check engine BMW MOTORRAD R 1150 GS 2002 Rider's Manual (in English)
[x] Cancel search | Manufacturer: BMW MOTORRAD, Model Year: 2002, Model line: R 1150 GS, Model: BMW MOTORRAD R 1150 GS 2002Pages: 104, PDF Size: 7.54 MB
Page 4 of 104
i
2
Introduction
12
General information and
controls
General view, left side
R 1150 GS ............................ 4
General view, right side
R 1150 GS ............................ 5
General view, left side
R 1150 GS Adventure ........... 6
General view, right side
R 1150 GS Adventure ........... 7
Cockpit ................................. 8
Telltale and warning lights ..... 9
Ignition switch and steering
lock ................................ 10-11
Hazard warning lights .......... 12
Power socket ...................... 13
Left handlebar fitting ........... 14
Right handlebar fitting ......... 15
Dualseat R 1150 GS ..... 16-18
Seat
R 1150 GS Adventure .... 19-20
System case .................. 21-23
Aluminium case .............. 24-26
Adjusting the windscreen .... 27Safety check
Checklist ........................ 28-29
Engine oil ....................... 30-31
Fuel ................................ 32-33
Handlebar levers ............ 34-35
Brake system - general .. 36-37
Brake system - without
BMW Integral ABS ......... 38-40
Brake system - with
BMW Integral ABS ......... 41-44
Clutch ................................. 45
Lights ............................. 46-49
Suspension spring
preload .......................... 50-51
Shock absorber .................. 52
Wheels ........................... 53-55
Accessories and tyres......... 56
Accessories and loads ... 56-57
Contents
10geBKg6.book Seite 2 Dienstag, 19. November 2002 1:11 13
Page 31 of 104
2
29
Safety check
Checklist
For this reason, check the
details in the following sections
before you start the journey:
– Fuel level
– Positions of the handlebar-lever fittings
–Brakes
– Brake fluid level
– Clutch fluid level
– Warning lights and telltale lights
–Lights
– Shock absorber settings and spring preload
– Wheel rim and tyre condition,
tread depth and tyre
pressures
– Load, gross weight – Check regularly (every time
you stop for fuel),
on the basis of the following
section:
– Engine oil level
(every second/third stop for
fuel):
– brake pads
If you encounter any problems
or difficulties, it is always best to
contact your authorised BMW
motorcycle dealer. He will pro-
vide the necessary advice and
assistance.
10geBKg6.book Seite 29 Dienstag, 19. November 2002 1:11 13
Page 32 of 104
2
30
Safety check
Engine oil
Checking oil levelCheck the oil level at regular
intervals.
Always check the oil level when
the engine is at operating tem-
perature, because the differ-
ence between the oil level
indicated when the engine is at
operating temperature and the
oil level indicated when the
engine is very cold due to
extremely low outdoor temper-
atures (-10 °C/14 °F) can be as
much as 10 mm (0.393 in).
After switching off the engine at
operating temperature, wait at
least 5 minutes for the oil to
drain back into the sump.Checking the oil level after the
engine has been run only briefly
or when it is not properly warm
will falsify the reading and could
lead to the engine being oper-
ated with the wrong quantity of
oil, because cold oil is viscous
and takes longer to drain back
into the sump. At extremely low
outdoor temperatures (-10 °C/
14 °F), this can take as long as
12 hours.
e
Attention:
To avoid damage to the engine:
– Never exceed the maximum oil level.
– Always keep the oil level above the minimum mark.
Always check the oil level with
the motorcycle upright.
Check the oil level with the engine at its regular operating
temperature
Check the oil level after the engine has been stopped for
at least 5 minutes
Make sure that the motorcy-
cle is upright
– Make sure the ground is level and firm
10geBKg6.book Seite 30 Dienstag, 19. November 2002 1:11 13
Page 33 of 104
2
31
Safety check
1
MAXMIN2
Check the oil level at the sight glass:
MAX Top edge
of marking ring
MIN Bottom edge
of marking ring
– The difference between the
two marks is approx. 0.5 litre
(0.88 pint)
If necessary, remove oil filler plug 2 and top up the engine
oil through engine oil filler 1.
Reinstall oil filler plug 2e Attention:
Warning light, engine oil pres-
sure red
p (b 9) indicates no
(or very little) oil pressure in
the lube-oil system; this light
m u s t n o t b e r e g a r d e d a s a n o i l
level check. Oil pressure
builds up after 1-2 seconds
and the warning light goes out
– the redengine oil pressure
warning light
p should remain
off while the engine is running.
Engine oil
BMW recommends Castrol
10geBKg6.book Seite 31 Dienstag, 19. November 2002 1:11 13
Page 34 of 104
2
32
Safety check
Fuel
Refuelling
d Warning:
Fuel is flammable and explo-
sive. Do not smoke. Never
bring a naked flame near the
fuel tank.
The fuel expands when hot
(for instance if the fuel tank is
in the sun). For this reason,
only fill as far as the lower
edge of the filler neck.
e Attention:
Leaded fuel will destroy the cat-
alytic converter.
