CADILLAC FLEETWOOD 1994 Owners Manual

surfaces. Use cleaners that are marked safe for painted surfaces to
remove foreign matter.
FINISH DMGE
Any stone chips, fractures or deep scratches in the finish should be
repaired right away. Bare metal will corrode quickly and may develop
into a major repair expense.
Minor chips and scratches can be repaired with touch-up materials
available from your dealer
or other service outlets. Larger areas of finish
damage can be corrected in your dealer's body and paint shop.
UNDERBODYWNTENN/'E
Chemicals used for ice and snow removal and dust control can collect on
the underbody.
If these are not removed, accelerated corrosion (rust) can
occur on the underbody parts such as fuel lines, frame, floor pan, and
exhaust system even though they have corrosion protection.
At least every spring, flush these materials from the underbody with plain
water. Clean any areas where mud and other debris can collect. Dirt
packed in closed areas of the frame should be loosened before being
I flushed. Your dealer or an underbody vehicle washing system can do this
for you.
CHEMICAL PANT SPOTTING
Some weather and atmospheric conditions can create a chemical fallout.
Airborne pollutants can fall upon and attack painted surfaces on your
vehicle.
This damage can take two forms: blotchy, ringlet-shaped
discolorations, and small irregular dark spots etched into the paint surface.
Although no defect in the paint job causes this, Cadillac will repair, at no
charge to the owner, the surfaces of new vehicles damaged by this fallout
condition within
12 months or 12,000 miles (20 000 km) of purchase,
whichever comes first.
D/
a i
308

APPEGACE CAREMATERLZS CIiART
w NUMBER
I
1052277 12 OZ. (0.354 L)
1050172 .16 OZ. (0.473 L)
1050173 16 OZ. (0.473 L)
10501 74 16 OZ. (0.473 L)
105021 4 32 02. (0.946 L)
1050244 16 OZ. (0.473 L)
1050427 23 OZ. (0.680 L)
I
1050429 6 LB. (2.72 KG)
1052349 12 OZ. (0.354 L)
1050.729 8 OZ. (0.237 L)
1052870 16 OZ. (0.473 L)
1051 398
8'02. (Oi237 L)
DESCRIPTION,
SPRAY-A-SQUEAK
TAR AND ROAD OIL
REMOVER'
C.HROME CLEANER
AND POLISH
WHITE SIDEWALL
TIRE CLEANER
VINYL/LEATHER CLEANER
FABRIC CLEANER
GLASS CLEANER MULTI-PURPOSE
POWDERED
CLEANER
~~
LUBRIPLATE (WHITE GREASE)
VINYL TOP CLEANER
WASH-WAX (CONC.) SPOT LIFTER
GM OPTIKLEEN
MAGIC MIRROR
CLEANER POLISH
USAGE
WEATHER STRIPS-STOPS
SQUEAKS
ON,
METAL-TO-METAL AND
METAL-TO-RUBBER
CO.NTACT
REMOVES OLD WAXES,
POLISHES, TAR AND ROAD
01 L
REMOVES RUST AND
CORROSION ON CHROME
AND STAINLESS' STEEL
CLEANS WHITE AND BLACK TIRES
SPOT AND STAIN REMOVAL
ON LEATHER
OR VINYL
SPOT AND STAIN REMOVAL
ON CLOTH AND FABRIC
GLASS CLEANING AND
SPOT CLEANING ON VINYLS
CLEANS VINYL AND CLOTH
ON DOOR TRIM, SEATS,
AND MATS AND CARPET-ALSO, TIRES
GREASE FOR HOOD,
TRUNK AND DOOR HINGES
AND LATCHES
CLEANING OF VINYL TOPS
EXTERIOR WASH
SPOT AND STAIN REMOVAL
ON CLOTH A,ND FABRIC
WINDSHIELD WASHER SOLVENT AND
ANTI-FREEZE
EXTERIOR CLEANER AND
POLISH,
309

KEHICLE IDENTIFICATIONNUMBER WN)
I
El lG6DW52PXRR700001 lGMl A
NATl
1 G 6 DW5 2'P X P R700001
1 = USA
MANUFACTURER
G
= GENERAL MOTORS
I MAKE
6
= CADILLAC
CARLINE/SERIES
-
DW = BROUGHAM
VIN BODY CODE
= BODY TYPE -
5 = 69 SEDAN 4DOOR/ 4 WINDOW NOTCHBACK
-7 PRODUCTION
SEQUENCE
NUMBER
- ASSEMBLY PLANT
R = ARLINGTON, TEXAS
MODEL YEAR
R = 1994
-. CHECK DIGIT
- ENGINE CODE
P = 5.7 LITER VB
- RESTRAINT SYSTEM:
2 - ACTIVE (MANUAL) BELTS WITH
DRIVER AND PASSENGERS INFLATABLE RESTRAINT SYSTEM
1
310
Ll I
U!
31

