light Peugeot RCZ 2014 Service Manual

160
MANUAL GEARBOX
AUTOMATIC GEARBOX
BRAKE PADS BRAKE DISC WEAR
The gearbox does not require any maintenance (no oil
change).
Refer to the warranty and maintenance record for the details
of the level checking interval for this component.
The gearbox does not require any maintenance (no oil
change).
Refer to the warranty and maintenance record for details of
the level checking interval for this component.
Brake wear depends on the style of driving, particularly in
the case of vehicles used in town, over short distances.
It may be necessary to have the condition of the brakes
checked, even between vehicle services.
Unless there is a leak in the circuit, a drop in the brake fl uid level
indicates that the brake pads are worn. For information on checking brake disc wear, contact a
PEUGEOT dealer or a qualifi ed workshop.
Only use products recommended by PEUGEOT or products of
equivalent quality and specifi cation.
In order to optimise the operation of units as important as those
in the braking system, PEUGEOT selects and offers very specifi c
products.
After washing the vehicle, dampness, or in wintry conditions, ice
can form on the brake discs and pads: braking effi ciency may
be reduced. Make light brake applications to dry and defrost the
brakes.
PARKING BRAKE
If excessive travel or a loss of effectiveness of this system
is noticed, the parking brake must be checked, even
between two services.
Checking this system must be done by a PEUGEOT dealer
or a qualifi ed workshop.

8/
PRACTICAL INFORMATION
DISCONNECTING / RECONNECTING THE
CABLES
To avoid discharging the battery, do not leave the vehicle lighting
on repeatedly with the ignition off (refer to the "Energy economy
mode" paragraph).
It is advisable to disconnect the battery if the vehicle is to be left
unused for more than one month.
Do not disconnect the terminals while the engine is running.
Do not charge the batteries without disconnecting the terminals fi rst.
Before disconnecting the battery
Wait 2 minutes after switching off the ignition before disconnecting
the battery.
Retract the active spoiler then close the windows and the doors
before disconnecting the battery.
Following reconnection of the battery
Following reconnection of the battery, switch on the ignition
and wait 1 minute before starting to permit initialisation of the
electronic systems. However, if slight problems remain following
this operation, contact a PEUGEOT dealer or a qualifi ed
workshop.
Referring to the corresponding section, you must yourself
reinitialise:
- the remote control key,
- the electric windows and the automatic partial opening of the door windows,
- the GPS satellite navigation system.
 Raise the locking tab
D fully.
 Position the open clip E of the cable on the positive terminal (+)
of the battery.
 Press vertically on the clip E to position it correctly against the
battery.
 Lock the clip by lowering the tab D .
CHARGING THE BATTERY USING A BATTERY
CHARGER
 Disconnect the battery from the vehicle.

Follow the instructions for use provided by the manufacturer of the char\
ger.
 Reconnect starting with the negative terminal (-).
 Check that the terminals and connectors are clean. If they are
covered with sulphate (whitish or greenish deposit), remove them
and clean them.
Do not force the tab as locking will not be possible if the clip is not \
positioned correctly.
Start the procedure again. Some functions are not available if the battery is not suffi ciently
charged.

188
DASHBOARD FUSES
The fusebox is placed in the lower section of the dashboard (left-hand \
side). It consists of two boxes.
Access to the fuses
 Refer to the paragraph "Access to the tools".
Fuse tables
Fuse N° Rating Functions
F2 30 A Locking and deadlocking earth.
F3 5 A Airbags, active bonnet and pretensioners
control unit.
F4 10 A Clutch pedal switch, electrochromatic
rear view mirror, automatic gearbox,
switching and protection unit.
F5 30 A One-touch electric windows, folding door
mirrors supply.
F7 5 A Front and rear courtesy lamps, map
reading lamps, sun visor lighting, glove
box lighting.
F8 20 A Audio equipment, audio/telephone,
multifunction screen, tyre under-infl ation
detection, clock.
F9 30 A 12 V socket.
F10 15 A Steering mounted controls.
F 11 15 A Low current ignition switch.
F12 15 A Instrument panel, air conditioning,
driver's seat memory unit, rain /
sunshine sensor, airbags.
Box 1

