300 SUZUKI SX4 2006 1.G Service Workshop Manual

Downloaded from www.Manualslib.com manuals search engine 7B-44 Air Conditioning System: Automatic Type
Electronic Control System Components LocationS6RW0D7223002
NOTE
The figure shows left-hand steering vehicle. For right-hand steering vehicle, parts with (*) are installed
at the opposite side.

[A]
2
3
5
1
4
78*
18
19
20
23
22 219*
10*
11*
12*
13*
15* 16* 17
14*
8*6
I6RW0C722003-01
[A]: Junction block assembly viewed from relay
side8. Junction block assembly 16. Blower motor controller
1. A/C refrigerant pressure sensor 9. Sunload sensor 17. HVAC control module
2. Compressor relay 10. Inside air temperature sensor 18. Temperature selector
3. Condenser cooling fan relay 11. Air flow control actuator 19. Blower speed selector
4. Outside air temperature sensor 12. Temperature control actuator 20. MODE (air flow) selector
5. ECT sensor 13. Evaporator temperature sensor 21. A/C switch
6. Condenser cooling fan 14. Air intake actuator 22. Air intake selector
7. Blower motor relay 15. Blower motor 23. Rear defogger switch

Downloaded from www.Manualslib.com manuals search engine 8B-11 Air Bag System:
Component Location
Air Bag System Components, Wiring and Connectors LocationS6RW0D8203001
17 147B19
A
20
16
1818
43
1 A
5
C
2 B
10
11
8
9
6
15
C
5
5
13
12
I6RW0C820004-01

Downloaded from www.Manualslib.com manuals search engine 8B-27 Air Bag System:
DTC Troubleshooting
NOTE
Upon completion of inspection and repair work, perform the following items.
• Reconnect all air bag system components and ensure all components are properly mounted.
• Clear DTCs referring to “DTC Clearance”, if any.
• Repeat “Air Bag Diagnostic System Check” to confirm that the trouble has been corrected.

DTC B1017: Power Supply Voltage too LowS6RW0D8204013
Wiring Diagram
Refer to “DTC B1016: Power Supply Voltage too High”.
DTC Detecting Condition and Trouble AreaStep Action Yes No
1Was “Air Bag Diagnostic System Check Flow” performed?Go to Step 2. Go to “Air Bag
Diagnostic System
Check Flow”.
2SDM power supply voltage check
1) With ignition switch turned OFF, disconnect SDM
connector “L04”.
2) Check for proper connection to SDM at “L04-27”
terminal.
3) If OK, run engine with more than 3000 rpm.
4) In this state, check voltage between “L04-27” terminal on
SDM connector and body ground.
Special tool
(A): 09932–76010
Is measured voltage 15 V or less?Go to Step 3. Check charging system
and repair as necessary
referring to “Generator
Test (Overcharged
Battery Check) in
Section 1J”.
3DTC B1016 recheck
1) With ignition switch turned OFF, reconnect SDM
connector.
With ignition switch turned ON, is DTC B1016 still indicated?Substitute a known-
good SDM and recheck.Intermittent trouble.
Check for intermittent
trouble referring to
“Inspection of
Intermittent and Poor
Connections” If OK,
substitute a known-
good SDM and recheck.
“L04-27”
(A)
I7RW01822016-01
DTC detecting condition Trouble area
Power supply voltage is less than 7.2 V for more than 16
sec.• Charging system
•SDM

Downloaded from www.Manualslib.com manuals search engine 9A-143 Wiring Systems:
List of Connector
List of ConnectorsS6RW0D910F001
Refer to “C Connector”.
Refer to “E Connector”.
Refer to “G Connector”.
Refer to “J Connector”.
Refer to “K Connector”.
Refer to “L Connector”.
Refer to “O Connector”.
Refer to “Q Connector (8ch)”.
Refer to “R Connector”.
Refer to “S Connector”.
C ConnectorS6RW0D910F002
C01 C06
A/T
C07 C31 C31 C32 C32
A/TM15A engine,
M16A engineJ20A engine With OCV Without OCV
C32 C34 C36 C37 C39 C40
J20A engine A/TM15A engine,
M16A engineM15A engine
C40 C42 C42 C43 C44 C45
J20A engine M15A engineM16A engine,
J20A engineM16A engine A/T J20A engine A/T
C46 C47 C47 C48 C64
M15A engine,
J20A engineM15A engine,
M16A engineJ20A engine J20A engine
12 3456
20 21 16 17 18 1978910
22 23 24 2512
27 2613
28
31 32 33 34 35 36
50 51 46 47 48 4937 38 39 40
52 53 54 5511
41
5642
5743
5814 15
29 30
44
60 45
59
MCONF600002-01
17181920
7
1256
89101113141516
21222324
12
34
MCONF240020-01
181920 21
712345 68910
22232425
13141516
26
171112
MCONF260020-01
123
MCONF030103-02
123
MCONF030038-01
123
MCONF030123-01
123
MCONF030103-02
123
MCONF030053-01
123
MCONF030103-02
123
MCONF030030-01
1
MCONF010054-01
12MCONF020042-01
1
2
3
4
MCONF040102-02
1
2
3
4
MCONF040024-01
1
2
3
4
MCONF040024-01
1
2
3
4
MCONF040102-02
1
2
3
4
MCONF040024-01
1
2
MCONF020150-01
1
2
MCONF020150-01
123
MCONF030040-01
14325
MCONF050025-01
12345
MCONF050050-01
1234 56
MCONF060068-01
1
2
MCONF020150-01

