fuel TATA SAFARI 2015 Owner's Manual
[x] Cancel search | Manufacturer: TATA, Model Year: 2015, Model line: SAFARI, Model: TATA SAFARI 2015Pages: 161, PDF Size: 2.55 MB
Page 84 of 161
84
D R I V I N GFUEL ECONOMY FUEL ECONOMYFUEL ECONOMY FUEL ECONOMY
FUEL ECONOMY
NOTICE NOTICENOTICE NOTICE
NOTICE
Do not engage four wheel drive mode (4H or 4L)
continuously on dry and hard road surface. It can cause
expensive damage to the vehicle transmission and the
tyres.
Four wheel drive facility is a powerful tool which enables
the vehicle to traverse terrain which is otherwise
inaccessible to two wheel drive vehicles. However, it must
be used judiciously and carefully. Do not take unnecessary
risks and attempt the impossible. Familiarise yourself
thoroughly with the vehicle and its abilities before
attempting serious off road driving.
With ignition ‘ON’ 4H & 4L indicator lamp on panel should
glow for a few seconds only & then go off. Continuous
illumination of 4L & 4H lamps indicates electrical fault.
F FF F
F
uel E uel Euel E uel E
uel E
c cc c
c
onom onomonom onom
onom
y yy y
y
A. A.A. A.
A . Drive smoothly, accelerate gradually and anticipate stops.
B. B.B. B.
B . Best fuel consumption is achieved at low engine speeds, the
highest possible gear without labouring the engine.
C. C.C. C.
C . Driving with accelerator pedal fully depressed means using
excessive fuel.
D DD D
D
.. ..
. Do not allow engine to labour. Change to lower gear when
engine no longer runs smoothly.
E. E.E. E.
E . If possible, do not idle the engine for more than 2 minutes.
Switch off the engine.
F FF F
F
.. ..
. Do not ride the clutch OR brake pedal while driving. Do not
use clutch pedal as foot rest.
G* G*G* G*
G*.When changing from 4H/4L to 2H of transfer case, 2H free
wheeling should be done.
If 2H free wheeling is not done the hub locks of front hub
remain locked causing unnecessary rotation of front drive
components and this consumes more fuel and causes wear
and tear of front axle components.
H. H.H. H.
H . Depending on traffic conditions, a constant speed should
be maintained.
The vehicle uses more fuel, every time you speed up or slow
down.
I. I.I. I.
I . Hard braking, abrupt cornering and rapid acceleration use
more fuel. Avoid these.
J. J.J. J.
J . Do not carry unnecessary weight in the vehicle.
K. K.K. K.
K . Maintain moderate speed limits, while driving.
L. L.L. L.
L . Always ensure that front wheel alignment is proper.
(*F (*F(*F (*F
(*F
or 4 or 4 or 4 or 4
or 4
WD mo WD moWD mo WD mo
WD mo
del only del onlydel only del only
del only
.) .).) .)
.)
ProCarManuals.com
Page 91 of 161
91
FUEL, LUBRICANTS & COOLANTS
• •• •
•Fuel FuelFuel Fuel
Fuel
• •• •
•Lubricants LubricantsLubricants Lubricants
Lubricants
• •• •
•Coolants CoolantsCoolants Coolants
Coolants
• •• •
•Recommended oils & lubricants Recommended oils & lubricantsRecommended oils & lubricants Recommended oils & lubricants
Recommended oils & lubricants
This section give information regarding recommendations of fuel &
oils to be used on TATA Safari Vehicles. Use only these fuel & oils on
your vehicle to avoid damage to vital systems & components.
ProCarManuals.com
Page 92 of 161
92
FUEL, LUBRICANTS & COOLANTSFUEL FUELFUEL FUEL
FUEL
Fuel FuelFuel Fuel
Fuel
High speed diesel conforming to IS 1460 or EN 590 or equivalent
is recommended to be used as fuel.
At very low temperatures fluidity of diesel may become
insufficient due to paraffin separation. It is therefore, necessary
to mix supplementary fuel with summer or winter grade diesel.
