steering CADILLAC DEVILLE 2003 8.G Repair Manual

Part C: Periodic
MaintenanceInspections
Listed in this part are inspections and services which
should be performed at least twice a year (for instance,
each spring and fall).
You should let your dealer's
service department do these jobs. Make sure any
necessary repairs are completed at once.
Proper procedures to perform these services may be
found in a service manual. SeeService Publications
Ordering Information on page 7-11.
Steering, Suspension and Front
Drive Axle Boot and Seal Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs of
wear or lack of lubrication. Inspect the power steering
lines and hoses for proper hook-up, binding, leaks,
cracks, cha®ng, etc. Clean and then inspect the drive
axle boot seals for damage, tears or leakage. Replace
seals if necessary.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system. Look for broken, damaged,
missing or out-of-position parts as well as open seams,
holes, loose connections or other conditions which
could cause a heat build-up in the ¯oor pan or could let
exhaust fumes into the vehicle. See
Engine Exhaust
on page 2-38.
Fuel System Inspection
Inspect the complete fuel system for damage or leaks.
6-13

Part D: Recommended Fluids and
Lubricants
Fluids and lubricants identi®ed below by name, part
number or speci®cation may be obtained from your
dealer.
Usage Fluid/Lubricant
Engine OilEngine oil with the American
Petroleum Institute Certi®ed for
Gasoline Engines starburst symbol
of the proper viscosity. To determine
the preferred viscosity for your
vehicle's engine, see
Engine Oil on
page 5-13.
Engine Coolant50/50 mixture of clean, drinkable
water and use only
DEX-COOL
žCoolant. SeeEngine
Coolant on page 5-24.
Hydraulic Brake
SystemDelco Supreme 11 Brake Fluid or
equivalent DOT-3 brake ¯uid.
Windshield
Washer SolventGM Optikleen
žWasher Solvent or
equivalent.
Parking Brake
Cable GuidesChassis Lubricant (GM Part No.
U.S. 12377985, in Canada
88901242, or equivalent) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Usage Fluid/Lubricant
Power Steering
SystemGM Power Steering Fluid (GM Part
No. U.S. 1052884, in Canada
993294, or equivalent).
Automatic
TransaxleDEXRON
ž-IIII Automatic
Transmission Fluid.
Key Lock
CylindersMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474, or equivalent).
Hood Latch
Assembly,
Secondary
Latch, Pivots,
Spring Anchor
and Release
PawlLubriplate Lubricant Aerosol (GM
Part No. U.S. 12346293, in Canada
992723, or equivalent) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Hood and Door
HingesMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474, or equivalent).
Weatherstrip
ConditioningDielectric Silicone Grease (GM Part
No. U.S. 12345579, in Canada
10953014, or equivalent).
6-15

Reporting Safety Defects to
General Motors
In addition to notifying NHTSA (or Transport Canada) in
a situation like this, we certainly hope you'll notify us.
Please call us at 1-800-458-8006, or write:
Cadillac Customer Assistance Center
Cadillac Motor Car Division
P.O. Box 33169
Detroit, MI 48232-5169
In Canada, please call us at 1-800-263-3777 (English)
or 1-800-263-7854 (French). Or, write:
Customer Communication Centre, 163-005
General Motors of Canada Limited
1908 Colonel Sam Drive
Oshawa, Ontario L1H 8P7
Service Publications Ordering
Information
Service Manuals
Service Manuals have the diagnosis and repair
information on engines, transmission, axle, suspension,
brakes, electrical, steering, body, etc.
RETAIL SELL PRICE: $120.00
Transmission, Transaxle, Transfer
Case Unit Repair Manual
This manual provides information on unit repair service
procedures, adjustments and speci®cations for GM
transmissions, transaxles and transfer cases.
RETAIL SELL PRICE: $50.00
7-11

