ecm SSANGYONG KORANDO 1997 Service Repair Manual
[x] Cancel search | Manufacturer: SSANGYONG, Model Year: 1997, Model line: KORANDO, Model: SSANGYONG KORANDO 1997Pages: 2053, PDF Size: 88.33 MB
Page 1868 of 2053
2-4 2-4 2-4 2-4
2-4
ELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMSELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMS
ELECTRICAL WIRING DIAGRAMS
Engine Room Fuse Box - W/H Main
Engine Room Fuse Box - W/H Main
Engine Room Fuse Box - W/H Main
Engine Room FuseBox - W/H Main
Engine Room Fuse Box - W/H Engine Room
Engine Room Fuse Box - W/H Engine Room
Engine Room Fuse Box - W/H Engine Room
Engine Room Fuse Box - W/H Engine Room
W/H Engine Room - W/H Pre - Heating
W/H Engine Room - W/H Alternator
W/H Engine Room - W/H Alternator
W/H Engine Room - W/H Wheel G. sensor
W/H Engine Room - W/H Main
W/H Engine Room - W/H Main
W/H Engine Control - W/H ECM Main
W/H Engine Control - W/H ECM Main
W/H Main - W/H Fuel Cut Solenoid
W/H Main - W/H Roof
W/H Main - W/H Air Bag
W/H Main - W/H Air Bag
W/H Main - W/H SDM
W/H Main - W/H Air Conditioner
W/H Main - W/H ECM Main
W/H Main - W/H Transmission
W/H Main - W/H Transmission
W/H Main - W/H Transmission
W/H Main - W/H Fuel Pump
W/H Main - W/H Fuel Pump
W/H Main - W/H Fuel Pump
W/H Main - W/H Seat Heater
W/H Main - W/H Main
W/H Main - W/H FRT LH Door
W/H FRT LH Door - W/H Speaker
W/H Main - W/H FRT RH Door
W/H FRT RH Door - W/H Speaker
G201W/H Main Upper Front Left Leg Room
G202W/H Main Upper Front Left Leg Room
G203W/H Main Left Upper Center Facia
G204W/H Main Left Lower Center Facia
G205W/H Main Center "A" Pillar Front Right
G301W/H Main Below Front Left seat
G302W/H Main Below Center Console
G303W/H Main Below Front Right seat
G401W/H Main Inside Lower Trim Rear Left Quater
Engine Room Fuse Box
Engine Room Fuse Box
Engine Room Fuse Box
Engine Room Fuse Box
Engine Room Fuse Box
Engine Room Fuse Box
Engine Room Fuse Box
Engine Room Fuse Box
Bhind Battery
Below Air Cleaner
Below Air Cleaner
Upper Front Right Control Arm
Next to Hydraulic Unit
Next to Hydraulic Unit
Behind Hydraulic Unit
Behind Hydraulic Unit
Next to Engine Room Fuse Box
Inside Left Cluster
Above FRT LH Seat Under Cover
Above FRT LH Seat Under Cover
Lower Rear Center Facia
Upper Evaporator
Lower "A" Piller(Upper ECM)
Upper Transfer Case
Upper Transfer Case
Upper Transfer Case
Upper Transfer Case
Upper Transfer Case
Upper Transfer Case
Below FRT LH Seat
Below Center Console
Upper Fuse Box
(Passenger Room)
Inside FRT LH Door Trim
Behind Front Right Panel
Inside FRT RH Door Trim
2. 2.2. 2.
2.