8/
PRACTICAL INFORMATION
Fuse N° Rating Functions
F13 5 A Engine fusebox, active bonnet.
F14 15 A Multifunction screen, seat belt and
passenger's front airbag warning lamps
display, instrument panel screen,
amplifi er, Bluetooth system, parking
sensors control unit, USB Box.
F15 30 A Locking and deadlocking.
F17 40 A Rear screen and door mirrors demist/
defrost.
Fuse N° Rating Functions
G36 30 A Hi-Fi amplifi er.
G37 30 A Passenger's seat memory unit.
G38 30 A Driver's seat memory unit.
G39 5 A Lighting memory unit.
G40 30 A Driver and passenger heated seats.
Box 2

8/
PRACTICAL INFORMATION
TOWING A TRAILER
Towbar suitable for the attachment of a trailer with additional lighting \
and signalling.
Your vehicle is primarily designed for transporting people and luggage,
but it may also be used for towing a trailer. We recommend use of the PEUGEOT genuine towbar with ball
which can be removed without tools and its harness that have
been tested and approved from the design stage of your vehicle,
and that the fi tting of the towbar is entrusted to a PEUGEOT
dealer or a qualifi ed workshop.
If the trailer is fi tted outside the PEUGEOT dealer network, it must
be fi tted in accordance with the manufacturer's instructions.
DRIVING ADVICE
Driving with a trailer subjects the towing vehicle to more signifi cant
stress and its driver must be particularly careful.
Distribution of loads
 Distribute the load in the trailer so that the heaviest items are as close as possible to the axle and the nose weight approaches the
maximum permitted without exceeding it.
Air density decreases with altitude, thus reducing engine performance.
Above 1 000 metres, the maximum towing load must be reduced by
10 % and so on for every 1 000 metres of altitude.
Refer to the "Technical data" section for details of the weights and
towing loads which apply to your vehicle version.
Side wind
 Take into account the increased sensitivity to side wind.

196
Cooling
Towing a trailer on a slope increases the temperature of the coolant.
As the fan is electrically controlled, its cooling capacity is not depen\
dent
on the engine speed.
 To lower the engine speed, reduce your speed.
The maximum towing load on a long slope depends on the gradient and
the ambient temperature.
In all cases, pay attention to the coolant temperature.
Braking
Towing a trailer increases the braking distance.
Tyres
 Check the tyre pressures of the towing vehicle and of the trailer, observing the recommended pressures.
Lighting
 Check the electrical signalling on the trailer.  If the warning lamp and the
STOP warning lamp come
on, stop the vehicle and switch off the engine as soon as
possible. The rear parking sensors will be deactivated automatically if a
genuine PEUGEOT towbar is used.
When not towing a trailer, remove the quickly-detachable tow ball
before driving, so as to avoid masking the central rear lamp.

198
MATT PAINT
If you vehicle is fi nished with a clear matt lacquer, please observe the
following recommendations to avoid damaging the paintwork by the use
of an inappropriate cleaning procedures.
These recommendations are also valid for alloy road wheels fi nished
with clear matt lacquer. Never clean the vehicle without water.
Never wash your vehicle in an automatic roller brush car wash.
Never polish the vehicle body, nor the alloy wheels. Doing this will
make the paintwork shiny.
Do not use paint cleaners, abrasive products or paint polishing or
preserving products (such as wax, for example) on the paintwork.
These products are only suitable for bright fi nishes. Application of
these products on vehicles with a matt fi nish will seriously damage
the paint surface of the vehicle, giving rise to irreversible shiny or
stained areas.
Never use a high pressure jet wash with a lance fi tted with a
brush, this may scratch the paintwork.
Never select a wash programme that fi nishes with a hot wax
cycle. From the range of cleaning and maintenance products in the
"TECHNATURE" range recommended and approved by PEUGEOT,
use only the insect remover and car shampoo, which are the only
products to be used on the bodywork.
The insect remover can also be used to remove minor marks
(for example: fi nger marks...).
Always have paint repairs done by a PEUGEOT dealer or a qualifi ed
workshop.
We recommend the use of a high pressure jet wash, or at least a
water hose with a high output.
We recommend that the vehicle be rinsed using de-ionised water.
Use only a microfi bre cloth to dry the vehicle. It must be clean and
used without heavy pressure.
Lightly wipe off any fuel stains present on the bodywork using a
soft cloth, then leave to dry.