r_ This is the legal identifier for your CadillaciIt appears on a plate in the
front corner of the. instrument panel, on the driver’s side. You can see it
if
you look through the windshield from outside your vehicle. The VIN also
appears on the Vehicle Certification and Service Parts labels and the
certificates
of title and registration.
Engine Identification
The eighth character in your VIN is the engine code. This code will help
you identify your engine, specifications, and replacement parts.
SERVICE PARTS IDENTD?ICATION LABEL
You’ll find this label on the underside of the trunk lid. It’s very helpful if
you ever need to order parts. On this label is:
0 your VIN,
the model designation,
0 paint information, and
a list of all production options and special equipment.
Be sure that this label is not removed from the vehicle.
ADD-ON ELECTHCAL EQUIPMENT
NOTICE:
Don’t add anything electrical to your Cadillac unless you check
with your dealer first. Some electrical equipment can damage
your vehicle and the damage wouldn’t be covered by your
warranty. Some add-on electrical equipment can keep other
components from working as they should.
311

FUSES AND CIRCUIT BREAKERS
The wiring circuits in your vehicle are protected from short circuits by a
combination of Mini Fuses, Circuit Breakers, and
Maxi Fuses. This
greatly reduces the chance of fires caused. by electrical problems..
If you ever have a problem on the road and don’t have a spare fuse, you
can “borrow” one,of the correct value. Select a feature that you can get
along without tha.t is the same value you need
-- like the radio or cigarette
lighter
-- and use its fuse. Be sure to use a fuse with the same amperage
rating number on it (ie.
lOA, 20A, etc.). Replace it as soon as you can.
Instrument Panel Fuse Block
To gain access to the fuse block.
Remove the
instrument panel side
cover.
312
611
E
r-‘
I
LJI!
I