A
Accessory Power Outlets.................................3-27
Adaptive Seat Controls...................................... 1-3
Adding Washer Fluid.......................................5-37
Additional Program Information........................... 7-9
Additives, Fuel................................................. 5-6
Add-On Electrical Equipment............................5-93
Adjusting the Speakers (Balance/Fade)......3-83, 3-92
Air Bag Systems.............................................1-49
How Does an Air Bag Restrain?....................1-56
Servicing Your Air Bag-Equipped Vehicle.........1-59
What Makes an Air Bag In¯ate?....................1-56
What Will You See After an Air Bag In¯ates?......1-57
When Should an Air Bag In¯ate?...................1-55
Where Are the Air Bags?..............................1-52
Air Bag .........................................................3-45
Readiness Light..........................................3-45
Air Cleaner/Filter, Engine.................................5-19
AM .............................................................3-105
Analog Cluster................................................3-42
Antenna, Diversity Antenna System..................3-108
Antenna, XMŸ Satellite Radio
Antenna System........................................3-108
Anti-lock Brake System (ABS)............................ 4-7
Anti-Lock Brake, System Warning Light..............3-48
Anti-Pinch Feature..........................................2-17
Appearance Care............................................5-84
Care of Safety Belts....................................5-87
Chemical Paint Spotting...............................5-90Appearance Care (cont.)
Cleaning the Inside of Your Vehicle................5-84
Cleaning the Outside of Your Vehicle..............5-88
Finish Damage............................................5-90
Sheet Metal Damage...................................5-90
Underbody Maintenance...............................5-90
Vehicle Care/Appearance Materials................5-91
Weatherstrips..............................................5-87
Ashtrays........................................................3-28
Assist Handles...............................................2-53
Audio System(s).............................................3-80
Audio Steering Wheel Controls....................3-105
Care of Your Cassette Tape Player...............3-106
Care of Your CD Player..............................3-107
Care of Your CDs......................................3-107
Diversity Antenna System............................3-108
Glovebox-Mounted CD Changer...................3-100
Navigation/Radio System.............................3-100
Radio Personalization with Home and Away
Feature.................................................3-103
Radio with Cassette and CD.................3-81, 3-89
Setting the Time for Radios with Radio Data
Systems (RDS)........................................3-80
Setting the Time for Radios without Radio
Data Systems (RDS)................................3-80
Theft-Deterrent Feature...............................3-104
Understanding Radio Reception...................3-105
XMŸ Satellite Radio Antenna System...........3-108
Auto Exit Seat................................................3-69
Auto Exit Steering Wheel.................................3-70
1

Center Console Storage Area...........................2-51
Center Flex Storage Unit.................................2-52
Center Front Passenger Position, Safety Belts....1-21
Center High-Mounted Stoplamp (CHMSL)...........5-58
Chains, Tires..................................................5-70
Charging System Light....................................3-46
Checking Coolant............................................5-26
Checking Engine Oil........................................5-14
Checking Things Under the Hood......................5-10
Checking Your Restraint Systems......................1-60
Check...........................................................3-50
Engine Light...............................................3-50
Chemical Paint Spotting...................................5-90
Child Restraints..............................................1-35
Child Restraint Systems...............................1-35
Infants and Young Children...........................1-32
Lower Anchorages and Top Tethers for
Children (LATCH System)..........................1-41
Older Children.............................................1-29
Securing a Child Restraint Designed for the
LATCH System........................................1-43
Securing a Child Restraint in a Rear Seat
Position..................................................1-44
Securing a Child Restraint in the Right Front
Seat Position...........................................1-46
Top Strap Anchor Location............................1-41
Top Strap...................................................1-39
Where to Put the Restraint...........................1-38Cigarette Lighter.............................................3-28
Cleaning Aluminum or Chrome-Plated Wheels.....5-89
Cleaning Exterior Lamps/Lenses.......................5-88
Cleaning Fabric/Carpet....................................5-85
Cleaning Glass Surfaces..................................5-87
Cleaning Leather............................................5-86
Cleaning the Interior Plastic Components...........5-86
Cleaning the Mirror.................................2-40, 2-42
Cleaning the Speaker Covers...........................5-87
Cleaning the Top of the
Instrument Panel.........................................5-86
Cleaning Tires................................................5-89
Cleaning Vinyl................................................5-86
Cleaning Windshield and Wiper Blades..............5-89
Cleaning Wood Panels....................................5-87
Cleaning........................................................5-84
Inside of Your Vehicle..................................5-84
Outside of Your Vehicle................................5-88
Underbody Maintenance...............................5-90
Weatherstrips..............................................5-87
Climate Control System...................................3-36
Air Filter, Passenger Compartment.................3-36
Climate Controls Personalization....................3-39
Dual..........................................................3-29
Outlet Adjustment........................................3-33
Rear..........................................................3-34
Steering Wheel Controls...............................3-38
Comfort Controls, DIC Personalization................3-67
3