Downloaded from www.Manualslib.com manuals search engine Wiring Systems: 9A-144
C91 C92 C93 C94 C101 C101
M15A engine,
M16A engineJ20A engine
C102 C102 C103 C104 C122 C123
M15A engine,
M16A engineJ20A engine J20A engine J20A engine IF EQPDM15A engine,
M16A engine
C123 C124 C139 C139 C141 C162
J20A engine IF EQPDM15A engine A/T,
M16A engine A/TJ20A engine A/T
C163 C165 C166 C166 C192 C194
J20A engine M/TM15A engine A/T,
M16A engine A/TJ20A engine A/T
C195 C196 C282 C283 C311 C312
M15A engine,
M16A engine
C313 C343 (TO E371)
M16A engine
12
MCONF020266-01
12
MCONF020266-01
12
MCONF020266-01
12
MCONF020266-01
123
MCONF030055-01
123
MCONF030103-02
123
MCONF030055-01
123
MCONF030103-02
123
MCONF030103-02
123
MCONF030103-02
123
456
MCONF060018-01
12MCONF020042-01
1
2
MCONF020150-01
2
1
MCONM020033-01
1
2
65
10 74
93
8
MCONF100049-01
1
2
54
8 63
7
MCONF080028-02
1
MCONF010076-01
1
MCONF010030-01
1
MCONF010001-01
12
MCONF020176-0169
12345
78
MCONF090011-01
546
213
879
1110MCONF110011-02
1
MCONF010057-03
21
43
MCONF040127-01
1MCONF010021-01
1
MCONF010057-03
1
MCONF010078-01
1
MCONF010074-01
24
9
131415
1
101112
56378
MCONF150008-01
24
9
131415
1
101112
56378
MCONF150008-01
24
9
131415
1
101112
56378
MCONF150008-01
21
8
3
9765
131211
1819
4
10
14
20171615MCONF200011-01

Downloaded from www.Manualslib.com manuals search engine 9A-145 Wiring Systems:
E ConnectorS6RW0D910F003
E01 E04
Except Taiwan
E08 E11 E12
E13 E31 E33 E35 E36 E37
E40 E61 E62 E63 E64 E65
M16A engine
E65 E68 E69 E70 E151 E152
J20A engine IF EQPD IF EQPD
E159 E160 E161 E162 E163 E164
E165 E166 E181 E183 E191
E192 E221 E222 E223 E224 E225
J20A engine J20A engine J20A engine
12 3456
20 21 16 17 18 1978910
22 23 24 2512
27 2613
28
31 32 33 34 35 36
50 51 46 47 48 4937 38 39 40
52 53 54 5511
41
5642
5743
5814 15
29 30
44
60 45
59
MCONF600002-01
12567
8
9 1011121314
34
MCONF140012-01
210
13242521
1345678911
1214152326161718192022
MCONF260018-01
123456789
11 12 13 14 15 16 17 18 1910
20
MCONF200029-01
1
2
MCONF020204-01
1
2
MCONF020185-01
3 2 1
6 5 4
MCONF060052-01
2
1
MCONM020033-01
2
1
MCONM020033-01
123
MCONF030062-01
1
2
MCONF020200-01
12
MCONF020199-01
12
MCONF020205-01
1
2
MCONF020008-01
1
2
MCONF020008-01
12
54
3
MCONF050027-01
21
MCONF020183-01
21
43
MCONF040130-01
3
12
MCONF030128-01
3
12
MCONF030128-01
21
MCONF020183-01
12
3
MCONF030101-01
12
3
MCONF030101-01
1
2
MCONF020289-01
1
2
MCONF020289-01
1
2
MCONF020013-01
1
2
MCONF020013-01
2 1
MCONF020162-01
2 1
MCONF020162-01
2 1
MCONF020196-01
2 1
MCONF020196-01
1
34
2
MCONF040045-012 1
MCONF020115-01
1234 56
MCONF060068-01
2 1
MCONF020151-01
21
4
3
MCONF040131-01
312
5
4
MCONF050044-01
312
5
4
MCONF050044-01
312
5
4
MCONF050044-01
21
4
3
MCONF040131-01