1 - MIR DEFG (10 AMP) - SIDEVIEW MIRROR DEFOGGERS 2-5 - NOT USED
6 - T/SIG (15 AMP) - PARWNEUTRALAND BACKUP
- TURN FLASHER SWITCH ASSEMBLY 7 - EBTCMlTPS (10 AMP) - ELECTRONIC BRAKE AND TRACTION
CNTRL. MOD. (EBTCM)
- THROlTLE POSITION SENSOR
(TIPS) INTERFACE MODULE
8 - RAP WPR (25 AMP) - RETAINED ACCESSORY PWR. (RAP)
9 - RADIO (10 AMP)
10
- WIPER (25 AMP) - RADIO RECEIVER
11 - II/P INDC (10 AMP) - WINDSHIELD WIPEWASHER
WIPER RELAY
- INFLATABLE RESTRAINT
DIAGNOSTIC ENERGY RESERVE
(WITH SENSOR) MODULE
INDICATORS
- INSTRUMENT PANEL CLUSTER
12 - ELC IGN 1 (10 AMP) - AUTOMATIC LEVEL CNTRL. SENSOR 13 - CHIME (10 AMP) - WARNING ALARM CRUISE CNTRL.
RELEASE SWITCH
- REAR WINDOW DEFOG. RELAY - INSULE REAR VIM MIRROR (DDB) - CATALYTIC CONVERTER TEMP
. . - - - . . . . - . .
14 - CCM ION 1 (10 AMP)
15
- AIR BAG (15 AMP)
ALARM (JAPAN ONLY)
- CENTRAL CNTRL. MOD. (CCM)
- INFLATABLE RESTRAINT
DIAGNOSTIC ENERGY RESERVE (WITH SENSOR) MOD.
16 - GEN (10 AMP) - ENGINE ELECTRICAL GENERATOR - SECONDARY ELECTRICAL ENGINE
17 - MEM SEAT (10 AMP) COOLING FAN RELAY
- DRIVER'S SEAT MEMORY MOD. - DRIVER SEAT ADJUSTER CNTRL.
- HEATED PASSENGER SEAT
MOD.
CNTRL MOD.
18 - -
19 - -
20 - -
-
- 21 - -
22-
23 - -
-
24 - -
25 - -
CCM IGN 3 10 AMP)
RECEIVER AND THEFT
DETERRENT MOD.
RAP PWR (30 AMP) RETAINED ACCESSORY PWR. (RAP)
AIC COMP (10 AMP) PWR. RELAY
NC COMPRESSOR RELAY
PRIMARY ELECTRICAL ENGINE
COOLING FAN RELAY
RAP BATT (25 AMP) RETAINED ACCESSORY PWR. (RAP)
WIPER RELAY
HVAC MOD. 25 AMP)
TRK REL (10 AMP)
REAR COMPARTMENT LID
RELEASE SW.
STARTER 10 AMP
RESTRAINT DIAGNOSTIC ENERGY
RESERVE (WITH SENSOR) MOD.
HVAC ION (10 AMP)
CLUSTER INSTRUMENT PANEL GAGE
REMOTE
CARL. DOOR LOCK
Nc ELECTRILL CNTRL. MOD.
THEFT DELREN? RELAY INFLAT.
26 - ELC SENS (20 AMP - HVAC.FOWER MOD.
- AUTOMATIC LwEL ANTRL. SENSOR - REAR COMPARTMENT COURTESY
LAMP
27 - &NT LTS (1 5 AMP) - DELAYED INTERIOR LIGHTS (DIL)
RELAY
28 -
29 -
30 - -
- -
31 -
32- 33 -
-
-
-
FRY CIG (1 0 AMP) FRONT CIGAR LIGHTERS RR CIG
(20 AMP)
EBTCM 25 AMP) REAR CIGAR LIGHTERS
CNTRL. MOD. (EBTCM)
PARK LTS (20 AMP
HORN
(25 AMP)
WARNING ALARM HVAC BAT (10 AMP)
INSTRUMENT CLUSTER
HEADLAMP SWITCH
RADIO RECEIVER ALARM
HEATER AND NC CNTRL.
ENGINE
OIL LEVEL INDICATOR
ELECTR6NIC BRAKE &TRACTION
FORWARD LAMP WIRING RELAY
CNTRL~ MOD.
34 - CCM BAT (10 AMP)
35 - PWR MIR 110 AMP) - CENTRAL CNTRL. MOD. (CCM)
- DOOR LOCKS ' - OUTSIDE REMOTE CNTRL.
- PWR. SEAT BACK LUMBAR CNTRLS. REARVIEW MIRRORS SWITCHES
36 - TRK PDWN 115 AMPI __ ...... ~ ~~~~ - TRUNK LID PULL-DOWN UNIT 37 - HAZARD LTS (20 AMP)
39 - PWR LUMB (20 AMP) - HAZARD LAMP FLASHER
- PWR. SEAT BACK PNEUMATIC
- RADIO POWER ANTENNA RELAY
- DRIVERS HEATED SEAT
CNTRL. MOD. 40 - HTD SEAT
(20 AMP)
CNTRL. MOD.
CNTRL. MOD. - PASSENGER HEATED SEAT
41 - CORNR LTS (10 AMP) - INSTRUMENT CLUSTER: - RADIO CNTRL. -I - 42 - -
TURN SIGNAL SWlTCt
HEADLIGHT SWITCH I/P DIM LTS (10 AMP)
INTERIOR LIGHTS
TAIL LTS (10 AMP) DIMMING CNTRL.
REAR TAIL LIGHTS REAR SIDE MARKER L LICENSE LAMP STOP LTS (20 AMP) STOP LAMP SWITCH PWR LK (20 AMP) DOOR LOCK RELAY .IGHTS CIB 1 - NOT USED
C/B 2 - RAP RELAY (30 AMP) - RETAINED ACCESSORY PWR. (RAP)
RELAY
C/B 3 - PWR ST (30 AMP)
- PASSENGER PWR. SEAT SW. - DRIVERS PWR. SEAT SW.
- MEMORY SEAT MOD.
- REAR DEFOGGER RELAY C/0 4 - RR DEFG (30 AMP)
C/B
5 - HD LTS (30 AMP) - HEADLIGHT RELAY - DAYTIME RUNNING UGHTS (DRL)
313

Underhood (UIH) Electrical Center
The U/H electrical center is located on the passenger side wheel housing
I in the engine compartment.
Remove the cover
to
gain access.
314