Engine (cont.)
Coolant......................................................5-24
Cooling System Inspection............................6-14
Exhaust.....................................................2-38
Oil .............................................................5-13
Overheating................................................5-27
Starting......................................................2-25
English/Metric Button.......................................3-44
Entering Feature Programming..........................3-67
Entry Lighting.................................................3-20
Erasing HomeLink
žButtons..............................2-50
Exiting Feature Programming............................3-78
Express-Down Window....................................2-16
Express-Up Window........................................2-16
Extender, Safety Belt.......................................1-28
Exterior Lamps...............................................3-15
Exterior Lighting Battery Saver..........................3-19
Exterior Lights at Unlock..................................3-72
F
Filter.............................................................5-19
Engine Air Cleaner......................................5-19
Finding a PTY Station (RDS and XMŸ).............3-94
Finding a PTY Station (XMŸ Only)...................3-83
Finding a Station....................................3-82, 3-90
Finish Care....................................................5-88Finish Damage...............................................5-90
Flash-To-Pass.................................................. 3-9
Flat Tire, Changing.........................................5-72
Flat Tire........................................................5-71
Floor Mats.....................................................2-53
Fluid.............................................................5-21
Automatic Transaxle.....................................5-21
Power Steering...........................................5-36
Windshield Washer......................................5-37
FM Stereo....................................................3-105
Fog Lamp Light..............................................3-54
Fog Lamps....................................................3-17
Following Distance..........................................4-38
Footnotes........................................................ 6-5
Front Ashtray.................................................3-28
Front Storage Area.........................................2-51
Fuel............................................................... 5-4
Additives...................................................... 5-6
California Fuel.............................................. 5-5
Data Display...............................................3-56
Filling a Portable Fuel Container..................... 5-9
Filling Your Tank........................................... 5-7
Fuels in Foreign Countries.............................. 5-6
Gage.........................................................3-55
Gasoline Octane........................................... 5-4
Gasoline Speci®cations.................................. 5-5
System Inspection.......................................6-13
6

Horn Sounds at Lock......................................3-72
Horn............................................................... 3-7
How the System Works...................................3-26
How to Add Coolant to the Coolant Surge Tank......5-31
How to Add Fluid............................................5-23
How to Check Power Steering Fluid..................5-36
How to Check........................................5-21, 5-62
How to Reset the Transaxle Fluid Indicator.........5-23
How to Use This Manual...................................... ii
How to Wear Safety Belts Properly...................1-14
Hydroplaning..................................................4-19
I
If No Steam Is Coming From Your Engine..........5-29
If Steam Is Coming From Your Engine...............5-28
If the Light Is Flashing.....................................3-51
If the Light Is On Steady.................................3-52
If You Are Stuck in Sand, Mud, Ice or Snow.......4-30
If You Do Decide To Pull a Trailer.....................4-35
If You're Caught in a Blizzard...........................4-27
Ignition Positions.............................................2-23
Ignition Transaxle Lock Check..........................6-12
Inadvertent Power Battery Saver.......................3-22
Infants and Young Children, Restraints...............1-32
In¯ation Ð Tire Pressure.................................5-61Inspection......................................................6-14
Brake System.............................................6-14
Engine Cooling System................................6-14
Exhaust System..........................................6-13
Fuel System...............................................6-13
Part C - Periodic Maintenance.......................6-13
Steering, Suspension and Front Drive Axle
Boot and Seal.........................................6-13
Throttle System...........................................6-14
Instrument Panel Brightness.............................3-19
Instrument Panel.............................................3-40
Cluster.......................................................3-40
Overview..................................................... 3-4
Storage Area..............................................2-51
Interior Lamps................................................3-19
J
Jump Starting.................................................5-43
K
Key in Recall Memory.....................................3-68
Key Lock Cylinders Service..............................6-10
Keyless Entry System....................................... 2-4
Keys............................................................... 2-3
8

M
Magnetic Speed Variable Assist Steering System . . . 4-11
Maintenance, Normal Replacement Parts..........5-103
Maintenance Schedule...................................... 6-9
At Each Fuel Fill........................................... 6-9
At Least Once a Month.................................. 6-9
At Least Once a Year..................................6-10
At Least Twice a Year..................................6-10
Brake System Inspection..............................6-14
Engine Cooling System Inspection.................6-14
Exhaust System Inspection...........................6-13
Fuel System Inspection................................6-13
How This Section is Organized....................... 6-3
Introduction.................................................. 6-2
Maintenance Requirements............................. 6-2
Part A - Scheduled Maintenance Services......... 6-4
Part B - Owner Checks and Services............... 6-9
Part C - Periodic MaintenanceInspections......6-13
Part D - Recommended Fluids and Lubricants . 6-15
Part E - Maintenance Record........................6-16
Scheduled Maintenance................................. 6-4
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection..........................6-13
Throttle System Inspection............................6-14
Using Your................................................... 6-4
Your Vehicle and the Environment................... 6-2
Maintenance When Trailer Towing.....................4-40Making Turns.................................................4-38
Malfunction Indicator Light................................3-50
Map Pocket...................................................2-52
Massaging Lumbar Controls............................... 1-3
Matching Transmitter(s) to Your Vehicle............... 2-6
Memory Mirrors..............................................2-55
Memory Seat.................................................2-55
Memory Steering Wheel Controls......................2-55
Message.......................................................3-60
DIC Warnings and Messages........................3-60
Mexico, Central America and
Caribbean Islands/Countries
(Except Puerto Rico and U.S. Virgin Islands) ±
Customer Assistance..................................... 7-5
Mirror Operation.....................................2-40, 2-41
Mirror to Curb In Reverse................................3-77
Mirrors..........................................................2-40
Automatic Dimming Rearview with OnStar
ž
and Compass..........................................2-40
Automatic Dimming Rearview with OnStarž.....2-40
Memory.....................................................2-55
Outside Automatic Dimming Mirror.................2-43
Outside Convex Mirror.................................2-44
Outside Curb View Assist Mirror....................2-43
Outside Heated Mirrors................................2-44
Outside Power Mirrors..................................2-42
MyGMLink.com................................................ 7-4
10