The supplementary fuel to be used is kerosene or aviation
turbine fuel.
Ratios for mixing of supplementary fuel and diesel are shown
in table:
A AA A
A
mbien mbienmbien mbien
mbien
t tt t
t
P PP P
P
er erer er
er
c cc c
c
en enen en
en
tage tagetage tage
tage
temperature upto temperature uptotemperature upto temperature upto
temperature upto
Summer SummerSummer Summer
Summer
Suppl. Suppl.Suppl. Suppl.
Suppl.
Deg C. Deg C.Deg C. Deg C.
Deg C.
Grade diesel Grade dieselGrade diesel Grade diesel
Grade diesel
fuel fuelfuel fuel
fuel
upto 0 100 0
0 to -10 70 30
-10 to -15 50 50Ambient AmbientAmbient Ambient
Ambient
Percentage PercentagePercentage Percentage
Percentage
temperature upto temperature uptotemperature upto temperature upto
temperature upto
Winter WinterWinter Winter
Winter
Suppl. Suppl.Suppl. Suppl.
Suppl.
Deg C. Deg C.Deg C. Deg C.
Deg C.
Grade diesel Grade dieselGrade diesel Grade diesel
Grade diesel
fuel fuelfuel fuel
fuel
upto -15 100 0
-15 to -20 70 30
-20 and below 50 50
Care should be taken that diesel and supplementary fuel are
thoroughly mixed before filling.
Recommended Fuel Specification for engines to be added.
Parameter ParameterParameter Parameter
Parameter
Unit UnitUnit Unit
Unit
BS III BS III BS III BS III
BS III
1 Cetane Number (min) CN 51
2 Sulphur contentmg/kg 350
3 Lubricity (HFRR) micon 460
ProCarManuals.com
Page 93 of 161
93
FUEL, LUBRICANTS & COOLANTS
Lubricants and Oils Lubricants and OilsLubricants and Oils Lubricants and Oils
Lubricants and Oils
Recommended lubricants conform to the following
specifications :
1. 1.1. 1.
1.
Engine oil Engine oilEngine oil Engine oil
Engine oil -API-CH4 + MB 228.3 or higher
grade engine oil
2. 2.2. 2.
2.
Gear Box oil Gear Box oilGear Box oil Gear Box oil
Gear Box oil - 75W90 GL-4
3. 3.3. 3.
3.
Power Steering Power SteeringPower Steering Power Steering
Power Steering - ATF Type A, Suffix A
and and and and
and
T TT T
T
r rr r
r
ansf ansfansf ansf
ansf
er C er Cer C er C
er C
ase asease ase
ase
4. 4.4. 4.
4.
Rear & Front axle Rear & Front axleRear & Front axle Rear & Front axle
Rear & Front axle -M/Grade oil SAE 85W 140 GL5
Angolmol AG043 oil
* * * *
* Friction modifier 40819 (2-5%) to be added to oil for
Limited Slip Differential
5. 5.5. 5.
5.
Chassis and wheel Chassis and wheelChassis and wheel Chassis and wheel
Chassis and wheel -SS6805 bearing grease
bearing
bearingbearing bearing
bearing
Please use only recommended grades for good Please use only recommended grades for goodPlease use only recommended grades for good Please use only recommended grades for good
Please use only recommended grades for good
performance. performance.performance. performance.
performance.
DO NOT DO NOT DO NOT DO NOT
DO NOT mix grease of different brands and optional grades.
Replace old grease completely.
The oil change periods recommended in maintenance
schedule should be adhered to.
