LAND ROVER DEFENDER 1999 Owner's Guide
Manufacturer: LAND ROVER, Model Year: 1999, Model line: DEFENDER, Model: LAND ROVER DEFENDER 1999Pages: 667, PDF Size: 8.76 MB
Page 31 of 667
04GENERAL SPECIFICATION DATA
8
INFORMATION AIR CONDITIONING
System CFC free, expansion valve system.............................................................................
Compressor Nippon Denso.....................................................................
Refrigerant R134a CFC free.......................................................................
Charge quantity 750 g±50 g ................................................................
Refrigerant oil ND-OIL 8...................................................................
WIPER MOTORS
Tailgate wiper motor
Make/type IMOS (non-serviceable)........................................................................
Running current, wet screen at 20°C ambient 1.0 to 2.8 amps.................
Wiper speed, wet screen at 20°C ambient 37 to 43 cycles per minute.......................
Windscreen wiper motor
Make/type Lucas 14W uprated two speed........................................................................
Armature end float 0,1 to 0,2 mm............................................................
Brush length, minimum 4,8 mm....................................................
Brush spring tension 140 to 200 g........................................................
Resistance of armature winding
at 16˚C (69˚F) measured between adjacent
commutatator segments 0.23 to 0.35 ohms...................................................
Light running, rack disconnected: current at 13.5 V 2.0 amps.........
Wiper speed, wet screen, 60 seconds from cold Low speed - 45±3 rev/min, High speed - 65±5 ..............
rev/min
ELECTRICAL
System 12 volt, negative ground.............................................................................
Battery
Make/type Delphi GP31........................................................................
Alternator
Type Nippon Denso.................................................................................
Fuses
Type Autofuse (blade type) blow ratings to suit individual.................................................................................
circuits
Horns
Make/type Mixo TR99........................................................................
Starter motor
Make and type Bosch 12v.................................................................
ProCarManuals.com
Page 32 of 667
GENERAL SPECIFICATION DATA
9
INFORMATION BULBS
REPLACEMENT BULBS TYPE
Headlamps 12V 60/55W Halogen
Front side lamps 12V 5W
Side repeater lamps 12V 5W
Tail lamps 12V 21W
Cente High Mounted Stop Lamp 12V 21W
Direction indicator lamps 12V 21W
Number plate lamp 12V 4W
Reverse lamp 12V 21W
Rear fog guard lamp 12V 21W
Interior roof lamps 12V 10W
Instrument illumination 12V 1.2W
Warning light panel 12V 1.2W
Hazard warning switch 12V 1.2W
CAUTION: The fitting of new bulbs with wattages in excess of those specified will result in damage
to vehicle wiring and switches.
ProCarManuals.com
Page 33 of 667
04GENERAL SPECIFICATION DATA
10
INFORMATION VEHICLE WEIGHTS AND PAYLOAD
When loading a vehicle to its maximum (Gross Vehicle Weight), consideration must be taken of the unladen
vehicle weight and the distribution of the payload to ensure that axle loadings do not exceed the permitted
maximum values.
It is the customer’s responsibility to limit the vehicle’s payload in an appropriate manner such that neither
maximum axle loads nor Gross Vehicle Weight are exceeded.
Maximum EEC kerb weight and distribution - all optional equipment
VEHICLE AXLE WEIGHTS
90 models Station Wagon Utility
Front axle 1200 Kg (2645 lb)......................................................................... 1200 Kg (2645 lb)
Rear axle 1500 kg (3307 lb).......................................................................... 1500 Kg (3307 lb)
Gross vehicle weight 2550 Kg (5291 lb)........................................................ 2400 Kg (5622 lb)
110 models Station Wagon Utility
Front axle 1200 Kg (2645 lb)......................................................................... 1200 Kg (2645 lb)
Rear axle 1750 Kg (3858 lb).......................................................................... 1850 Kg (4078 lb)
Gross vehicle weight 2950 Kg (6503 lb)........................................................ 3050 Kg (6724 lb)
130 modelsUtility
Front axle1580 Kg (3483 lb) .....................................................................................................................
Rear axle2200 Kg (4850 lb) ......................................................................................................................
Gross vehicle weight 3500 Kg (7716 lb)....................................................................................................
NOTE: Axle weights are not accumulative. The individual maximum axle weights and gross vehicle
weight must not be exceeded.
EEC VEHICLE KERB WEIGHTS
90 models Standard Heavy Duty
Soft top: 1770 Kg (3402 lb)............................................................................ 1993 Kg (4393 lb)
Pick-up: 1770 Kg (3402 lb)............................................................................ 1993 Kg (4393 lb)
Hard top: 1815 Kg (4001 lb).......................................................................... 1987 Kg (4380 lb)
Station wagon: 1870 Kg - 1885 Kg................................................................. 1989 Kg - 1998 Kg
(4122 lb - 4155 lb) (4385 lb - 4404 lb)
110 models
Soft top: 1885 Kg - 2080 Kg............................................................................ (4155 lb - 4585 lb)
High capacity pick-up: 1920 Kg - 2122 Kg...................................................... (4232 lb - 4678 lb)
Hard top: 1920 Kg - 2110 Kg.......................................................................... (4232 lb - 4651 lb)
Station wagon: 2055 Kg - 2229 Kg................................................................. (4530 lb - 4914 lb)
130 models
Crew cab and high capacity pick-up: 2177 Kg - 2286 Kg...........................................................................