CONNECT CONNECTCONNECT CONNECT
CONNECT
OR, OR,OR, OR,
OR,
GR GR GR GR
GR
OUND AND SPLICE PA OUND AND SPLICE PAOUND AND SPLICE PA OUND AND SPLICE PA
OUND AND SPLICE PA
CK INFORMA CK INFORMACK INFORMA CK INFORMA
CK INFORMA
TION TIONTION TION
TION1) 1)1) 1)
1)
CONNECTOR CONNECTORCONNECTOR CONNECTOR
CONNECTORConnector Number Connector NumberConnector Number Connector Number
Connector Number
(Pin Number, Color) (Pin Number, Color)(Pin Number, Color) (Pin Number, Color)
(Pin Number, Color)Connecting Connecting Connecting Connecting
Connecting
Wiring Harness Wiring HarnessWiring Harness Wiring Harness
Wiring Harness
Connector Position Connector PositionConnector Position Connector Position
Connector Position
C101 (19Pin, White)
C102 (4Pin, Colorless)
C103 (22Pin, White)
C104 (8Pin, Colorless)
C105 (10Pin, White)
C106 (3Pin, Black)
C107 (20Pin, White)
C108 (6Pin, Colorless)
C109 (1Pin, Black)
C110 (2Pin, Black)
C110 (4Pin, Black)
C111 (3Pin, Black)
C112 (6Pin, Black)
C113 (12Pin, Black)
C114 (6Pin, Gray)
C115 (40Pin, Black)
C116 (3Pin, Black)
C201 (8Pin, White)
C202 (4Pin, White)
C203 (2Pin, Black)
C204 (4Pin, Colorless)
C205 (17Pin, White)
C206 (6Pin, Black)
C301 (2Pin, Black)
C301 (16Pin, Black)
C302 (10Pin, Black)
C303 (3Pin, Black)
C303 (4Pin, Black)
C303 (6Pin, Black)
C304 (10Pin, White)
C305 (14Pin, White)
C351 (22Pin, White)
C352 (2Pin, Black)
C361 (22Pin, Blue)
C362 (2Pin, Black)
2) 2)2) 2)
2)
SPLICE PACK SPLICE PACKSPLICE PACK SPLICE PACK
SPLICE PACK
S201
S202
S203
S204
S205Splice Pack Position Splice Pack PositionSplice Pack Position Splice Pack Position
Splice Pack Position Wiring WiringWiring Wiring
Wiring
Harness HarnessHarness Harness
Harness Color ColorColor Color
Color Splice Pack Splice PackSplice Pack Splice Pack
Splice Pack
Number NumberNumber Number
Number
Colorless
Black
Colorless
Colorless
ColorlessW/H Main
W/H Main
W/H Main
W/H Main
W/H MainUpper Fuse Box(Passenger Room)
Behind Cluster
Behind 4WD Switch
Behind Audio
Behind Front Right Kick Panel
Remark RemarkRemark Remark
Remark
Diesel only
Gasoline
Diesel
Gasoline
Gasoline
Diesel
Gasoline
Manual T/M
Automatic T/M
Diesel
Diesel
Gasoline
GSL : EURO IIIBehind Left Tail Lamp
Behind Left Tail Lamp
Inside Rear Bumper
Inside Tail Gate
Connector Number Connector NumberConnector Number Connector Number
Connector Number
(Pin Number, Color) (Pin Number, Color)(Pin Number, Color) (Pin Number, Color)
(Pin Number, Color)Connecting Connecting Connecting Connecting
Connecting
Wiring Harness Wiring HarnessWiring Harness Wiring Harness
Wiring Harness
Connector Position Connector PositionConnector Position Connector Position
Connector Position
C401 (2Pin, Black)
C402 (12Pin, Black)
C403 (3Pin, Black)
C404 (2Pin, Black)W/H Tail Gate - W/H Main
W/H Tail Gate - W/H Main
W/H Rear Bumper - W/H Main
W/H Tail Gate - W/H HMSL
Remark RemarkRemark Remark
Remark
3) 3)3) 3)
3)
GROUND GROUNDGROUND GROUND
GROUND
G101
G102
G103Ground Position Ground PositionGround Position Ground Position
Ground Position
Wiring Harness Wiring HarnessWiring Harness Wiring Harness
Wiring Harness Number NumberNumber Number
Number
Ground GroundGround Ground
Ground
W/H Engine Room
Battery
W/H Engine RoomLeft Fender Next to Battery
Center Engine Block
Right Fender Engine Room
Pin PinPin Pin
Pin
Number NumberNumber Number
Number
8
20
14
14
8
Page 1871 of 2053
ELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMSELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMS
ELECTRICAL WIRING DIAGRAMS
2-7 2-7 2-7 2-7
2-7
2) 2)2) 2)
2)
W/H MAIN W/H MAINW/H MAIN W/H MAIN
W/H MAIN• W/H MAIN
1. C351
2. S201
3. G201
4. G202
5. Auto down unit
6. HLLD switch
7. OSRV switch
8. Rear wiper & washer switch
8-1. DLC9. C201
10. Clutch switch "A"
11. Clutch switch "B" (Gasoline E/G)
12. Stop lamp switch
13. Dimmer & passing switch
14. Turn signal,FRT fog lamp & Light switch
15. Wiper switch
16. J201
17. C20218. Immobilizer antenna
19. Ignition switch
20. Cruise control switch
21. Key reminder switch
22. C203
23. Acceleration pedal sensor
24. Kick down switch
25. REKES
26. ADD' (LH)
27. Diagnosis connector
28. Brake fluid switch
29. Locking hud solenoid (TCCU)
30. C116
31. Cluster "D"
32. Cluster "C"
33. Cluster "B"
34. Cluster "A"
35. J202
36. J202
37. J203
38. S203
39. 4WD switch
40. Hazard switch
41. Defroster switch
42. -
43. Antenna feeder cable
44. S204
45. Audio
46. -
47. SDM
48. G204
49. C204
50. Chime Bell
51. Buzzer
52. Acceleration sensor
53. G203
54. Cigar lighter
55. Central door lock relay
56. BTSI solenoid
57. A/Tsocket
58. BTSI "P" position sw
59. Mode switch
60. Shift motor
61. Speed sensor & clutch coil
62. VSS
63. C301
64. C302
65. C30366. C304
67. TCM
68. TOD Resistor (Gasoline E/G)
69. G301
70. TOD or TCCU
71. FRT LH seat belt sw
72. Parking brake sw
73. W/D Burglar connector
74. Seat heater switch
75. STICS
76. G303
77. -
78. OVPR (Gasoline E/G)
79. C305
80. Seat belt sw (FRT RH)
81. EBCM (ADD)
82. G303
83. C205
84. Thermo amp
85. Passenger inflator
86. -
87. -
88. Front wiper motor
89. Siren
90. O2 sensor 1 / (Gasoline E/G)
91. EBCM (ABS) & Modulator (ABD)
92. J105
93. C113
94. C112
95. EGR solenoid (Diesel E/G)
96. C114 (Gasoline E/G)
97. C115 (Gasoline E/G)
98. J204 (Gasoline E/G)
99. S205
100.J205 (Gasoline E/G)
101.Antenna feeder cable
102.Auto antenna
103.C206
104.ECM (GSL) or Immobilizer unit (DSL)
105.EGR control unit (Diesel E/G)
106. G205
107.C361
108. O2 sensor 2 (Gasoline E/G)
FUSE
BOX
RELAY
BOX
FUSE &
RELAY BOX
A
1011
12131415171618192021222829
30
26
27
31323334
35
3637
38
394041
43
83888990
91
93
9495
9296
979899102
101100
106107
104105
103
108
84
85
44
8-1
4748
49
50
51
52
53
45
55
54565758
60616263
6465
66
67
68
71
72
73
74
7576
78
7980
8182
69
70
59
232425
13
4259678
Page 1895 of 2053
CONTENTS CONTENTSCONTENTS CONTENTS
CONTENTS
1. 1.1. 1.
1.
ST STST ST
ST
AR ARAR AR
AR
TING & CHARGING SYSTEM TING & CHARGING SYSTEMTING & CHARGING SYSTEM TING & CHARGING SYSTEM
TING & CHARGING SYSTEM
........................................................................................... ...................................................................................................................................................................................... ...........................................................................................
...........................................................................................
5-6 5-6 5-6 5-6
5-6
1) DIESEL..................................................................................................................................................................... 5-6
2) GASOLINE.................................................................................................................................................................. 5-8
2. 2.2. 2.
2.