Downloaded from www.Manualslib.com manuals search engine 9A-147 Wiring Systems:
G17 G20
Auto A/C
G26 G32 G34 G35
IF EQPD Auto A/C Auto A/C
G61 G62 G63 G64 G65 G65
Auto A/C Auto A/C Auto A/C Manual A/C
G141 G144 G146 G147
G150 G151 G152 G153 G154
IF EQPD IF EQPD Manual A/C
G155 G211 G214
Manual A/C IF EQPD
G241 G248
IF EQPD
G251 G253 G254 G255 G259
IF EQPD Auto A/C
G265 G266 G267 G267 G271
Taiwan IF EQPD With NavigationWithout
Navigation
2 1
83
94
105
116
12 7
MCONF120051-01
14567
15 16 1718192021
89101114
2425262730 13
29 12
2822 23
23
MCONF300004-01
13141516171819
456789
20212223242526
121110123
MCONF260010-01
123MCONF030078-01
2 1
MCONF020111-01
2 1
MCONF020111-01
1
2
MCONF020008-01
456 3 12
MCONF060093-01
456 3 12
MCONF060093-01
456 3 12
MCONF060093-01
12
34
MCONF040009-01
2 143
MCONF040142-01
12345678910MCONF100038-01710
56 12 34
8 9 11 12 13
MCONF130010-01
4
1
8
3
567
2
MCONF080050-01
3
2 1
6 5 4
MCONF060063-01
12
3
8 4675
MCONF080002-01
12
3
8 4675
MCONF080002-01
12
3456
MCONF060025-01
1234
MCONF040098-01
123
78910
456
11121314
MCONF140018-01
3
7 6 5 42 1
MCONF070016-01
1234567 8
9 10111213141516
MCONF160023-01
5 4 3 21
10 9 8 76
MCONF100060-01
1
172
183
194
205
216
227
238
249
2510
2611
2712
2813
2914
3015
3116
32
MCONF320015-01
12345MCONF050021-01
12345678910
11 12 13 14 15 16 17 18 19 20
MCONF200012-01
2
1
MCONF020304-01
1234567
MCONF070004-01
1234
MCONF040096-01
1
2
()MCONF020147-01
12
MCONF020235-01
1MCONF010010-01
4 3 12MCONF040146-0112MCONF020305-011
MCONM010040-01
12345
78 116
12 910
MCONF120028-01

Downloaded from www.Manualslib.com manuals search engine Wiring Systems: 9A-148
G272 G273 G306
G307 G308 G309
IF EQPD
G310 G311 G333 (TO E381)
Auto A/C
G334 (TO E382) G335 (TO E383) G341 (TO L374)
IF EQPD
G342 (TO L375) G343 (TO L376) G344 (TO L377) G345 (TO L378) G346 (TO S171)
IF EQPDWith auto cruise
G346 (TO S171) G347 (TO S172) G347 (TO S172) G348 (TO K153) G349 (TO L399)
Without auto cruise With auto cruiseWithout auto
cruise
G352 (TO L402) G354 (TO K154) G355 (TO L409)
IF EQPD IF EQPD
10
11 12 13 14 15 16 17 18 19123456789
20
MCONF200020-01
6 5 4 32 1
MCONF060064-01
AA A A A
BBBB
BB
CCC C CD DD D DD
()
MCONF220018-01
AAB CC
AAB CB B BC
( )
MCONF130019-01
AAB CC
AAB CB B BC
( )
MCONF130019-01
AAA BB
AAA BB B BB
( )
MCONF130021-01
AB
AABBB
MCONF070023-01
AAA BB
AAA BB B BB
( )
MCONF130021-01
123456789
101112131415161718
MCONF180012-01
3
256
1012
9
81341
14151617181920
11 7
MCONF200008-01
5 4 3 21
10 9 8 76
MCONF100060-01
7
654 3
21
14 13 12 11 10 9 8
MCONM140005-02
54 32 167910
20 19 18 17 16 15 14 13 12 118
MCONM200008-01
34
7
2
68910
121314
1716
1
5
11
15181920
MCONM200005-01
21
MCONM020065-01
21
MCONM020065-01
123456
789101112
MCONF120052-01
654321
MCONF060080-01
4 3 2 1
MCONF040099-01
12
MCONF020212-011
MCONM010017-01
2 1
MCONF020151-01
7
654 3
21
14 13 12 11 10 9 8
MCONM140005-02
1MCONF010046-011 2 43
MCONM040035-01