L LL L
L
UBRIC UBRICUBRIC UBRIC
UBRIC
ANT ANTANT ANT
ANT
S SS S
S
Engine EngineEngine Engine
Engine
Qty : 7.5 Litres Qty : 7.5 Litres Qty : 7.5 Litres Qty : 7.5 Litres
Qty : 7.5 Litres
Recommended grades of engine oil for range of ambient
temperature :
A AA A
A
mbien mbienmbien mbien
mbien
t t t t
t
T TT T
T
emp empemp emp
emp
er erer er
er
a aa a
a
tur turtur tur
tur
e e e e
e
0 00 0
0C CC C
C
Engine Oil Grade Engine Oil GradeEngine Oil Grade Engine Oil Grade
Engine Oil Grade
- 5 and above SAE 15W/40
- 10 to 0 SAE 5W30
- 20 and -10 SAE 0W30
Front live axle and rear axle oil (Spicer axles) Front live axle and rear axle oil (Spicer axles)Front live axle and rear axle oil (Spicer axles) Front live axle and rear axle oil (Spicer axles)
Front live axle and rear axle oil (Spicer axles)
Use Multigrade oil SAE 85W 140 Angolmol A6043 oil
Capacity : Capacity :Capacity : Capacity :
Capacity :
For Rear axle For Rear axleFor Rear axle For Rear axle
For Rear axle
- 2.2 litres - 2.2 litres- 2.2 litres - 2.2 litres
- 2.2 litres
For Front axle For Front axleFor Front axle For Front axle
For Front axle
- 1.2 litres - 1.2 litres- 1.2 litres - 1.2 litres
- 1.2 litres
Gear Box oil : Gear Box oil :Gear Box oil : Gear Box oil :
Gear Box oil :
Qty : 1.6 Litres Qty : 1.6 LitresQty : 1.6 Litres Qty : 1.6 Litres
Qty : 1.6 Litres
75W90, (Synthetic oil GL4)
ProCarManuals.com
Page 94 of 161
94
T TT T
T
r rr r
r
ansf ansfansf ansf
ansf
er c er cer c er c
er c
ase oil : ase oil :ase oil : ase oil :
ase oil :
Qty : 1.2 Litres Qty : 1.2 LitresQty : 1.2 Litres Qty : 1.2 Litres
Qty : 1.2 Litres
Recommended lubricants should confirm to General
Motors, ATF A specification
Hub bearing grease Hub bearing greaseHub bearing grease Hub bearing grease
Hub bearing grease
Use lithium base multipurpose grease -
Quantity : Quantity :Quantity : Quantity :
Quantity :
92 gms p 92 gms p92 gms p 92 gms p
92 gms p
er hub er huber hub er hub
er hub
.. ..
.
(F (F (F (F
(F
r rr r
r
on onon on
on
t axles 4X4) t axles 4X4)t axles 4X4) t axles 4X4)
t axles 4X4)
47 gms p 47 gms p47 gms p 47 gms p
47 gms p
er hub er huber hub er hub
er hub
.. ..
.
(F (F (F (F
(F
r rr r
r
on on
on on
on
t axles 4X2) t axles 4X2)t axles 4X2) t axles 4X2)
t axles 4X2)
25 gms p 25 gms p25 gms p 25 gms p
25 gms p
er hub er huber hub er hub
er hub
.. ..
.
(R (R (R (R
(R
ear) ear)ear) ear)
ear)
Brake and Clutch Fluid Brake and Clutch FluidBrake and Clutch Fluid Brake and Clutch Fluid
Brake and Clutch Fluid
Brake fluid confirming to SAE J 1703, DOT 3 is recommended.
Spicer propeller shaft Spicer propeller shaftSpicer propeller shaft Spicer propeller shaft
Spicer propeller shaft
Lubricant slip joint with NLGI-2 grade grease.
FUEL, LUBRICANTS & COOLANTSLUBRICANTS & COOLANTS LUBRICANTS & COOLANTSLUBRICANTS & COOLANTS LUBRICANTS & COOLANTS
LUBRICANTS & COOLANTS
Coolants CoolantsCoolants Coolants
Coolants
Qty : Approx. 9-10 Litres Qty : Approx. 9-10 LitresQty : Approx. 9-10 Litres Qty : Approx. 9-10 Litres
Qty : Approx. 9-10 Litres
Presence of dirt in coolant chokes up passages in radiator,
cylinder head and crankcase, thereby causing overheating of
engine.
To prevent rust formation and freezing of coolant inside the
passages of radiator, crankcase and cylinder head use premixed
coolant as recommended.
It is recommended that the entire cooling system should
be drained and filled with fresh premixed coolant.
