technical specifications Lancia Musa 2007 Owner handbook (in English)

297
WARNING
LIGHTS AND
MESSAGES
TECHNICALSPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT
USE OF
THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
CHECKING FLUID
LEVELS
IMPORTANT When topping up
take care not to confuse the
various types of fluids: they are
all incompatible with one
another and could seriously
damage the car.
IMPORTANT Never smoke
while working in the engine
compartment: gas and
inflammable vapours may be
present, with the risk of fire.
L0D0206m
L0D0259m
1.416Vversions
1.48Vversions (where provided)
1 Engine coolant - 2 Engine
oil- 3 Brake fluid - 4 Battery -
5 Windscreen/rear window

298
WARNING
LIGHTS AND
MESSAGES
TECHNICALSPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT
USE OF
THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
1 Engine oil - 2 Battery -
3 Brake fluid - 4 Windscreen/
rear window - 5 Engine coolant
L0D0325m1.9 Multijet versions
L0D0207m1.3 Multijet versions
1 Engine oil - 2 Battery -
3 Brake fluid - 4 Windscreen/
rear window - 5 Engine coolant

ENGINE OIL
Checking engine oil
Check the oil level a few minutes (about 5) after the engine has
stopped, with the car parked on level ground.
Check that the level is within the MIN and MAX marks on the
dipstick. The interval between the MIN and MAX marks corresponds
to about one litre of oil.
Topping up engine oil
If the oil level is near or even below the MIN mark, add oil through
the filler neck, until reaching the MAX mark. Oil level shall never
exceed the MAX mark.
IMPORTANT If a routine check reveals that the oil level is above the
MAX mark, contact Lancia Dealership to have the correct level
restored.
IMPORTANT After adding or changing the oil, let the engine turn
over for a few seconds and wait a few minutes after turning it off
before you check the level.
299
WARNING
LIGHTS AND
MESSAGES
TECHNICALSPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT
USE OF
THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
L0D0208m
L0D0209mL0D0326m
1.416Vversions
1.3 Multijet versions 1.9 Multijet versions
L0D0258m1.48Vversions
(where provided)

Engine oil consumption
Max engine oil consumption is usually 400 grams
every 1000 km.
When the car is new, the engine needs to run in,
therefore the engine oil consumption can only be
considered stabilised after the first 5000 - 6000 km.IMPORTANT The oil consumption depends on
driving style and the conditions under which the car
is used.
IMPORTANT Do not add oil with specifications
other than that already in the engine.
300
WARNING
LIGHTS AND
MESSAGES
TECHNICALSPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT
USE OF
THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
Used engine oil and filter contain harmful substances for the environment.
Contact Lancia Dealership to have the oil and filter changed.
When the engine is hot, take care when working inside the engine compartment to
avoid burns. Remember that when the engine is hot, the fan may cut in: danger of
injury. Scarves, ties and other loose clothing might be pulled by moving parts.
WARNING

ENGINE COOLANT FLUID
The coolant level shall be checked with cold engine and shall be
included between the MIN and MAX mark on the reservoir.
If the level is low, pour slowly a mixture of 50% distilled water and
50% FL Selenia PARAFLU UP through the filler neck.
A 50-50 mixture of PARAFLU UP and distilled water gives freeze
protection to –35°C.
IMPORTANT Do not remove the reservoir cap when the engine is hot:
you risk scalding yourself.
301
WARNING
LIGHTS AND
MESSAGES
TECHNICALSPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT
USE OF
THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
L0D0210m
L0D0211m
1.48V(where provided)-
1.416Vversions
1.3 and 1.9 Multijet versions
DUAL FUNCTION SYSTEM GEARBOX HYDRAULIC
SYSTEM OIL
To have the oil level checked contact Lancia Dealership only.
WARNING
The cooling system uses PARAFLU UP antifreeze. Do not add fluid having
different specifications from that already existing. PARAFLU UP cannot be mixed
with other types of fluids. Should other fluids be added, do not start the engine
and contact Lancia Dealership as soon as possible.
The cooling system is pressurised. If necessary, replace the cap only with another
genuine one, otherwise system efficiency could be compromised.
WARNING

WINDSCREEN/REAR WINDOW/HEADLIGHT WASHER FLUID
To top up, remove the cap (A) and then pour a mixture of water and
TUTELA PROFESSIONAL SC 35, in the following concentrations:
❒30% TUTELA PROFESSIONAL SC 35 and 70% water in
summer;
❒50% TUTELA PROFESSIONAL SC 35 and 50% water in winter.
In case of temperatures below –20°C, use undiluted TUTELA
PROFESSIONAL SC 35.
Check level through the reservoir.
302
WARNING
LIGHTS AND
MESSAGES
TECHNICALSPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT
USE OF
THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
L0D0212m
WARNINGDo not travel with the windscreen washer reservoir empty: the windscreen washer
is fundamental for improving visibility.
WARNINGCertain commercial additives for windscreen washers are inflammable. The
engine compartment contains hot components which may set it on fire.

