meter NISSAN TIIDA 2007 Service Manual Online

CHG
L TERMINAL CIRCUIT
CHG-39
< COMPONENT DIAGNOSIS >[K9K]
C
D
E
F
G
H
I
J
K
L B A
O
P N
L TERMINAL CIRCUIT
DescriptionINFOID:0000000001724511
The terminal “2” (L) circuit controls the charge warning lamp. The charge warning lamp illuminates when the
ignition switch is set to ON or START. When the generator is providing sufficient voltage with the engine run-
ning, the charge warning lamp will go off. If the charge warning lamp illuminates with the engine running, a
malfunction is indicated.
Diagnosis ProcedureINFOID:0000000001724512
1.CHECK CHARGE WARNING LAMP CIRCUIT CONNECTION
Verify generator connector F1 terminal 2 is clean and tight.
Is the connection secure?
YES >> GO TO 2
NO >> Repair the connection. Confirm repair by performing complete Starting/Charging system test.
Refer to Technical Service Bulletin.
2.CHECK CHARGE WARNING LAMP CIRCUIT
1. Disconnect generator connector F1.
2. Apply ground to generator harness connector F1 terminal 2 with
the ignition switch in the ON position.
Does the charge lamp illuminate?
YES >> Check generator function. Refer to CHG-33, "Work
Flow".
NO >> GO TO 3
3.CHECK HARNESS CONTINUITY
1. Turn ignition switch OFF.
2. Disconnect the generator connector F1 and combination meter
connector M24.
3. Check continuity between generator harness connector F1 ter-
minal 2 and combination meter harness connector M24 terminal
38.
4. Check continuity between generator harness connector F1 ter-
minal 2 and ground.
Are the continuity results as specified?
YES >> Replace the combination meter. Refer to XX-XX, "*****".
NO >> Repair the harness or connector.Charge lamp should illuminate
ALMIA0328GB
Terminal Terminal
Continuity
Connector Terminal Connector Terminal
F1 2 M24 38 Yes
Te r , m i n a l
—
Continuity
Connector Terminal
F1 2 Ground No
ALMIA0329GB

CHG-44
< SERVICE DATA AND SPECIFICATIONS (SDS) [K9K]
SERVICE DATA AND SPECIFICATIONS (SDS)
SERVICE DATA AND SPECIFICATIONS (SDS)
SERVICE DATA AND SPECIFICATIONS (SDS)
GeneratorINFOID:0000000001691231
Applied modelK9K
Ty p e0 124 525 082
BOSCH make
Nominal rating [V - A] —
Ground polarity—
Minimum revolution under no-load (When 13.5 V
is applied)[rpm] —
Hot output current (When 13.5 V is applied) [A/rpm] —
Regulated output voltage [V] —
Minimum length of brush [mm (in)] —
Brush spring pressure [N (g, oz)] —
Slip ring minimum outer diameter [mm (in)] —
Rotor (Field coil) resistance [Ω]—

CL-16
< SERVICE INFORMATION >
SERVICE DATA AND SPECIFICATIONS (SDS)
SERVICE DATA AND SPECIFICATIONS (SDS)
Clutch Control SystemINFOID:0000000001375300
Clutch PedalINFOID:0000000001375301
Clutch DiscINFOID:0000000001375302
Clutch CoverINFOID:0000000001375303
Type of clutch controlHydraulic
Clearance ″A″ between clutch pedal and ASCD switch threaded
end while clutch pedal is fully released (if equipped). 0.74 - 1.96 mm (0.0291 - 0.0772 in)
Clearance ″C″ between clutch pedal and clutch interlock switch
threaded end while clutch pedal is fully depressed.0.74 - 1.96 mm (0.0291 - 0.0772 in)
Model225
Facing size (outer dia. × inner dia. × thickness) 225 mm × 160 mm × 3.2 mm (8.86 in × 6.30 in × 0.126 in)
Thickness of disc assembly with load 7.2 - 7.6 mm (0.283 - 0.299 in) with 5,394 N (550 kg, 1,213 lb)
Runout limit/diameter of the area to be measured 1.0 mm (0.039 in) / 215 mm (8.46 in) dia.