202
* The weight of the braked trailer can be increased, within the GTW limit,\
on condition that the GVW of the towing vehicle is reduced by the same \
amount; warning: towing with a lightly loaded towing vehicle may have an\
adverse effect on its road holding.
Engines
1.6 litre THP
150 hp 1.6 litre THP 156 hp 1.6 litre THP
163 hp 1.6 litre THP
200 hp 1.6 litre THP
270 hp
Gearboxes Automatic Manual Auto. Automatic Manual Manual
Model codes: 4J... 5FE-J 5FV-8 5FV-A 5FM-J 5FU-8 5FGM
- Unladen weight 1 297 1 275 1 297 1 297 1 297 1 280
- Kerb weight 1 372 1 350 1 372 1 372 1 372 1 355
- Payload 463 465 463 463 483 425
- Gross vehicle weight (GVW) 1 760 1 740 1 760 1 760 1 780 1 780
- Gross train weight (GVW)
on a 12% gradient 2 260 2 240 2 260 2 260 2 280 1 780
- Braked trailer (within GTW limit)
on a 10% or 12% gradient 500 500 500 500 500 0
- Braked trailer * (with load transfer within GTW limit) 650
650 650 650 650 0
- Unbraked trailer 500 500 500 500 500 0
- Recommended nose weight 65 65 65 65 65 0
The GTW and towed load values indicated apply up to a maximum altitude o\
f 1000 metres; the towed load mentioned must be reduced by 10 % for
every additional 1000 metres.
The speed of a towing vehicle must not exceed 60 mph (100 km/h) (comp\
ly with the legislation in force in your country).
High ambient temperatures may result in a reduction in the performance o\
f the vehicle to protect the engine; when the ambient temperature is
higher than 37 °C, limit the towed weight.
PETROL WEIGHTS AND TOWED LOADS (IN KG)

204
* The weight of the braked trailer can be increased, within the GTW limit,\
on condition that the GVW of the towing vehicle is reduced by the same \
amount; warning: towing with a lightly loaded towing vehicle may have an\
adverse effect on its road holding.
Diesel engine
2.0 litre HDi 163 hp
Gearbox Manual
Model codes: 4J... RHH-8
- Unladen weight 1 370
- Kerb weight 1 445
- Payload 455
- Gross vehicle weight (GVW) 1 825
- Gross train weight (GTW)
on a 12% gradient 2 325
- Braked trailer (within GTW limit)
on a 10% or 12% gradient 500
- Braked trailer * (with load transfer within GTW limit) 650
- Unbraked trailer 500
- Recommended nose weight 65
The GTW and towed load values indicated apply up to a maximum altitude o\
f 1000 metres; the towed load mentioned must be reduced by 10 % for
every additional 1000 metres.
The speed of a towing vehicle must not exceed 60 mph (100 km/h) (comp\
ly with the legislation in force in your country).
High ambient temperatures may result in a reduction in the performance o\
f the vehicle to protect the engine; when the ambient temperature is
higher than 37 °C, limit the towed weight.
DIESEL WEIGHTS AND TOWED LOADS (IN KG)

01
213
FIRST STEPS
PEUGEOT Connect Media Navigation (NG4 3D) navigator
Press to left / right:
With display of the "RADIO" screen: select the previous / next frequency.
With display of the "MEDIA" screen: select the previous / next track.
With display of the "MAP" or "NAV": horizontal movement on the map.
Press up / down:
With display of the "RADIO" screen: select the previous / next radio station in the list.
With display of the "MEDIA" screen: select the MP3 folder.
With display of the "MAP" or "NAV": vertical movement on the map.
Go the the next or previous page in a menu.
Movement on the virtual keypad displayed.
OK: confi rm the highlighted item. END CALL: access to the Phone menu.
End a call in progress or reject an incoming call, Bluetooth connection.
Normal display or black screen.
Select successive display in the screen of "MAP" / "NAV" (if navigation in progress) / "TEL" (if a call is in progress) / "RADIO" or "MEDIA" being played.
CALL: access to the Phone menu.
Bluetooth connection, accept an incoming call.
Rotate the dial:
With display of the "RADIO" screen: select the previous / next radio station in the list.
With display of the "MEDIA" screen: select the previous / next CD or MP3 track.
With display of the "MAP" or "NAV": zoom the map in/out.
Movement of the menu selection cursor.