BRAKE FLUID
Unscrew cap: check that the fluid level in the reservoir is at
maximum.
Fluid level in the reservoir shall not exceed the MAX mark.
If fluid has to be added, it is suggested to use the brake fluid in table
"Fluids and lubricants" (see chapter "Technical characteristics").
NOTE Clean accurately the tank cap and the surrounding surface.
At plug opening, pay maximum attention in order to prevent any
impurities from entering the tank.
For topping up, always use a funnel with integrated filter with mesh
equal to or lower than 0.12 mm.
IMPORTANT Brake fluid absorbs moisture, for this reason, if the car
is mainly used in areas with a high degree of atmospheric humidity,
the fluid should be replaced at more frequent intervals than specified
in the “Service schedule”.
303
WARNING
LIGHTS AND
MESSAGES
TECHNICALSPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT
USE OF
THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
L0D0213m
Prevent brake fluid, which is highly corrosive, from coming into contact with painted parts.
Should it happen, immediately wash with water.
Symbolπon the container indicates synthetic brake fluid, distinguishing it
from the mineral kind. Using mineral fluids irreversibly damages the special
braking system rubber seals.
WARNING
Brake fluid is poisonous and highly corrosive. In the event of accidental contact,
wash the parts involved immediately with neutral soap and water, then rinse
thoroughly. Call the doctor immediately if the fluid is swallowed.
WARNING

DIESEL FUEL FILTER
(“green filter”)
DRAINING THE CONDENSE (Multijet versions)
IMPORTANT The presence of water in the fuel
circuit may cause serious damage to the entire
injection system and cause irregular engine
operation. If the warning light
cturns on (or oncertain versions, a dedicated message is shown on
the multifunction display) contact a Lancia
Dealership as soon as possible to have the bleeding
operation carried out.
304
WARNING
LIGHTS AND
MESSAGES
TECHNICALSPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT
USE OF
THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
WARNING
The presence of water in the fuel circuit may cause serious damage to the entire
injection system and cause irregular engine operation. If the warning light
c
turns on (or on certain versions, a dedicated message is shown on the
reconfigurable multifunction display) contact a Lancia Dealership as soon as
possible to have the bleeding operation carried out. Should the above indications
take place after refuelling, water has probably been poured into the tank: turn the
engine off immediately and contact a Lancia Dealership.

BATTERY
The battery is of the “Limited maintenance” type: under normal
conditions of use the electrolyte does not need topping up with
distilled water.
CHECKING THE CHARGE
The battery charge may be checked satisfactorily through the
inspection slot using the indicator (where provided) and acting
according to the colour the indicator shows.
Refer to the table below or to the label on the battery (see figure).
305
WARNING
LIGHTS AND
MESSAGES
TECHNICALSPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT
USE OF
THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
L0D0215m
Bright white colour
Dark colour
without green area in the centre
Dark colour
with green area in the centreTop up electrolyte
Low charge level
Electrolyte level and charge suffi-
cientContact Lancia Dealership
Charge the battery
(advisable to contact Lancia Dealership)
No action
WARNING
The liquid in the battery is poisonous and corrosive. Avoid contact with eyes and
skin. Do not bring naked flames or possible sources of sparks near to the battery:
risk of fire and explosion.
WARNING
Running the battery with low fluid level can damage the battery beyond repair
and could also cause its explosion.

If the battery is not fitted with electrolyte level
indicator, the relevant checks must only be carried
out by authorised personnel.
To check the battery charge, slacken the two
fastening screws and open the cover. Check the
battery charge and then reclose the cover, take care
to prevent pinching and short circuits.CHANGING THE BATTERY
If required, replace the battery with a genuine spare
part having the same specifications.
If a battery with different specifications is fitted, the
service intervals given in the “Service schedule” in
this section will no longer be valid. Refer to the
instructions provided by the battery manufacturer.
306
WARNING
LIGHTS AND
MESSAGES
TECHNICALSPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT
USE OF
THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
WARNINGWhen working on the battery or near it, always wear the proper goggles. Batteries contain substances that are very harmful for the environment. You are advised to have
the battery changed at a Lancia Dealership, which is properly equipped for disposing of used
batteries respecting nature and the law.
Incorrect fitting of electrical and electronic accessories can seriously damage the car.
If after buying the car, you want to install electric accessories which require permanent electric
supply (alarm, free-hand phone kit, etc.) contact Lancia Dealership whose qualified personnel, in
addition to suggesting the most suitable devices, will evaluate the overall electric absorption,
checking whether the car’s electric system is capable of withstanding the load required, or whether
it should be integrated with a more powerful battery.
If the car is left inactive for long periods at cold, remove the battery and store it
in a warm place to prevent freezing.
WARNING