ACURA TL 1995 Service Owner's Manual
Manufacturer: ACURA, Model Year: 1995, Model line: TL, Model: ACURA TL 1995Pages: 1771, PDF Size: 62.49 MB
Page 21 of 1771
Standards an d Servic e Limit s
Differentia l — Sectio n 1 5
ProCarManuals.com
Page 22 of 1771
Steering — Sectio n 1 7
Brake s — Sectio n 1 9
Suspensio
n — Sectio n 1 8
ProCarManuals.com
Page 23 of 1771
Standards an d Servic e Limit s
Electrica l — Sectio n 2 3
Ai
r Conditionin g — Sectio n 2 2
ProCarManuals.com
Page 24 of 1771
Design SpecificationsProCarManuals.com
Page 25 of 1771
Design SpecificationsProCarManuals.com
Page 26 of 1771
ITEMProCarManuals.com
Page 27 of 1771
Body SpecificationsProCarManuals.com
Page 28 of 1771
Lubrication Points
For the details of lubrication points and types of lubricants to be applied, refer to the illustrated index and various work
procedures (such as Assembly/Reassembly, Replacement, Overhaul, Installation, etc.) contained in each section.
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
LUBRICATION POINTS
Engine
Transmission
Brake Line (Includes Anti-lock brake line)
Power steering gearbox
Steering boots
Throttle cable end
Steering ball joints
Shift lever (Automatic transmission)
Pedal linkage
Intermediate shaft
Brake master cylinder pushrod
Fuel
fill
lid
Trunk hinges
Door hinges upper and lower
Door opening detents
Hood hinges and hood latch
Brake pipe joint (Front and rear wheel house)
Caliper Piston seal, Dust seal,
Caliper pin, Piston
Power steering system
Differential
A/C compressor
LUBRICANT
API Service Grade: Use SH "Energy Conserving II" or SJ
"Energy Conserving" grade oil.
The oil container may also display the API Certification
mark shown below. Make sure it says "For Gasoline
Engines."
SAE Viscosity: See chart below.
Genuine Honda Premium Formula Automatic
Transmission Fluid (ATF)*1
Genuine Honda DOT3 Brake Fluid*2
Steering grease P/N 08733 - B070E
Multi-purpose grease
Honda White Lithium Grease
Rust preventives
Silicone grease
Genuine Honda Power Steering Fluid-V or S*3
Hypoid gear Oil API service GL4 or GL5
Viscosity:
at above -18°C (0°F): SAE 90
at less than -18°C (0°F): SAE 80 W-90
Compressor oil:
DENSO: ND-OIL8 (P/N 38897 - PR7 - A01 AH or 38899 -
PR7-A01)
(For Refrigerant: HFC-134a (R-134a))
API SERVICE LABEL
API CERTIFICATION MARK
Recommended Engine Oil
Engine oil viscosity for ambient temperature ranges
NOTE: The following information as marked *1, *2 and *3 on above chart details for 1997 model:
*1: Always use Genuine Honda Premium Formula Automatic Transmission Fluid (ATF). Using a non-Honda ATF can affect
shift quality.
*2: Always use Genuine Honda DOT3 Brake Fluid. Using a non-Honda brake fluid can cause corrosion and decrease the
life of the system.
*3: Always use Genuine Honda Power Steering Fluid-V or S. Using any other type of power steering fluid or automatic
transmission fluid can cause increase wear and poor steering in cold weather.ProCarManuals.com
Page 29 of 1771
1ProCarManuals.com
Page 30 of 1771
Follow th e Norma l Condition s Maintenanc e Schedul e fo r 199 6 model s i f th e sever e drivin g condition s specifie d i n th e Sever e Condition s Maintenanc e
Schedul e fo r 199 6 Mode l o n page s 4- 6 an d 4- 7 d o no t apply .
*1: D o no t adjus t th e gap , replac e th e spar k plu g if i t i s ou t o f servic e limit .
*2: Refe r t o Bas e Servic e Manua l ('9 5 - '9 7 ACUR A 2.5TL , P/ N 61SW502 )
8-4
8-5
8-4 , 10- 5
11-13 4
23-78
6-6, 10-1 0
17-4,22-24 ,23-89
11-11 4
10-5
14-11 2
15-4
*219-4 , 19-8 ,19-10 , 19-12, 19-15
*219- 7
*219- 6
ProCarManuals.com