Engine coolant antifreeze coolant as per class II, JIS K2234
Windscreen Washer Antifrost
Make -Antifrost- K
Concentration - 1 : 5 For 0
0C
1 : 1 For 100C
2 : 5 For 160C
1 : 0 For 370C
ProCarManuals.com
Page 95 of 161
95
FUEL, LUBRICANTS & COOLANTSBRANDED LUBRICANTS, COOLANTS & ADHESIVES BRANDED LUBRICANTS, COOLANTS & ADHESIVESBRANDED LUBRICANTS, COOLANTS & ADHESIVES BRANDED LUBRICANTS, COOLANTS & ADHESIVES
BRANDED LUBRICANTS, COOLANTS & ADHESIVES
PLEASE USE ONL PLEASE USE ONLPLEASE USE ONL PLEASE USE ONL
PLEASE USE ONL
Y FOLL Y FOLLY FOLL Y FOLL
Y FOLL
O OO O
O
WING GENUINE OILS, WING GENUINE OILS,WING GENUINE OILS, WING GENUINE OILS,
WING GENUINE OILS,
C CC C
C
OOL OOLOOL OOL
OOL
ANT ANTANT ANT
ANT
S , S ,S , S ,
S ,
L L L L
L
UBRIC UBRICUBRIC UBRIC
UBRIC
ANT ANTANT ANT
ANT
S , S ,S , S ,
S ,
ANTI R ANTI R ANTI R ANTI R
ANTI R
UST & SOUND DEADENING UST & SOUND DEADENINGUST & SOUND DEADENING UST & SOUND DEADENING
UST & SOUND DEADENING
C CC C
C
O OO O
O
A AA A
A
T TT T
T
S, S,S, S,
S,
WINDSCREEN SEAL WINDSCREEN SEALWINDSCREEN SEAL WINDSCREEN SEAL
WINDSCREEN SEAL
ANT ANTANT ANT
ANT
,, ,,
,
ADHESIVES & FUEL ADDITIVES BR ADHESIVES & FUEL ADDITIVES BR ADHESIVES & FUEL ADDITIVES BR ADHESIVES & FUEL ADDITIVES BR
ADHESIVES & FUEL ADDITIVES BR
ANDED BY ANDED BY ANDED BY ANDED BY
ANDED BY
T TT T
T
A AA A
A
T TT T
T
A MO A MOA MO A MO
A MO
T TT T
T
ORS F ORS FORS F ORS F
ORS F
OR OPTIMUM OR OPTIMUMOR OPTIMUM OR OPTIMUM
OR OPTIMUM
PERFORMANCE OF PERFORMANCE OF PERFORMANCE OF PERFORMANCE OF
PERFORMANCE OF
Y YY Y
Y
OUR OUR OUR OUR
OUR
T TT T
T
A AA A
A
T TT T
T
A Saf A SafA Saf A Saf
A Saf
ari DICOR ari DICORari DICOR ari DICOR
ari DICOR
... ......
...
...
