L
M
SECTION BRM
A
B
BRM
N
O P
CONTENTS
BODY REPAIR
VEHICLE INFORMATION ... ..........................2
BODY EXTERIOR PAINT COLOR ................ .....2
Body Exterior Paint Color ................................. ......2
PRECAUTION ...............................................3
PRECAUTIONS .............................................. .....3
Precaution for Supplemental Restraint System
(SRS) "AIR BAG" and "SEAT BELT PRE-TEN-
SIONER" ............................................................. ......
3
Precaution for Heating Metal .....................................3
HANDLING PRECAUTIONS FOR PLASTICS .....4
Precautions For Plastics .................................... ......4
PRECAUTIONS IN REPAIRING HIGH
STRENGTH STEEL .............................................
8
High Strength Steel (HSS) ................................ ......8
Handling of Ultra High Strength Steel Plate Parts ....10
PREPARATION ...........................................11
REPAIRING MATERIAL ................................ ....11
Foam Repair ....................................................... ....11
BODY COMPONENT PARTS ............................12
Underbody Component Parts ............................ ....12
Body Component Parts ...........................................14
REMOVAL AND INSTALLATION ...............16
CORROSION PROTECTION .............................16
Description ........................................................... ....16
Anti-Corrosive Wax .................................................16
Undercoating ...........................................................17
BODY SEALING ...............................................19
Description ...............................................................19
REPLACEMENT OPERATIONS .......................22
Description ...............................................................22
Hoodledge ...............................................................25
Front Side Member ..................................................27
Front Pillar ..............................................................28
Dash Side ................................................................31
Center Pillar .............................................................32
Roof .........................................................................35
Outer Sill .................................................................36
Rear Fender ............................................................37
Rear Panel ..............................................................38
Rear Floor Rear .....................................................39
Rear Side Member Extension ...............................40
SERVICE DATA AND SPECIFICATIONS
(SDS) ............... .......................................... ...
41
BODY ALIGNMENT ..........................................41
Body Center Marks ............................................ ....41
Description ...............................................................42
Engine Compartment ..............................................42
Underbody ...............................................................44
Passenger Compartment ........................................47
Rear End Panel .......................................................48
Revision: August 2015 2016 Versa Note

cardiagn.com

BODY COMPONENT PARTSBRM-15
< PREPARATION >
C
DE
F
G H
I
J
L
M A
B
BRM
N
O P
1. Hood assembly (Under 440 MPa) 2. Front fender (LH/RH) (Under 440 MPa) 3. Front roof rail assembly (Under 440
MPa)
4. Roof center reinforcement (590 MPa) 5. Roof bow 3rd (Under 440 MPa)
6. Roof bow 4th (Under 440 MPa)
7. Rear roof rail assembly (Under 440 MPa) 8. Roof (Under 440 MPa)
9. Rear bumper upper retainer (Under
440 MPa)
10. Center pillar lo wer (Under 440
MPa) 11. Outer rear wheel house (LH/RH) (Under
440 MPa) 12. Front inner upper pillar (440 MPa)
13. Center pillar in ner upper (LH/RH)
(440 MPa) 14. Roof rail inner side (LH/RH) (440 MPa) 15. Rear panel upper (Under 440 MPa)
16. Front pillar ou ter reinforcement
(LH/RH) (440 MPa) 17. Center pillar hinge brace (LH/RH) (440
MPa) 18. Roof side rail outer reinforcement (LH/
RH) (440 MPa)
19. Rear inner pillar (LH/RH) (Under 440 MPa) 20. Rear pillar reinforcement (LH/RH) (Under
440 MPa) 21. Center pillar reinforcement (LH/RH)
(440 MPa)
22. Rear pillar reinforcement (LH/RH) (Under 440 MPa) 23. Rear seat belt anchor (LH/RH) (440 MPa) 24. Body side outer front (LH/RH) (Under
440 MPa)
25. Body side outer rear (LH/RH) (Un- der 440 MPa) 26. Body side outer sill (LH/RH) (Under 440
MPa) 27. Front door inner (LH/RH) (Under 440
MPa)
28. Rear door inner (LH/RH) (Under 440 MPa) 29. Front door outer (LH/RH) (Under 440
MPa) 30. Rear door outer (LH/RH) (Under 440
MPa)
31. Center pillar inner reinforcement (LH/RH) (440 MPa) 32. Rear lid assembly (Under 440 MPa)
Front
Revision: August 2015 2016 Versa Note

cardiagn.com