Maximum spline backlash (at outer edge of disc) 1.0 mm (0.039 in)
Wear limit of facing surface to rivet head 0.3 mm (0.012 in)
Set-load5,394 N (550 kg, 1,213 lb)
Diaphragm spring lever height 20 - 22 mm (0.79 - 0.87 in)
Uneven limit diaphragm spring toe height 0.7 mm (0.028 in) or less

CO-10
< PREPARATION >[HR16DE]
PREPARATION
PREPARATION
PREPARATION
Special Service ToolINFOID:0000000001534595
The actual shapes of Kent-Moore tools may from those of special service tools illustrated here.
Commercial Service ToolINFOID:0000000001534596
Tool number
(Kent-Moore No.)
Tool nameDescription
K V 1 0 1111 0 0
(J-37228)
Seal cutterRemoving chain tensioner cover and water
pump cover
—
(J-23688)
Engine coolant refractometerChecking concentration of ethylene glycol in
engine coolant
NT046
WBIA0539E
NISSAN tool number
Tool nameDescription
Radiator cap tester Checking radiator and radiator cap
(J-33984-A)
Radiator cap tester adapterAdapting radiator cap tester to radiator cap
and radiator filler neck
a: 28 (1.10) dia.
b: 31.4 (1.236) dia.
c: 41.3 (1.626) dia.
Unit: mm (in)
WS39930000
Tube pressurePressing the tube of liquid gasket
PBIC1982E
S-NT564
S-NT052

CO-34
< PREPARATION >[MR18DE]
PREPARATION
PREPARATION
PREPARATION
Special Service ToolINFOID:0000000001337834
The actual shapes of Kent-Moore tools may from those of special service tools illustrated here.
Commercial Service ToolINFOID:0000000001337835
Tool number
(Kent-Moore No.)
Tool nameDescription
K V 1 0 1111 0 0
(J-37228)
Seal cutterRemoving chain tensioner cover and water
pump cover
—
(J-23688)
Engine coolant refractometerChecking concentration of ethylene glycol in
engine coolant
NT046
WBIA0539E
NISSAN tool number
Tool nameDescription
Radiator cap tester Checking radiator and radiator cap
(J-33984-A)
Radiator cap tester adapterAdapting radiator cap tester to radiator cap
and radiator filler neck
a: 28 (1.10) dia.
b: 31.4 (1.236) dia.
c: 41.3 (1.626) dia.
Unit: mm (in)
WS39930000
Tube pressurePressing the tube of liquid gasket
PBIC1982E
S-NT564
S-NT052

PREPARATION
CO-57
< PREPARATION >[K9K]
C
D
E
F
G
H
I
J
K
L
MA
CO
N
P O
PREPARATION
PREPARATION
Special Service ToolsINFOID:0000000001381583
Commercial Service ToolsINFOID:0000000001381584
NISSAN tool number
(RENAULT tool number)
Tool nameDescription
—
(M.S. 554-07)
Reservoir tank cap tester
1. Adapter A
—
(M.S. 554-01)
2. Adapter B
—
(M.S. 554-06)Leak checking
Checking reservoir tank cap
K V 1 0 1111 0 0
(J-37228)
Seal cutterRemoving chain tensioner cover and water
pump cover
—
(J-23688)
Engine coolant refractometerChecking concentration of ethylene glycol in
engine coolant
E1BIA0058ZZ
NT046
WBIA0539E
NISSAN tool number
Tool nameDescription
Radiator cap tester Checking radiator and radiator cap
WS39930000
Tube pressurePressing the tube of liquid gasket
PBIC1982E
S-NT052

DLK-3
C
D
E
F
G
H
I
J
L
MA
B
DLK
N
O
P
TRUNK LID UNLOCK SWITCH .........................94
Description ..............................................................94
Component Function Check ..................................94
Diagnosis Procedure ...............................................94
Component Inspection ............................................96
BACK DOOR OPENER SWITCH ......................98
Description ..............................................................98
Component Function Check ..................................98
Diagnosis Procedure ...............................................98
Component Inspection ..........................................100
TRUNK LID OPENER SWITCH .......................101
Description ............................................................101
Component Function Check ................................101
Diagnosis Procedure .............................................101
Component Inspection ..........................................103
UNLOCK SENSOR ..........................................104
Description ............................................................104
Component Function Check ................................104
Diagnosis Procedure .............................................104
Component Inspection ..........................................106
DOOR LOCK ACTUATOR ...............................108
DRIVER SIDE ..........................................................108
DRIVER SIDE : Description ..................................108
DRIVER SIDE : Component Function Check ......108
DRIVER SIDE : Diagnosis Procedure ...................108
PASSENGER SIDE .................................................109
PASSENGER SIDE : Description .........................109
PASSENGER SIDE :
Component Function Check ................................