DIAGNOSIS CONNECTOR DIAGNOSIS CONNECTORDIAGNOSIS CONNECTOR DIAGNOSIS CONNECTOR
DIAGNOSIS CONNECTOR
........................................................................................................ ................................................................................................................................................................................................................ ........................................................................................................
........................................................................................................
5-10 5-10 5-10 5-10
5-10
1) DIESEL................................................................................................................................................................... 5-10
2) GASOLINE.............................................................................................................................................................. 5-12
(1) W/O EURO III .................................................................................................................................................................................... 5-12
(2) W/ EURO III ....................................................................................................................................................................................... 5-14
3. 3.3. 3.
3.
PRE-HEA PRE-HEAPRE-HEA PRE-HEA
PRE-HEA
TING SYSTEM TING SYSTEMTING SYSTEM TING SYSTEM
TING SYSTEM
............................................................................................................ ........................................................................................................................................................................................................................ ............................................................................................................
............................................................................................................
5-16 5-16 5-16 5-16
5-16
4. 4.4. 4.
4.
EGR (EXHA EGR (EXHAEGR (EXHA EGR (EXHA
EGR (EXHA
UST GAS RECIRCULA UST GAS RECIRCULAUST GAS RECIRCULA UST GAS RECIRCULA
UST GAS RECIRCULA
TION) SYSTEM TION) SYSTEMTION) SYSTEM TION) SYSTEM
TION) SYSTEM
............................................................... .............................................................................................................................. ...............................................................
...............................................................
5-18 5-18 5-18 5-18
5-18
1) MANUAL TRANSMISSION .................................................................................................................................... 5-18
2) AUTOMATIC TRANSMISSION.............................................................................................................................. 5-20
5. 5.5. 5.
5.
ECM (ELECTRONIC CONTROL MODULE) : E23 MSE ECM (ELECTRONIC CONTROL MODULE) : E23 MSEECM (ELECTRONIC CONTROL MODULE) : E23 MSE ECM (ELECTRONIC CONTROL MODULE) : E23 MSE
ECM (ELECTRONIC CONTROL MODULE) : E23 MSE
......................................................... .................................................................................................................. .........................................................
.........................................................
5-22 5-22 5-22 5-22
5-22
1) SENSOR (CRANK SHAFT POSITION, ACCELERATION PEDAL), THROTTLE MOTOR & SENSOR, IGNTION
COIL & SPARK PLUG ........................................................................................................................................... 5-22
SECTION 5 SECTION 5SECTION 5 SECTION 5
SECTION 5
ELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMSELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMS
ELECTRICAL WIRING DIAGRAMS
Page 1896 of 2053
2) INJECTOR, FUEL PUMP RELAY, FUEL PUMP, IMMOBILIZER ........................................................................ 5-24
(1) W/O EURO III .................................................................................................................................................................................... 5-24
(2) W/ EURO III ....................................................................................................................................................................................... 5-26
3) SENSOR (CAM SHAFT POSITION, MAP, O
2), CAM SHAFT ACTUATOR ...................................................... 5-28
(1) W/O EURO III .................................................................................................................................................................................... 5-28
(2) W/ EURO III ....................................................................................................................................................................................... 5-30
4) SENSOR (ENGINE TEMPERATURE, INTAKE AIR TEMP', KNOCK),
CANISTER PURGE VALVE, DIAGNOSIS........................................................................................................... 5-32
(1) W/O EURO III .................................................................................................................................................................................... 5-32
(2) W/ EURO III ....................................................................................................................................................................................... 5-34
5) VEHICLE SPEED SENSOR, SWITCH (CRUISE CONTROL, STOP LAMP, INHIBITOR, CLUTCH) ............. 5-36
6. 6. 6. 6.
6.
ECM (ELECTRONIC CONTROL MODULE) : E32 MSE ECM (ELECTRONIC CONTROL MODULE) : E32 MSEECM (ELECTRONIC CONTROL MODULE) : E32 MSE ECM (ELECTRONIC CONTROL MODULE) : E32 MSE
ECM (ELECTRONIC CONTROL MODULE) : E32 MSE
......................................................... .................................................................................................................. .........................................................
.........................................................