ITEM COMPANY BRAND QTY
ENGINE OIL ENGINE OILENGINE OIL ENGINE OIL
ENGINE OIL
CASTROL CASTROLCASTROL CASTROL
CASTROL
Castrol GTX (Diesel) Castrol GTX (Diesel)Castrol GTX (Diesel) Castrol GTX (Diesel)
Castrol GTX (Diesel)
HPCL HPCLHPCL HPCL
HPCL
HP MIL HP MILHP MIL HP MIL
HP MIL
CY CY CY CY
CY
TURBO PL TURBO PLTURBO PL TURBO PL
TURBO PL
US USUS US
US
7.5 Litres 7.5 Litres7.5 Litres 7.5 Litres
7.5 Litres
COOLANT COOLANTCOOLANT COOLANT
COOLANT
SUNST SUNSTSUNST SUNST
SUNST
AR ARAR AR
AR
Golden Cruiser Premium 1400 M Golden Cruiser Premium 1400 MGolden Cruiser Premium 1400 M Golden Cruiser Premium 1400 M
Golden Cruiser Premium 1400 M
HPCL HPCLHPCL HPCL
HPCL
HP HP HP HP
HP
T TT T
T
handa R handa Rhanda R handa R
handa R
aja P aja Paja P aja P
aja P
Approx 13 Litres Approx 13 LitresApprox 13 Litres Approx 13 Litres
Approx 13 Litres
CASTROL CASTROLCASTROL CASTROL
CASTROL
Radicool
RadicoolRadicool Radicool
Radicool
GEAR BOX (G-76) GEAR BOX (G-76)GEAR BOX (G-76) GEAR BOX (G-76)
GEAR BOX (G-76)
HPCL HPCLHPCL HPCL
HPCL
HP Gear Oil XP 75W90 HP Gear Oil XP 75W90HP Gear Oil XP 75W90 HP Gear Oil XP 75W90
HP Gear Oil XP 75W90
CASTROL CASTROLCASTROL CASTROL
CASTROL
Castrol Syntro 75W90 GL4 Castrol Syntro 75W90 GL4Castrol Syntro 75W90 GL4 Castrol Syntro 75W90 GL4
Castrol Syntro 75W90 GL4
1.6 Litres 1.6 Litres1.6 Litres 1.6 Litres
1.6 Litres
TRANSFERCASE TRANSFERCASETRANSFERCASE TRANSFERCASE
TRANSFERCASE
HPCL HPCLHPCL HPCL
HPCL
HP-A HP-AHP-A HP-A
HP-A
ut utut ut
ut
oma omaoma oma
oma
tic tic tic tic
tic
T TT T
T
r rr r
r
ansmission F ansmission Fansmission F ansmission F
ansmission F
luid luid luid luid
luid
T TT T
T
yp ypyp yp
yp
e A e Ae A e A
e A
1.2 Litres 1.2 Litres
1.2 Litres 1.2 Litres
1.2 Litres
CASTROL CASTROLCASTROL CASTROL
CASTROL
C CC C
C
astr astrastr astr
astr
ol ol ol ol
ol
T TT T
T
r rr r
r
ansp anspansp ansp
ansp
o oo o
o
w ww w
w
er er er er
er
T TT T
T
Q QQ Q
Q
POWER STEERING OIL POWER STEERING OILPOWER STEERING OIL POWER STEERING OIL
POWER STEERING OIL
HPCL HPCLHPCL HPCL
HPCL
HP-A HP-AHP-A HP-A
HP-A
TF D TF DTF D TF D
TF D
e ee e
e
x II x IIx II x II
x II
1.4 Litres 1.4 Litres1.4 Litres 1.4 Litres
1.4 Litres
CASTROL CASTROLCASTROL
CASTROL
CASTROL
C CC C
C
astr astrastr astr
astr
ol ol ol ol
ol
T TT T
T
QD QDQD QD
QD
REAR AXLE, LIVE FRONT AXLE, REAR AXLE, LIVE FRONT AXLE,REAR AXLE, LIVE FRONT AXLE, REAR AXLE, LIVE FRONT AXLE,
REAR AXLE, LIVE FRONT AXLE,
HPCL HPCLHPCL HPCL
HPCL
HP AXLE OIL 85W140 HP AXLE OIL 85W140HP AXLE OIL 85W140 HP AXLE OIL 85W140
HP AXLE OIL 85W140
2.2 2.2 2.2 2.2
2.2
(Rear) (Rear)(Rear) (Rear)
(Rear) 1.2 1.2 1.2 1.2
1.2(Front (Front(Front (Front
(Front) )) )
)
CASTROL CASTROLCASTROL CASTROL
CASTROL
Castrol Long Drain 85W140 Castrol Long Drain 85W140Castrol Long Drain 85W140 Castrol Long Drain 85W140
Castrol Long Drain 85W140
BR BRBR BR
BR
AKE / CL AKE / CLAKE / CL AKE / CL
AKE / CL
UT UTUT UT
UT
CH FL CH FLCH FL CH FL
CH FL
UID UIDUID UID
UID