109
PASSENGER SIDE : Diagnosis Procedure ..........109
REAR LH .................................................................111
REAR LH : Description ..........................................111
REAR LH : Component Function Check .............111
REAR LH : Diagnosis Procedure ..........................111
REAR RH .................................................................112
REAR RH : Description .........................................112
REAR RH : Component Function Check .............112
REAR RH : Diagnosis Procedure ..........................113
BACK DOOR ...........................................................114
BACK DOOR : Description ....................................114
BACK DOOR : Component Function Check .......114
BACK DOOR : Diagnosis Procedure ....................114
BACK DOOR : Component Inspection ..................116
TRUNK LID OPENER ACTUATOR .................117
Description ............................................................117
Component Function Check ................................117
Diagnosis Procedure .............................................117
Component Inspection ..........................................118
INSIDE KEY ANTENNA ...................................120
INSTRUMENT CENTER ..........................................120
INSTRUMENT CENTER : Description ..................120
INSTRUMENT CENTER :
Component Function Check ................................
120
INSTRUMENT CENTER : Diagnosis Procedure ...120
CONSOLE ................................................................123
CONSOLE : Description ........................................123
CONSOLE : Component Function Check ............123
CONSOLE : Diagnosis Procedure .........................124
REAR FLOOR ..........................................................127
REAR FLOOR : Description ..................................127
REAR FLOOR : Component Function Check ......127
REAR FLOOR : Diagnosis Procedure ...................128
OUTSIDE KEY ANTENNA ..............................132
Description .............................................................132
Component Function Check ................................132
Diagnosis Procedure .............................................132
STEERING LOCK SOLENOID .......................134
Diagnosis Procedure .............................................134
KEY INTERLOCK SOLENOID (M/T) ..............137
Diagnosis Procedure .............................................137
STOP LAMP SWITCH (A/T) ...........................138
Diagnosis Procedure .............................................138
STOP LAMP SWITCH (M/T) ...........................140
Diagnosis Procedure .............................................140
INTELLIGENT KEY WARNING BUZZER .......142
Description .............................................................142
Component Function Check ................................142
Diagnosis Procedure .............................................142
Component Inspection ...........................................143
BUZZER (COMBINATION METER) ...............145
Description .............................................................145
Component Function Check ................................145
Diagnosis Procedure .............................................145
KEY WARNING LAMP ....................................146
Description .............................................................146
Component Function Check ................................146
Diagnosis Procedure .............................................146
LOCK WARNING LAMP .................................147
Description .............................................................147
Component Function Check ................................147
Diagnosis Procedure .............................................147
HAZARD WARNING LAMPS .........................148
Description .............................................................148
Component Function Check ................................148
Diagnosis Procedure .............................................148
VEHICLE SPEED SIGNAL CIRCUIT ..............149
Description .............................................................149
Component Function Check ................................149
Diagnosis Procedure .............................................149

DLK-4
INTELLIGENT KEY BATTERY AND FUNC-
TION .................................................................
150
Description .............................................................150
Component Function Check ................................150
Diagnosis Procedure .............................................150
Component Inspection ...........................................150
Special Repair Requirement ..................................150
ECU DIAGNOSIS .......................................151
INTELLIGENT KEY UNIT ................................151
Reference Value ....................................................151
Wiring Diagram - INTELLIGENT KEY SYSTEM - ..158
Fail Safe ................................................................171
DTC Inspection Priority Chart .............................171
DTC Index .............................................................171
BCM (BODY CONTROL MODULE) ................172
Reference Value ....................................................172
Wiring Diagram - POWER DOOR LOCK SYSTEM
- .............................................................................