5-38 5-38 5-38 5-38
5-38
1) SENSOR (CRANK SHAFT POSITION, ACCELERATION PEDAL), THROTTLE MOTOR.......................................
& SENSOR, IGNTION COIL & SPARK PLUG .................................................................................................... 5-38
2) INJECTOR, FUEL PUMP RELAY, FUEL PUMP, IMMOBILIZER ........................................................................ 5-40
(1) W/O EURO III .................................................................................................................................................................................... 5-40
(2) W/ EURO III ....................................................................................................................................................................................... 5-42
3) SENSOR (CAM SHAFT POSITION, AIR FLOW), INTAKE MANIFOLD RESONANCE ............................................
FLAP, CAM SHAFT ACTUATOR, FUEL GAUGE................................................................................................ 5-44
(1) W/O EURO III .................................................................................................................................................................................... 5-44
(2) W/ EURO III ....................................................................................................................................................................................... 5-46
4) SENSOR (ENGINE TEMPERATURE, KNOCK1, KNOCK2), CANISTER PURGE VALVE, DIAGNOSIS....... 5-48
5) VEHICLE SPEED SENSOR, SWITCH (CRUISE CONTROL, STOP LAMP, INHIBITOR, CLUTCH) ............. 5-50
6) O
2 SENSOR (1,2,3,4) ............................................................................................................................................. 5-52
7. 7. 7. 7.
7.
TCM (TRASMISSION CONTROL MODULE) - DIESEL TCM (TRASMISSION CONTROL MODULE) - DIESELTCM (TRASMISSION CONTROL MODULE) - DIESEL TCM (TRASMISSION CONTROL MODULE) - DIESEL
TCM (TRASMISSION CONTROL MODULE) - DIESEL
........................................................... ...................................................................................................................... ...........................................................
...........................................................
5-54 5-54 5-54 5-54
5-54
1) MODE SWITCH, INDICATOR, DIAGNOSIS........................................................................................................ 5-54
2) TRANSMISSION, INDICATOR, T/M LEVER, KICK DOWN SWITCH............................................................... 5-56
8. 8. 8. 8.
8.
TCM (TRASMISSION CONTROL MODULE) - GASOLINE TCM (TRASMISSION CONTROL MODULE) - GASOLINETCM (TRASMISSION CONTROL MODULE) - GASOLINE TCM (TRASMISSION CONTROL MODULE) - GASOLINE
TCM (TRASMISSION CONTROL MODULE) - GASOLINE
..................................................... .......................................................................................................... .....................................................
.....................................................
5-58 5-58 5-58 5-58
5-58
1) MODE SWITCH, INDICATOR, DIAGNOSIS........................................................................................................ 5-58
2) TRANSMISSION, INDICATOR, T/M LEVER, KICK DOWN SWITCH............................................................... 5-60
Page 1906 of 2053
5-12 5-12 5-12 5-12
5-12
ELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMSELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMS
ELECTRICAL WIRING DIAGRAMS
a. a.a. a.
a.
CONNECTOR INFORMATION CONNECTOR INFORMATIONCONNECTOR INFORMATION CONNECTOR INFORMATION
CONNECTOR INFORMATION
b. b.b. b.
b.
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITIONCONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
ECMTOD "A"
TCM "A"TOD "B"
TCM "B"
C204 (COLORLESS)DIAGNOSIS CONNECTOR
S203 (COLORLESS) S202 (BLACK)
2) 2)2) 2)
2)
GASOLINE GASOLINEGASOLINE GASOLINE
GASOLINE
(1) W/O EURO III (1) W/O EURO III(1) W/O EURO III (1) W/O EURO III
(1) W/O EURO III
CLUSTER "A"
Engine Room Fuse Box - W/H Main
W/H Main - W/H SDM
W/H Main
W/H Main
W/H Main C104 (8Pin, Colorless)
C204 (4Pin, Colorless)
S202 (20Pin, Black)
S203 (14Pin, Colorless)
G201
CONNECTOR(NUMBER) CONNECTOR(NUMBER)CONNECTOR(NUMBER) CONNECTOR(NUMBER)
CONNECTOR(NUMBER)
CONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESSCONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESS
CONNECTING. WIRING HARNESS
Engine Room Fuse Box
Lower Rear Center Facia
Behind Cluster
Behind 4WD Switch
Upper Front Leftt Leg Room
CONNECTOR POSITION CONNECTOR POSITIONCONNECTOR POSITION CONNECTOR POSITION
CONNECTOR POSITION
Page 1908 of 2053
5-14 5-14 5-14 5-14
5-14
ELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMSELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMS
ELECTRICAL WIRING DIAGRAMS
a. a.a. a.
a.