N
Navigation/Radio System................................3-100
New Vehicle Break-In......................................2-23
Night Vision System........................................3-22
Normal Maintenance Replacement Parts...........5-103
O
Odometer, Trip...............................................3-43
Odometer......................................................3-43
Off-Road Recovery..........................................4-13
Oil ................................................................5-13
Engine.......................................................5-13
Life Indicator...............................................3-79
Pressure Light.............................................3-53
Older Children, Restraints................................1-29
Online Owner Center........................................ 7-4
OnStar
žPersonal Calling.................................2-45
OnStaržServices............................................2-45
OnStaržSteering Wheel Controls......................2-46
OnStaržSystem.............................................2-45
OnStaržVirtual Advisor....................................2-46
Other Warning Devices...................................... 3-7
Outlet Adjustment............................................3-33
Outside.........................................................2-43
Automatic Dimming Mirror.............................2-43
Convex Mirror.............................................2-44Outside (cont.)
Curb View Assist Mirror................................2-43
Heated Mirrors............................................2-44
Power Mirrors.............................................2-42
Overheated Engine Protection Operating Mode . . . 5-27
Overseas ± Customer Assistance........................ 7-5
Owners, Canadian............................................... ii
Owner's Information........................................7-12
P
Parade Dimming.............................................3-20
Park Aid........................................................3-25
Park (P)........................................................2-37
Shifting Out of............................................2-37
Parking Brake and Automatic Transaxle Park (P)
Mechanism Check.......................................6-12
Parking on Hills..............................................4-39
Parking.........................................................3-25
Assist........................................................3-25
Brake Indicator Light....................................3-47
Brake........................................................2-32
Over Things That Burn.................................2-38
Park(P).........................................................2-34
Shifting Into................................................2-34
Part A - Scheduled Maintenance Services............ 6-4
Part B - Owner Checks and Services.................. 6-9
Part C - Periodic MaintenanceInspections..........6-13
11

Part D - Recommended Fluids and Lubricants....6-15
Part E - Maintenance Record...........................6-16
Passenger Compartment Air Filter.....................3-36
Passing.................................................4-13, 4-38
PASS-Key
žIII Operation..................................2-21
PASS-KeyžIII ................................................2-21
Performance Shifting (DTS Only).......................2-30
Personalization, Climate Controls......................3-39
Plan Ahead When Possible................................ 7-8
Playing a Cassette Tape..........................3-86, 3-97
Playing a Compact Disc..........................3-87, 3-98
Playing the Radio...................................3-81, 3-90
Power Steering...............................................4-11
Power Tilt Wheel and Telescopic Steering
Column........................................................ 3-8
Power...........................................................3-27
Accessory Outlets........................................3-27
Door Locks.................................................. 2-9
Electrical System.........................................5-93
Lumbar Controls........................................... 1-2
Rear Lumbar Controls.................................... 1-8
Seat............................................................ 1-2
Steering Fluid.............................................5-36
Windows....................................................2-16
Pretensioners, Safety Belt................................1-28
Programmable Automatic Door Locks.................. 2-9
Programming the HomeLink Transmitter.............2-48
Q
Questions and Answers About Safety Belts.........1-13
R
Radio Data System (RDS)...............................3-89
Radios..........................................................3-80
Care of Your Cassette Tape Player...............3-106
Care of Your CD Player..............................3-107
Care of Your CDs......................................3-107
DIC Personalization.....................................3-67
Glovebox-Mounted CD Changer...................3-100
Navigation/Radio System.............................3-100
Radio Personalization with Home and Away
Feature.................................................3-103
Radio with Cassette and CD.................3-81, 3-89
Setting the Time for Radios with Radio Data
Systems (RDS)........................................3-80
Setting the Time for Radios without Radio
Data Systems (RDS)................................3-80
Theft-Deterrent..........................................3-104
Understanding Reception............................3-105
RainsenseŸ II Wipers.....................................3-10
RDS Messages..............................................3-93
Reaching Roadside Service............................... 7-7
Reading Lamps..............................................3-21
12