172
Wiring Diagram - BACK DOOR OPENER SYS-
TEM - .....................................................................
182
Wiring Diagram - TRUNK LID OPENER SYSTEM
- .............................................................................
186
Fail Safe ................................................................188
DTC Inspection Priority Chart .............................189
DTC Index .............................................................189
SYMPTOM DIAGNOSIS ............................191
DOOR LOCK FUNCTION SYMPTOMS ..........191
DOOR LOCK AND UNLOCK SWITCH ...................191
DOOR LOCK AND UNLOCK SWITCH : Symptom
Table ......................................................................
191
INTELLIGENT KEY ..................................................192
INTELLIGENT KEY : Symptom Table ...................192
DOOR REQUEST SWITCH .....................................193
DOOR REQUEST SWITCH : Symptom Table ......193
KEY REMINDER ......................................................193
KEY REMINDER : Symptom Table .......................194
AUTO RELOCK .......................................................194
AUTO RELOCK : Symptom Table .........................194
BACK DOOR OPEN FUNCTION SYMPTOMS
.
195
BACK DOOR OPENER SWITCH ............................195
BACK DOOR OPENER SWITCH : Symptom Ta-
ble ..........................................................................
195
TRUNK OPEN FUNCTION SYMPTOMS ........196
TRUNK LID OPENER SWITCH ...............................196
TRUNK LID OPENER SWITCH : Symptom Table ..196
WARNING FUNCTION SYMPTOMS ...............197
BUZZER (COMBINATION METER) ........................197
BUZZER (COMBINATION METER) : Symptom
Table .....................................................................
197
INTELLIGENT KEY WARNING BUZZER ...............197
INTELLIGENT KEY WARNING BUZZER : Symp-
tom Table ..............................................................
197
IGNITION KNOB SWITCH DOES NOT TURN ON .198
IGNITION KNOB SWITCH DOES NOT TURN ON
: Symptom Table ...................................................
198
WARNING LAMP ....................................................199
WARNING LAMP : Symptom Table ......................199
BACK DOOR ...........................................................200
BACK DOOR : Symptom Table ............................200
HAZARD AND BUZZER REMINDER FUNC-
TION SYMPTOMS ............................................
201
HAZARD WARNING LAMP ....................................201
HAZARD WARNING LAMP : Symptom Table ......201
INTELLIGENT KEY WARNING BUZZER ...............201
INTELLIGENT KEY WARNING BUZZER : Symp-
tom Table ..............................................................
201
SQUEAK AND RATTLE TROUBLE DIAG-
NOSES ..............................................................
202
Work Flow .............................................................202
Inspection Procedure ............................................204
Diagnostic Worksheet ...........................................206
PRECAUTION ...........................................208
PRECAUTIONS ................................................208
Precaution for Supplemental Restraint System
(SRS) "AIR BAG" and "SEAT BELT PRE-TEN-
SIONER" ...............................................................
208
Precaution Necessary for Steering Wheel Rota-
tion After Battery Disconnect ................................
208
Precaution for Procedure without Cowl Top Cover .209
Precaution for Work ..............................................209
PREPARATION .........................................210
PREPARATION ................................................210
Commercial Service Tool ......................................210
ON-VEHICLE MAINTENANCE .................211
PRE-INSPECTION FOR DIAGNOSTIC ...........211
Basic Inspection ....................................................211
REMOVAL AND INSTALLATION .............213
HOOD ...............................................................213
Fitting Adjustment .................................................213
Removal and Installation .......................................214
Removal and Installation of Hood Lock Control ....215
Hood Lock Control Inspection ...............................217

DLK-7
C
D
E
F
G
H
I
J
L
MA
B
DLK
N
O
P BACK DOOR : Component Inspection ..................