CONNECTOR INFORMATION CONNECTOR INFORMATIONCONNECTOR INFORMATION CONNECTOR INFORMATION
CONNECTOR INFORMATION
b. b.b. b.
b.
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITIONCONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
ECMTOD "A"
TCM "A"
TOD "B"
TCM "B"
C204 (COLORLESS)DLC
S203 (COLORLESS) S202 (BLACK)
(2) W/ EURO III (2) W/ EURO III(2) W/ EURO III (2) W/ EURO III
(2) W/ EURO III
CLUSTER "A"
Engine Room Fuse Box - W/H Main
W/H Main - W/H SDM
W/H Main
W/H Main
W/H Main C104 (8Pin, Colorless)
C204 (4Pin, Colorless)
S202 (20Pin, Black)
S203 (14Pin, Colorless)
G201
CONNECTOR(NUMBER) CONNECTOR(NUMBER)CONNECTOR(NUMBER) CONNECTOR(NUMBER)
CONNECTOR(NUMBER)
CONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESSCONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESS
CONNECTING. WIRING HARNESS
Engine Room Fuse Box
Lower Rear Center Facia
Behind Cluster
Behind 4WD Switch
Upper Front Leftt Leg Room
CONNECTOR POSITION CONNECTOR POSITIONCONNECTOR POSITION CONNECTOR POSITION
CONNECTOR POSITION
Page 1916 of 2053
5-22 5-22 5-22 5-22
5-22
ELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMSELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMS
ELECTRICAL WIRING DIAGRAMS
b. b.b. b.
b.
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITIONCONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITIONTHROTTILE
MOTOR &
SENSOR
ECM
123
456
2167
5348
OVPR CRANK SHAFT
POSITION
SENSORACCELERATION
PEDAL SENSOR
5. 5.5. 5.
5.
ECM (ELECTRONIC CONTROL MODULE) : E23 MSE ECM (ELECTRONIC CONTROL MODULE) : E23 MSEECM (ELECTRONIC CONTROL MODULE) : E23 MSE ECM (ELECTRONIC CONTROL MODULE) : E23 MSE
ECM (ELECTRONIC CONTROL MODULE) : E23 MSE1) 1)1) 1)
1)
SENSOR (CRANK SHAFT POSITION, ACCELERATION PEDAL), THROTTLE SENSOR (CRANK SHAFT POSITION, ACCELERATION PEDAL), THROTTLESENSOR (CRANK SHAFT POSITION, ACCELERATION PEDAL), THROTTLE SENSOR (CRANK SHAFT POSITION, ACCELERATION PEDAL), THROTTLE
SENSOR (CRANK SHAFT POSITION, ACCELERATION PEDAL), THROTTLE
MOTOR & SENSOR, IGNITION COIL & SPARK PLUG MOTOR & SENSOR, IGNITION COIL & SPARK PLUGMOTOR & SENSOR, IGNITION COIL & SPARK PLUG MOTOR & SENSOR, IGNITION COIL & SPARK PLUG
MOTOR & SENSOR, IGNITION COIL & SPARK PLUG
a. a.a. a.
a.