Downloaded from www.Manualslib.com manuals search engine 9A-149 Wiring Systems:
J ConnectorS6RW0D910F005
K ConnectorS6RW0D910F006
J21 J21 J22 J25 J26 J27
Type A Type B
J28 J31 J32 J35 J36
J81 J82 J83 J84 J85
IF EQPD
J86 J87 J141 J142 J145
IF EQPD
J146 J147 J148 J151 J152 J153
IF EQPD IF EQPD IF EQPD IF EQPD IF EQPD
J154 J215 (L379) J216 (L380) J217 (TO L381) J218 (TO L382)
IF EQPD
K51 K52 K121 K152 (TO L383) K153 (TO G348) K154 (TO G354)
1
2
MCONF020236-01
1
23
456
MCONF060087-01
1
2
MCONF020236-01
1
2
MCONF020236-01
1
2
MCONF020236-016 21
7543
MCONM070004-01
6 21
7543
MCONM070004-01
1234
5678910
MCONF100054-01
1234
5678910
MCONF100054-01
1234
5678910
MCONF100054-01
1234
5678910
MCONF100054-01
12
91011
34
12 13 14 15
5678
16 17 18
MCONF180006-01
12345MCONF050001-0112345MCONF050001-0112345MCONF050001-012
1
MCONM020016-01
2
1
MCONM020016-01
135
68910111324
712
MCONF130011-01
1
2
MCONF020008-01
1
2
MCONF020008-01
1
2
MCONF020008-01
1
2
MCONF020008-01
2 1
MCONF020159-01
2 1
MCONF020159-01
2 1
MCONF020159-01
2 1
MCONF020159-01
1 2
MCONM020018-01
1 2
MCONM020018-01
26
25
24
2334
2233
21
31
14
13
126
115
10
7
8
2
91
4
330
32
2029
1928
18
17
16
15
27
MCONM340003-02
26
25
24
2334
2233
21
31
14
13
126
115
10
7
8
2
91
4
330
32
2029
1928
18
17
16
15
27
MCONM340003-02
5 4 3 21
10 9 8 76
MCONF100060-01
5 4 3 21
10 9 8 76
MCONF100060-01
123
MCONF030134-01
2 1
MCONF020157-012 1
MCONM020068-01
321
MCONM030021-01
1MCONF010010-01
1
MCONM010040-01

Downloaded from www.Manualslib.com manuals search engine Wiring Systems: 9A-150
L ConnectorS6RW0D910F007
L01 L04
Except Taiwan
L31 L32 L33 L35 L36 L37
IF EQPD 8ch 8ch IF EQPD
L40 L101 L102 L132 L133 L134
IF EQPD IF EQPD
L161 L162 L163 L164 L167 L170
L171 L172 L174 L281 L282 L283
IF EQPD IF EQPD IF EQPD IF EQPD IF EQPD
L285 L292 L293 L294 L296 L301
IF EQPD IF EQPD IF EQPD
L307 L308 L312 L313 L314
IF EQPD IF EQPD
L315 L346 L347
123456789
101112131415161718
MCONF180012-01
234567891011171819202122232425261213141516
1
27282930313233343536424344454647484950513738394041
MCONF510001-01
21
MCONM020066-01
21
MCONM020066-01
123
MCONF030123-01
12
MCONF020210-01
12
MCONF020210-01
3
21
MCONM030023-01
12MCONF020042-01
1
23
456
MCONF060044-01
2
1
MCONM020058-01
12
MCONF020211-01
1
23
456
MCONF060044-01
1
23
456
MCONF060044-01
1
MCONF010100-01
1
MCONF010100-01
1
MCONF010100-01
1
MCONF010100-01
1MCONF010021-01
12
MCONF020268-01
12
3456
MCONF060025-01
12
3456
MCONF060025-01
12
3456
MCONF060025-014 3
2 1
MCONF040132-01
4 3
2 1
MCONF040132-01
12
MCONF020209-01
12
MCONF020209-01
12
MCONF020266-01
2 1
MCONF020228-01
2 1
MCONF020228-012
1
MCONF020304-01
1
2
()MCONF020147-01
1MCONF010021-011MCONF010021-01
12
3456
MCONF060078-01
2341
MCONF040033-01
123456789
15 16 17 18 11 10 12 13 14
MCONF180013-01
4 356
1214
11
1015
721
1316
9 8
MCONF160014-01
AABBCC
DDEEFF
( )
MCONF120055-01
AABBCC
DDEEFF
( )
MCONF120055-01