Do not run the fuel tank dry or
you may damage the engine or
the catalytic converter.
Wipe off plastic parts immedi-
ately if they are wetted with fuel.
Place motorcycle on centre stand
– Make sure the ground is level and firm.
Open fuel filler cap
10geBKg6.book Seite 32 Dienstag, 19. November 2002 1:11 13
Page 64 of 104
3
62
Starting – Riding – Parking
Placing motorcycle on
side stand
d Warning:
For safety reasons, never sit
on the motorcycle with the
side stand extended.
e Attention:
Stop the engine before using
the side stand.
Make sure the surface under
the stand is firm.
On a gradient, the motorcycle
should always face uphill; se-
lect 1st gear. Switch off the ignition
Keep both feet on the ground
Hold the left handlebar grip
with your left hand
Keep your right hand on the
right handlebar grip and the
handbrake lever
Hold the motorcycle upright and balanced
U s e y o u r le f t f o o t a t t h e e x t e n -
sion pin to extend the side
stand fully (arrow)
Slowly lean the motorcycle to the side until its weight is
taken by the stand and dis-
mount from the motorcycle
Turn the handlebars to full left
lock (
b 11)
Check that the motorcycle
is firmly supported
Side stand
10geBKg6.book Seite 62 Dienstag, 19. November 2002 1:11 13
Page 66 of 104
3
64
Starting – Riding – ParkingPlacing motorcycle on
main (centre) stand
d Warning:
For safety reasons, never sit
on the motorcycle with the
centre stand extended.
e Attention:
Switch off the engine before
using the centre stand.
Make sure the surface under
the stand is firm. Switch off the ignition
Hold the left handlebar grip
with your left hand
Hold the lifting handle with
your right hand
Place your right foot on the
pin used to extend the centre
stand, and press the stand
down until its curved feet
touch the ground
Place your right foot on the
tread surface of the stand
Apply all your body weight to the stand
Pull the motorcycle to the rear and upwards (arrow) until it
rests on the centre stand
Check that the motorcycle
is firmly supported
Main (centre) stand
10geBKg6.book Seite 64 Dienstag, 19. November 2002 1:11 13
Page 75 of 104
3
73
Starting – Riding – Parking
5
Engine oil pressureWarning light5 goes out above
idle speed.
e Attention:
If warning light 5 comes on dur-
ing the journey, take the follow-
ing action as soon as traffic
conditions permit:
Declutch
Operate the kill switch
Bring the motorcycle safely to a halt
Check engine oil level
(b 31)
e Attention:
If the warning light comes on
even though the oil level is cor-
rect, you must consult a spe-
cialist workshop, preferably an
authorised
BMW motorcycle dealer.
Warning lights
10geBKg6.book Seite 73 Dienstag, 19. November 2002 1:11 13
Page 76 of 104
3
74
Starting – Riding – Parking
The Rider Information Display
operates only when the ignition
is on.
Engine oil temperature
indicator 1
A= engine oil too hot ( red)
OEOptional extra
e Attention:
Switch off the engine, wait 5 min-
utes and then check the oil level
(
b 30). If the oil level is correct, al-
ways consult a specialist work-
shop without delay, preferably an
authorised BMW motorcycle
dealer.
Avoid high engine speeds until
the problem has been dealt with.
B = engine oil at regular operating
temperature
C = engine oil cold ( blue)
Rider Information DisplayOE (RID)
1
A
B
C
10geBKg6.book Seite 74 Dienstag, 19. November 2002 1:11 13
Page 100 of 104
98
Index
i
AAnti-lock braking systemnotes, 88, 89
switching off, 86
BBMW Integral ABS, 60Changing brake fluid, 41
Checking brake fluid level, 41
CCatalytic convertersafety instructions, 61
Checking brake fluid level, 38
Checking brake pads, 37
Checking front brake fluid level, 39, 43
Checking rear brake fluid
level, 40, 44
Checking the brake system, 36
Choke cold start lever, 14
Choke lever
position, 14
Clock (RID), 75
DDipswitch, 14
Dualseat lock, 4
EEngine oil, 31 level check, 4
oil filler, 31 Engine oil filler, 4
Engine oil temperature indicator
(RID), 74
Engine-oil pressure
telltale light, 9
FFront brakebrake fluid reservoir, 5
Front spring preload, 50
Fuel octane number, 33
Fuel cap, 5
Fuel gauge (RID), 74
Fuel tank capacity, 33
Fuse box, 5
GGear shifts, 76, 77
General view left side, 6
Right side, 5, 7
General view, left side, 4
HHandlebar fitting, left, 14
Handlebar fitting, right, 15
Handlebar levers
Clutch lever, 34
handbrake, 35
Hazard warning lights, 12
Heated handlebar grips, 12, 15
Helmet holder, 5
A - H
10geBKg6.book Seite 98 Dienstag, 19. November 2002 1:11 13