HP CL HP CLHP CL HP CL
HP CL
Super Duty Brake Fluid DOT - 3 Super Duty Brake Fluid DOT - 3Super Duty Brake Fluid DOT - 3 Super Duty Brake Fluid DOT - 3
Super Duty Brake Fluid DOT - 3
As required As requiredAs required As required
As required
CASTROL CASTROLCASTROL CASTROL
CASTROL
Universal Brake Fluid DOT 3 Universal Brake Fluid DOT 3Universal Brake Fluid DOT 3 Universal Brake Fluid DOT 3
Universal Brake Fluid DOT 3
WHEEL BEARING & CHASSIS WHEEL BEARING & CHASSISWHEEL BEARING & CHASSIS WHEEL BEARING & CHASSIS
WHEEL BEARING & CHASSIS
HPCL HPCLHPCL HPCL
HPCL
HP Multipurpose Grease-2 HP Multipurpose Grease-2HP Multipurpose Grease-2 HP Multipurpose Grease-2
HP Multipurpose Grease-2
As required As requiredAs required As required
As required
CASTROL CASTROLCASTROL CASTROL
CASTROL
Castrol AP2 Castrol AP2Castrol AP2 Castrol AP2
Castrol AP2
ANTI R ANTI R ANTI R ANTI R
ANTI R
UST
UST UST UST
UST
TREA TREATREA TREA
TREA
T TT T
T
MENT MENTMENT MENT
MENT
DINITROL DINITROLDINITROL DINITROL
DINITROL
Dinitrol DinitrolDinitrol Dinitrol
Dinitrol
— —— —
—
& SOUND DEADENING & SOUND DEADENING & SOUND DEADENING & SOUND DEADENING
& SOUND DEADENING
WUERTH WUERTHWUERTH WUERTH
WUERTH
Wuerth WuerthWuerth Wuerth
Wuerth
3M 3M3M 3M
3M
3M 3M3M 3M
3M
— —— —
—
WIND SCREEN SEAL WIND SCREEN SEALWIND SCREEN SEAL WIND SCREEN SEAL
WIND SCREEN SEAL
ANT ANTANT ANT
ANT
WUERTH WUERTHWUERTH WUERTH
WUERTH
Wuerth WuerthWuerth Wuerth
Wuerth
— —— —
—
3M 3M3M 3M
3M
3M 3M3M 3M
3M
— —— —
—
Car System Car SystemCar System Car System
Car System
Car System Car SystemCar System Car System
Car System— —— —
—
ProCarManuals.com
Page 97 of 161
97
VEHICLE SPECIFICATIONS
• •• •
•Engine EngineEngine Engine
Engine
• •• •
•Clutch ClutchClutch Clutch
Clutch
• •• •
•Gear box Gear boxGear box Gear box
Gear box
• •• •
•T TT T
T
r rr r
r
ansf ansfansf ansf
ansf
er c er cer c er c
er c
ase asease ase
ase
• •• •
•Rear axle Rear axleRear axle Rear axle
Rear axle
• •• •
•Front axle Front axleFront axle Front axle
Front axle
• •• •
•Steering SteeringSteering Steering
Steering
• •• •
•Brakes BrakesBrakes Brakes
Brakes
• •• •
•Frame FrameFrame Frame
Frame
• •• •
•Suspension SuspensionSuspension Suspension
Suspension
• •• •
•W WW W
W
heels & heels & heels & heels &
heels &
T TT T
T
yr yryr yr
yr
es eses es
es
• •• •
•Fuel tank Fuel tankFuel tank Fuel tank
Fuel tank
• •• •
•Body BodyBody Body
Body
• •• •
•Electrical system Electrical systemElectrical system Electrical system
Electrical system
• •• •
•Performance PerformancePerformance Performance
Performance
• •• •
•Dimensions DimensionsDimensions Dimensions
Dimensions
• •• •
•Passenger capacity Passenger capacityPassenger capacity Passenger capacity
Passenger capacity
• •• •
•Luggage space Luggage spaceLuggage space Luggage space
Luggage space
• •• •
•W WW W
W
eigh eigheigh eigh
eigh
ts tsts ts
ts
This section give information on specification of various aggregates
fitted on TATA SAFARI vehicles.