CONNECTOR INFORMATION CONNECTOR INFORMATIONCONNECTOR INFORMATION CONNECTOR INFORMATION
CONNECTOR INFORMATION
C114 (GRAY) IGNITION COIL
C206 (BLACK)
C115 (BLACK)
C102 (4Pin, Colorless)
C104 (8Pin, Colorless)
C114 (6Pin, Gray)
C115 (2Pin, Black)
C206 (6Pin, Black)
J108
G302CONNECTOR(NUMBER) CONNECTOR(NUMBER)CONNECTOR(NUMBER) CONNECTOR(NUMBER)
CONNECTOR(NUMBER)
CONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESSCONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESS
CONNECTING. WIRING HARNESS
CONNECTOR POSITION CONNECTOR POSITIONCONNECTOR POSITION CONNECTOR POSITION
CONNECTOR POSITION
Engine Room Fuse Box - W/H Main
Engine Room Fuse Box - W/H Main
W/H Engine Control - W/H ECM Main
W/H Engine Control - W/H ECM Main
W/H Main - W/H ECM Main
W/H Engine Control
W/H MainEngine Room Fuse Box
Engine Room Fuse Box
Behind Hydraulic Unit
Behind Hydraulic Unit
Lower "A" Piller (Upper ECM)
Upper Injecter #4 (4CYL) or #6 (6CYL)
Below Center Console
Page 1918 of 2053
5-24 5-24 5-24 5-24
5-24
ELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMSELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMS
ELECTRICAL WIRING DIAGRAMS2) 2)2) 2)
2)
INJECTOR, FUEL PUMP RELAY, FUEL PUMP, IMMOBILIZER INJECTOR, FUEL PUMP RELAY, FUEL PUMP, IMMOBILIZERINJECTOR, FUEL PUMP RELAY, FUEL PUMP, IMMOBILIZER INJECTOR, FUEL PUMP RELAY, FUEL PUMP, IMMOBILIZER
INJECTOR, FUEL PUMP RELAY, FUEL PUMP, IMMOBILIZER
(1) W/O EURO III (1) W/O EURO III(1) W/O EURO III (1) W/O EURO III
(1) W/O EURO III
b. b.b. b.
b.
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITIONCONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
IMMOBILIZER
ANTENNA
ECM
OVPR
INJECTOR
a. a.a. a.
a.
CONNECTOR INFORMATION CONNECTOR INFORMATIONCONNECTOR INFORMATION CONNECTOR INFORMATION
CONNECTOR INFORMATION
C114 (GRAY) FUEL PUMP
C206 (BLACK)
C115 (BLACK)
C303 (BLACK)
C102 (4Pin, Colorless)
C104 (8Pin, Colorless)
C114 (6Pin, Gray)
C115 (40Pin, Black)
C206 (6Pin, Black)
C303 (4Pin, Black)
J107
J205
G201
G205
G302CONNECTOR(NUMBER) CONNECTOR(NUMBER)CONNECTOR(NUMBER) CONNECTOR(NUMBER)
CONNECTOR(NUMBER)
CONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESSCONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESS
CONNECTING. WIRING HARNESS
CONNECTOR POSITION CONNECTOR POSITIONCONNECTOR POSITION CONNECTOR POSITION
CONNECTOR POSITION
Engine Room Fuse Box - W/H Main
Engine Room Fuse Box - W/H Main
W/H Engine Control - W/H ECM Main
W/H Engine Control - W/H ECM Main
W/H Main - W/H ECM Main
W/H Main - W/H Fuel Pump
W/H Engine Control
W/H Main
W/H Main
W/H Main
W/H MainEngine Room Fuse Box
Engine Room Fuse Box
Behind Hydraulic Unit
Behind Hydraulic Unit
Lower "A" Piller (Upper ECM)
Upper Transfer Case
Next to Yellow Label
Behind Front Right Kick Panel
Upper Front Left Leg Room
Center "A" Piller Front Right
Below Center Console
Page 1920 of 2053
5-26 5-26 5-26 5-26
5-26
ELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMSELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMS
ELECTRICAL WIRING DIAGRAMS
(2) W/ EURO III (2) W/ EURO III(2) W/ EURO III (2) W/ EURO III
(2) W/ EURO III
b. b.b. b.
b.
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITIONCONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
IMMOBILIZER
ANTENNA
ECM
2167
5348
OVPR
INJECTOR
a. a.a. a.
a.