321
TRUNK REQUEST SWITCH ............................322
Description ............................................................322
Component Function Check ................................322
Diagnosis Procedure .............................................322
Component Inspection ..........................................324
BACK DOOR OPENER SWITCH ....................325
Description ............................................................325
Component Function Check ................................325
Diagnosis Procedure .............................................325
Component Inspection ..........................................327
TRUNK LID OPENER SWITCH .......................328
Description ............................................................328
Component Function Check ................................328
Diagnosis Procedure .............................................328
Component Inspection ..........................................330
DOOR LOCK ACTUATOR ...............................331
DRIVER SIDE ..........................................................331
DRIVER SIDE : Description ..................................331
DRIVER SIDE : Component Function Check ......331
DRIVER SIDE : Diagnosis Procedure ...................331
PASSENGER SIDE .................................................332
PASSENGER SIDE : Description .........................332
PASSENGER SIDE :
Component Function Check ................................
332
PASSENGER SIDE : Diagnosis Procedure ..........332
REAR LH .................................................................334
REAR LH : Description ..........................................334
REAR LH : Component Function Check .............334
REAR LH : Diagnosis Procedure ..........................334
REAR RH .................................................................335
REAR RH : Description .........................................335
REAR RH : Component Function Check .............335
REAR RH : Diagnosis Procedure ..........................336
BACK DOOR ...........................................................337
BACK DOOR : Description ....................................337
BACK DOOR : Component Function Check .......337
BACK DOOR : Diagnosis Procedure ....................337
BACK DOOR : Component Inspection ..................339
SUPER LOCK ACTUATOR .............................340
DRIVER SIDE ..........................................................340
DRIVER SIDE : Description ..................................340
DRIVER SIDE : Component Function Check ......340
DRIVER SIDE : Diagnosis Procedure ...................340
PASSENGER SIDE .................................................341
PASSENGER SIDE : Description .........................341
PASSENGER SIDE :
Component Function Check ................................
341
PASSENGER SIDE : Diagnosis Procedure ..........341
REAR LH .................................................................343
REAR LH : Description ..........................................343
REAR LH : Component Function Check ..............343
REAR LH : Diagnosis Procedure ...........................343
REAR RH .................................................................344
REAR RH : Description .........................................344
REAR RH : Component Function Check .............344
REAR RH : Diagnosis Procedure ..........................345
TRUNK LID OPENER ACTUATOR ................347
Description .............................................................347
Component Function Check ................................347
Diagnosis Procedure .............................................347
Component Inspection ...........................................348
INSIDE KEY ANTENNA ..................................350
INSTRUMENT CENTER ..........................................350
INSTRUMENT CENTER : Description ..................350
INSTRUMENT CENTER :
Component Function Check ................................
350
INSTRUMENT CENTER : Diagnosis Procedure ...350
CONSOLE ................................................................353
CONSOLE : Description ........................................353
CONSOLE : Component Function Check ............353
CONSOLE : Diagnosis Procedure .........................354
REAR FLOOR ..........................................................357
REAR FLOOR : Description ..................................357
REAR FLOOR : Component Function Check ......357
REAR FLOOR : Diagnosis Procedure ...................358
OUTSIDE KEY ANTENNA ..............................362
Description .............................................................362
Component Function Check ................................362
Diagnosis Procedure .............................................362
STEERING LOCK SOLENOID .......................364
Diagnosis Procedure .............................................364
KEY INTERLOCK SOLENOID (M/T) ..............367
Diagnosis Procedure .............................................367
STOP LAMP SWITCH (A/T) ...........................368
Diagnosis Procedure .............................................368
STOP LAMP SWITCH (M/T) ...........................370
Diagnosis Procedure .............................................370
INTELLIGENT KEY WARNING BUZZER .......372
Description .............................................................372
Component Function Check ................................372
Diagnosis Procedure .............................................372
Component Inspection ...........................................373
BUZZER (COMBINATION METER) ...............375
Description .............................................................375
Component Function Check ................................375
Diagnosis Procedure .............................................375
KEY WARNING LAMP ....................................376
Description .............................................................376

DLK-8
Component Function Check ................................376
Diagnosis Procedure .............................................376
LOCK WARNING LAMP .................................377
Description .............................................................377
Component Function Check ................................377
Diagnosis Procedure .............................................377
HAZARD WARNING LAMPS ..........................378
Description .............................................................378
Component Function Check ................................378
Diagnosis Procedure .............................................378
VEHICLE SPEED SIGNAL CIRCUIT ..............379
Description .............................................................379
Component Function Check ................................379
Diagnosis Procedure .............................................379
INTELLIGENT KEY BATTERY AND FUNC-
TION .................................................................