ProCarManuals.com
Page 100 of 161
100
Parking Brake :Lever type, Console
mounted, Cable
operated mechanical
linkages acting on rear
wheels.
9.0 9.09.0 9.0
9.0
FRAME : FRAME :FRAME : FRAME :
FRAME :
Frame :Ladder type cranked frame
with boxed section long
members and welded cross
members
Depth :110 mm (max.)
Width :60mm
10.0 10.010.0 10.0
10.0
SUSPENSION : SUSPENSION :SUSPENSION : SUSPENSION :
SUSPENSION :
Front :Double wishbone type
with Torsion bar springs.
Rear :Coil spring type 5 link
suspension
Shock Absorber : Hydraulic double acting
telescopic type at front
and rear.
Antiroll bar : At both front & rear.
FR FR FR FR
FR
AME AMEAME AME
AME
,, ,,
,
SUSPENSION, SUSPENSION, SUSPENSION, SUSPENSION,
SUSPENSION,
WHEELS & WHEELS & WHEELS & WHEELS &
WHEELS &
T TT T
T
YRES, YRES,YRES, YRES,
YRES,
FUEL FUEL FUEL FUEL
FUEL
T TT T
T
ANK , ANK ,ANK , ANK ,
ANK ,
BOD BOD BOD BOD
BOD
Y AND ELECTRIC Y AND ELECTRICY AND ELECTRIC Y AND ELECTRIC
Y AND ELECTRIC
AL SY AL SYAL SY AL SY
AL SY
STEM STEMSTEM STEM
STEM
11.0 11.011.0 11.0
11.0
WHEELS & WHEELS & WHEELS & WHEELS &
WHEELS &
T TT T
T
YRES : YRES :YRES : YRES :
YRES :
Tyres : 235/70 R 16
Radial with tube
Wheels rims : 6.5 J x 16 Steel rims
No. of wheels : Front 2, Rear 2, Spare -1
12.0 12.012.0 12.0
12.0
FUEL FUEL FUEL FUEL
FUEL
T TT T
T
ANK : ANK :ANK : ANK :
ANK :
Capacity :65 Litres
13.0 13.013.0 13.0
13.0
BODY : BODY :BODY : BODY :
BODY :
Type : Normal control all steel
shell with five doors.
14.0 14.014.0 14.0
14.0
ELECTRICAL SYSTEM : ELECTRICAL SYSTEM :ELECTRICAL SYSTEM : ELECTRICAL SYSTEM :
ELECTRICAL SYSTEM :
System Voltage : 12 Volts (-ve earth)
Alternator Capacity :120 / 125 Amps
Battery : 12 V, MF 70 Z
Capacity : 80 A/h, 20 Hr Rate
VEHICLE SPECIFICATIONS
ProCarManuals.com
Page 103 of 161
103
MAINTENANCE
• •• •
•Engine Compartment Engine CompartmentEngine Compartment Engine Compartment
Engine Compartment
• •• •
•Air filter Air filterAir filter Air filter
Air filter
• •• •
•Cooling system Cooling systemCooling system Cooling system
Cooling system
• •• •
•Engine oil & oil filter Engine oil & oil filterEngine oil & oil filter Engine oil & oil filter
Engine oil & oil filter
• •• •
•Changing fuel filter Changing fuel filterChanging fuel filter Changing fuel filter
Changing fuel filter
• •• •
•Changing gear box oil Changing gear box oilChanging gear box oil Changing gear box oil
Changing gear box oil
• •• •
•Changing transfer case oil Changing transfer case oilChanging transfer case oil Changing transfer case oil
Changing transfer case oil
• •• •
•Changing front axle & rear axle oil Changing front axle & rear axle oilChanging front axle & rear axle oil Changing front axle & rear axle oil
Changing front axle & rear axle oil
• •• •
•Head lamp & head lamp focus adjustment Head lamp & head lamp focus adjustmentHead lamp & head lamp focus adjustment Head lamp & head lamp focus adjustment
Head lamp & head lamp focus adjustment
• •• •
•Clutch & brake fluid Clutch & brake fluidClutch & brake fluid Clutch & brake fluid
Clutch & brake fluid
• •• •
•Power steering Power steeringPower steering Power steering
Power steering
• •• •
•L LL L
L
CR CRCR CR
CR
V (if fitt V (if fittV (if fitt V (if fitt
V (if fitt
ed) ed)ed) ed)
ed)
• •• •
•Battery BatteryBattery Battery
Battery
• •• •