CONNECTOR INFORMATION CONNECTOR INFORMATIONCONNECTOR INFORMATION CONNECTOR INFORMATION
CONNECTOR INFORMATION
C114 (GRAY) FUEL PUMP
C206 (BLACK)
C115 (BLACK)
C303 (BLACK)
C102 (4Pin, Colorless)
C104 (8Pin, Colorless)
C114 (6Pin, Gray)
C115 (40Pin, Black)
C206 (6Pin, Black)
C303 (6Pin, Black)
J107
J205
G201
G205
G302CONNECTOR(NUMBER) CONNECTOR(NUMBER)CONNECTOR(NUMBER) CONNECTOR(NUMBER)
CONNECTOR(NUMBER)
CONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESSCONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESS
CONNECTING. WIRING HARNESS
CONNECTOR POSITION CONNECTOR POSITIONCONNECTOR POSITION CONNECTOR POSITION
CONNECTOR POSITION
Engine Room Fuse Box - W/H Main
Engine Room Fuse Box - W/H Main
W/H Engine Control - W/H ECM Main
W/H Engine Control - W/H ECM Main
W/H Main - W/H ECM Main
W/H Main - W/H Fuel Pump
W/H Engine Control
W/H Main
W/H Main
W/H Main
W/H MainEngine Room Fuse Box
Engine Room Fuse Box
Behind Hydraulic Unit
Behind Hydraulic Unit
Lower "A" Piller (Upper ECM)
Upper Transfer Case
Next to Yellow Label
Behind Front Right Kick Panel
Upper Front Left Leg Room
Center "A" Piller Front Right
Below Center Console
Page 1922 of 2053
5-28 5-28 5-28 5-28
5-28
ELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMSELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMS
ELECTRICAL WIRING DIAGRAMS
a. a.a. a.
a.
CONNECTOR INFORMATION CONNECTOR INFORMATIONCONNECTOR INFORMATION CONNECTOR INFORMATION
CONNECTOR INFORMATION
b. b.b. b.
b.
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITIONCONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
3) 3)3) 3)
3)
SENSOR (CAM SHAFT POSITION, AIR FLOW, O SENSOR (CAM SHAFT POSITION, AIR FLOW, OSENSOR (CAM SHAFT POSITION, AIR FLOW, O SENSOR (CAM SHAFT POSITION, AIR FLOW, O
SENSOR (CAM SHAFT POSITION, AIR FLOW, O
2 22 2
2), CAM SHAFT ACTUATOR ), CAM SHAFT ACTUATOR), CAM SHAFT ACTUATOR ), CAM SHAFT ACTUATOR
), CAM SHAFT ACTUATOR
(1) W/O EURO III (1) W/O EURO III(1) W/O EURO III (1) W/O EURO III
(1) W/O EURO III
AIR FLOW
SENSOR
ECM
OVPRCAM SHAFT
POSITION
C114 (GRAY) CAM SHAFT
ACTUATOR
C206 (BLACK)
C115 (BLACK)
O2 SENSOR
C102 (4Pin, Colorless)
C104 (8Pin, Colorless)
C114 (6Pin, Gray)
C115 (40Pin, Black)
C206 (6Pin, Black)
J106
J204
G302CONNECTOR(NUMBER) CONNECTOR(NUMBER)CONNECTOR(NUMBER) CONNECTOR(NUMBER)
CONNECTOR(NUMBER)
CONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESSCONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESS
CONNECTING. WIRING HARNESS
CONNECTOR POSITION CONNECTOR POSITIONCONNECTOR POSITION CONNECTOR POSITION
CONNECTOR POSITION
Engine Room Fuse Box - W/H Main
Engine Room Fuse Box - W/H Main
W/H Engine Control - W/H ECM Main
W/H Engine Control - W/H ECM Main
W/H Main - W/H ECM Main
W/H Engine Control
W/H Main
W/H MainEngine Room Fuse Box
Engine Room Fuse Box
Behind Hydraulic Unit
Behind Hydraulic Unit
Lower "A" Piller (Upper ECM)
Behind Hydrauilc Unit
Upper Blower Unit
Below Center Console