380
Description .............................................................380
Component Function Check ................................380
Diagnosis Procedure .............................................380
Component Inspection ...........................................380
Special Repair Requirement ..................................380
ECU DIAGNOSIS .......................................381
INTELLIGENT KEY UNIT ................................381
Reference Value ....................................................381
Wiring Diagram - INTELLIGENT KEY SYSTEM - ..388
Fail Safe ................................................................400
DTC Inspection Priority Chart .............................400
DTC Index .............................................................400
BCM (BODY CONTROL MODULE) ................401
Reference Value ....................................................401
Wiring Diagram - POWER DOOR LOCK SYSTEM
- .............................................................................
401
Wiring Diagram - BACK DOOR OPENER SYS-
TEM - .....................................................................
411
Wiring Diagram - TRUNK LID OPENER SYSTEM
- .............................................................................
415
Fail Safe ................................................................417
DTC Inspection Priority Chart .............................418
DTC Index .............................................................418
SYMPTOM DIAGNOSIS ............................420
DOOR LOCK FUNCTION SYMPTOMS ..........420
DOOR LOCK AND UNLOCK SWITCH ...................420
DOOR LOCK AND UNLOCK SWITCH : Symptom
Table ......................................................................
420
INTELLIGENT KEY ..................................................421
INTELLIGENT KEY : Symptom Table ...................421
DOOR REQUEST SWITCH .....................................422
DOOR REQUEST SWITCH : Symptom Table ......422
KEY REMINDER ......................................................422
KEY REMINDER : Symptom Table ......................423
AUTO RELOCK .......................................................423
AUTO RELOCK : Symptom Table ........................423
BACK DOOR OPEN FUNCTION SYMPTOMS
..
424
BACK DOOR OPENER SWITCH ...........................424
BACK DOOR OPENER SWITCH : Symptom Ta-
ble .........................................................................
424
TRUNK OPEN FUNCTION SYMPTOMS .........425
TRUNK LID OPENER SWITCH ..............................425
TRUNK LID OPENER SWITCH : Symptom Table .425
WARNING FUNCTION SYMPTOMS ...............426
BUZZER (COMBINATION METER) ........................426
BUZZER (COMBINATION METER) : Symptom
Table .....................................................................
426
INTELLIGENT KEY WARNING BUZZER ...............426
INTELLIGENT KEY WARNING BUZZER : Symp-
tom Table ..............................................................
426
IGNITION KNOB SWITCH DOES NOT TURN ON .427
IGNITION KNOB SWITCH DOES NOT TURN ON
: Symptom Table ...................................................
427
WARNING LAMP ....................................................428
WARNING LAMP : Symptom Table ......................428
BACK DOOR ...........................................................429
BACK DOOR : Symptom Table ............................429
HAZARD AND BUZZER REMINDER FUNC-
TION SYMPTOMS ............................................
430
HAZARD WARNING LAMP ....................................430
HAZARD WARNING LAMP : Symptom Table ......430
INTELLIGENT KEY WARNING BUZZER ...............430
INTELLIGENT KEY WARNING BUZZER : Symp-
tom Table ..............................................................
430
SQUEAK AND RATTLE TROUBLE DIAG-
NOSES ..............................................................
431
Work Flow .............................................................431
Inspection Procedure ............................................433
Diagnostic Worksheet ...........................................435
PRECAUTION ...........................................437
PRECAUTIONS ................................................437
Precaution for Supplemental Restraint System
(SRS) "AIR BAG" and "SEAT BELT PRE-TEN-
SIONER" ...............................................................
437
Procedure without Cowl Top Cover ...................437
Steering Wheel Rotation after Battery Disconn
ect .........................................................................
437
Work ......................................................................438