•Starting the engine with jump leads Starting the engine with jump leadsStarting the engine with jump leads Starting the engine with jump leads
Starting the engine with jump leads
• •• •
•Wheels & tyres Wheels & tyresWheels & tyres Wheels & tyres
Wheels & tyres
• •• •
•V VV V
V
ehicle c ehicle cehicle c ehicle c
ehicle c
ar arar ar
ar
e ee e
e
• •• •
•Fuses & Relays Fuses & RelaysFuses & Relays Fuses & Relays
Fuses & Relays
• •• •
•Catalytic Converter Catalytic ConverterCatalytic Converter Catalytic Converter
Catalytic Converter
• •• •
•EGR system EGR systemEGR system EGR system
EGR system
• •• •
•T TT T
T
urb urburb urb
urb
o oo o
o
char charchar char
char
ger gerger ger
ger
• •• •
•Air Conditioning Air ConditioningAir Conditioning Air Conditioning
Air Conditioning
• •• •
•Belts tension Belts tensionBelts tension Belts tension
Belts tension
Your TATA SAFARI is designed to give you long trouble free service for
thousands of kilometres/miles. However with proper maintenance
care you can get optimum performance from your vehicle. We have
indicated some of the important maintenance operations to be
carried out on the vehicle. Please read the procedure carefully and
get it attended at Authorised Workshop.
ProCarManuals.com
Page 109 of 161
109
FUEL FIL FUEL FILFUEL FIL FUEL FIL
FUEL FIL
TER & FUEL SY TER & FUEL SYTER & FUEL SY TER & FUEL SY
TER & FUEL SY
STEM STEMSTEM STEM
STEM
6. Refit the drain plug using a new sealing washer. Tighten
drain plug to 5 mkg. torque.
7. Fill, recommended quantity of fresh engine oil in the crank
case and secure the oil filler cap in its place.
8. Start the engine and run for a few minutes. The engine oil
pressure indicator lamp should go ‘off ’ after starting the
engine.
9. Check for engine oil leakages.
10. Stop the engine and recheck engine oil level after a few
minutes. If necessary add oil to bring the level to the upper
mark on the dipstick.
NOTICE NOTICENOTICE NOTICE
NOTICE
Use of reclaimed oil is not recommended
Priming Pump Priming PumpPriming Pump Priming Pump
Priming Pump
Priming pump is used for priming the fuel manually after
overhauling of the engine or after refitment of fuel lines. Pump
the fuel by means of priming pump until all air in the fuel line is
removed. Before cranking the engine ensure that there is no air
in the fuel system.
NOTICE NOTICENOTICE NOTICE
NOTICE
Please do not loosen/remove high pressure pipes and injectors
for air bleeding in the fuel.
M A I N T E N A N C E
F FF F
F
uel & F uel & Fuel & F uel & F
uel & F
ilt iltilt ilt
ilt
er D er Der D er D
er D
r rr r
r
aining ainingaining aining
aining
Loosen drain plugs by 1-2 turn and drain out water and other
sediments from fuel filter bowls depending on operating
conditions to ensure that no water is allowed to enter the fuel
system.
S SS S
S
edimen edimenedimen edimen
edimen
t tt t
t
er er er er
er
W WW W
W
a aa a
a
t tt t
t
er D er Der D er D
er D
r rr r
r
aining ainingaining aining
aining
Water sedimenter is located near fuel tank at rear left hand side
of the vehicle.
Loosen drain plug by 1-2 turns and drain out water and other
sediments from sedimenter when water level indicator lamp
glows in instrument cluster to ensure that no water is
allowed to enter the fuel system.
Sedimenter
ProCarManuals.com