FUSE USAGE CHART
0
FOR MORE INFORMATION, SEE OWNER’S MANUAL
UNDERHOOD (U/H) ELECTRICAL CENTER BODY 1 (SO AMP)
I/P FUSE BLOCK
#3 PWR. SEAT CIRCUIT
BREAKER (30 AMP)
#36 TRUNK PULL-DOWN
#37 HAZARD LTS. (20 AMP)
(15 AMP)
#39 PWR. LUMBAR (20 AMP)
#40 HEATED SEAT (20 AMP)
#44 STOP LTS. (20 AMP)
#45 PWR. LOCK (20 AMP)
BODY 2 (50 AMP)
I/P FUSE BLOCK
- #21 RAP BAT (25 AMP)
- #22 HVAC MDL. (25 AMP) - #26 ELC. SENS. (20 AMP) - #27 D/INT LTS. (1 5 AMP) - #28 FRT CIG. (1 0 AMP) - #29 RR. CIG. (20 AMP) - #30 EBTCM (25 AMP) - #33 HVAC BAT (10 AMP) - #34 CCM BAT (10 AMP) - #35 PWR. MIR. (10 AMP) - #2 CIRCUIT BREAKER - RAP RLY (30 AMP) 3 - ION 1 (50 AMP) - I/P CONCEALED FUSE - RKE/UTD SA - I/P FUSE BLOCK - #6 T/SIS-ICA - #7 EBTCMDPS (1 0 AMP) - #8 RAP WPR. (25 AMP)
- #10 WIPER (25 AMP) - #9 RADIO (10 AMP)
- #li I/P IiDC (10 AMP) - #12 ELC. IGN. 1 (10 AMP) - #13 CHIME (10 AMP) - #14 CCM IGN 1 (10 AMP) - #15 AIR BAG (1 5 AMP) - #24 STARTER, U/H ELC. CNTR. - #15 PCM/IGN (10AMP) - #16 INJ 1 (10AMP) - #17 EMISSIONS (1 0 AMP) - #18 INJ 2 (10 AMP) 4 - ION 3 (40 AMP)
I/P FUSE BLOCK
- #16 GEN. (10 AMP) - #17 MEM. SEAT (10 AMP) - #18 CCM IGN 3 (10 AMP) - #19 RAP PWR. (30 AMP) - #20 A/C COMF! (10 AMP) - #25 HVAC IGN (10 AMP)
- BRAKE PRESSURE 5 - ABSRC (60 AMP)
MODULATOR VALVE (BPMV) 6 - NOT USED 7 - SCNDRY CLG FAN (40 AMP) - SECONDARY COOLING FAN
CNTRL. RELAY
8 - PRIMRY CLG FAN (40 AMP) - PRIMARY COOLING FAN
9 - LEVEL CNTRL. (30 AMP) CNTRL. REIAY
- AUTOMATIC LEVEL CNTRL.
10 - ENGINE (30 AMP) AIR COMR
- #13 PCM/FUEL PUMP (15 AMP) - #14 AIR PUMP (20 AMP)
11 - I/P FUSE BLOCK CIRCUIT
BREAKER
- #5 HDLTS (20 AMP) - #31 PARK LTS. (20 AMP) - #32 HORN (25 AMP) 12 - EMPTY 13 - PCM FUEL PUMP 115 AMP) - FUEL PUMP RELA? - FUEL PUMP AND ENGINE OIL PRESSURE INDICATOR SWITCH
MDL (PCM) - POWER TRAIN CONTRL.
14 - AIR PUMP (20 AMP) - SECONDARY AIR IN (AIR)
PUMP RELAY
15 - PCM IGN (10 AMP) - IGN COIL - ELECTRONIC TRANS. - (PCM) POWER TRAIN
CNTRL. MDL.
16- INJ 1 110AMP) ~ - FUEL I‘NJ 1,4,6,7 17 - EMISSIONS (10 AMP) - (A.I.R.) PUMP‘RELAY . - MASS AIR FLOW (MAF)
- HEATED OXYGEN SENSOR’S - EVAPORATIVE EMISSIONS
SENSOR
CANNISTER PURGE
SOLONOID VALVE
18- INJ 2 (10 AMP) - FUEL INJ 2,3,5,8
315

Headlights
The headlight wiring is protected by a circuit breaker in the light switch.
An electrical overload will cause the lights to go on and off, or in some
cases to remain
off. If this happens, have your headlight wiring checked
right away.
Windshield Wipers
The windshield wiper motor is protected by a circuit breaker and a fuse.
If the motor overheats due to heavy snow, etc., the wiper will stop until
the motor cools. If the overload is caused by some electrical problem and
not snow, etc., be sure to get it fixed.
Power Windows and Other Power Options
Circuit breakers in the fuse panel protect the power windows and other
power accessories. When the current load is too heavy, the circuit breaker
opens and closes, protecting the circuit until the problem is fixed or goes
away.
316
fll

.
BULB. CILL4RT .
.
.
.
.
.
.
.
You can get these from your Cadillac dealer .
DESCRIPTION BULB NO .
Ash Tray Illumination .................................. 1445
Center High Mounted Stop Light
........................ 1141
Cornering Light
....................................... 2057
BackupLights
......................................... 2057
Courtesy Light
. Front Door ............................ S214-2
Courtesy Light
. Rear Door ............................ S214-2
CourtesyMap Light
..................................... 192
Front Parking
& Directional Signal .................... 2057NA
Front Side Marker Light
................................. 194
Glove Box
............................................. 194
Headlight High Beam
...................... 906/HB4 (H2990 4)
Headlight Low Beam
....................... 905/HB3 (K1790 3)
License Plate Light ..................................... 194
Side Marker Lights
..................................... 194
Stop, Tail.
& Directional Signal Light ..................... 2057
TrunkLight
......................................... 5 92081
Vanity Mirror Light
..................................... 194
Parking
Light
.......................................... 2057
Underhood Light
........................................ -93
317