(4667 lb - 5039 lb)
EEC kerb weight = Unladen weight + Full fuel tank + 75 Kg (165 lb).
ProCarManuals.com
Page 34 of 667
GENERAL SPECIFICATION DATA
11
INFORMATION TOWING WEIGHTS
On-road Off-road
Unbraked trailers 750 Kg (1653 lb).............................................................. 500 Kg (1102 lb)
Trailers with overrun brakes 3500 Kg (7716 lb)............................................. 1000 Kg (2204 lb)
4 wheel trailers with coupled brakes * 4000 Kg (8818 lb).............................. 1000 Kg (2204 lb)
NOTE: * Only applies to vehicles modified to accept coupled brakes.
NOTE: All weight figures are subject to local restrictions.
OFF-ROAD PERFORMANCE
90 models
Max. gradient (EEC kerb weight) 45° .....................................
Approach angle:
Soft top and Pick-up (EEC kerb weight) 48° ..................
Hard top and station wagon (EEC kerb weight) 51.5° ......
Departure angle
Soft top and Pick-up (EEC kerb weight) 49° ..................
Hard top and Station wagon (EEC kerb weight) 53° ...............
Wading depth 500 mm (20 in)...................................................................
Min. ground clearance (unladen):
Soft top and pick-up 191 mm (7.5 in).................................................
Hard top and station wagon 229 mm (9.0 in).....................................
NOTE: Departure angles do not account for the addition of a tow hitch.
110 and 130 models
Max. gradient (EEC kerb weight) 45° .....................................
Approach angle (EEC kerb weight) 50° ..................................
Departure angle (EEC kerb weight)
110 models 35° ......................................................................
130 models 34° ......................................................................
Wading depth 500 mm (20 in)...................................................................
Min. ground clearance (unladen 215 mm (8.5 in).......................................
NOTE: Departure angles do not account for the addition of a tow hitch.
ProCarManuals.com
Page 35 of 667
04GENERAL SPECIFICATION DATA
12
INFORMATION TYRE SIZE AND PRESSURES
90 models Front Rear
Normal - all load conditions
205/80 R16 Radial1,9 bar .................................................. 2,6 bar
28 Ibf/in
238 Ibf/in2
2,0 kgf/cm22,7 kgf/cm2
265/75 R16 Radial (multi terrain)1,9 bar .......................... 2,4 bar
28 Ibf/in235 Ibf/in2
2,0 kgf/cm22,5 kgf/cm2
7.50 R16 Radial1,9 bar ...................................................... 2,6 bar
28 Ibf/in238 Ibf/in2
2,0 kgf/cm22,7 kgf/cm2
110 models
Normal - all load conditions
7.50 R16 Radial1,9 bar ...................................................... 3,3 bar
28 Ibf/in
248 Ibf/in2
2,0 kgf/cm23,4 kgf/cm2
130 models
Normal - all load conditions
7.50 R16 Radial3,0 bar ...................................................... 4,5 bar
44 Ibf/in
265 Ibf/in2
3,1 kgf/cm24,6 kgf/cm2
WARNING: Tyre pressures must be
checked with the tyres cold, as the
pressure is about 0,21 bar (3 Ibf/in
2, 0,2
kgf/cm2) higher at running temperature. If the
vehicle has been parked in the sun or high
ambient temperatures, DO NOT reduce the tyre
pressures, move the vehicle into the shade and
wait for the tyres to cool before checking the
pressures.
WHEELS
90 models
Steel wheel size:
Heavy duty - UK and Western Europe 6.5F X 16.............................
Other markets 5.5F X 16..................................................................
Alloy wheel size 7J X 16................................................................
110 models
Steel wheel size:
Heavy duty - UK and Western Europe 6.5F X 16.............................
Other markets 5.5F X 16..................................................................
130 models
Steel wheel size:
Heavy duty - UK and Western Europe 6.5F X 16.............................
Other markets 5.5F X 16..................................................................
WARNING: Always use the same make and
type of radial-ply tyres, front and rear. DO
NOT use cross-ply tyres, or interchange
tyres from front to rear.
If the the wheel is marked’TUBED’, an inner
tube MUST be fitted, even with a tubeless tyre.
If the wheel is marked’TUBELESS’, an inner
tube must NOT be fitted.
ProCarManuals.com
Page 36 of 667
GENERAL SPECIFICATION DATA
13
INFORMATION VEHICLE DIMENSIONS
90 models
Overall length:
Soft top and Pick-up 3722 mm (146.5 in)................................................
Hard top and Station wagon 3883 mm (152.9 in)....................................
Overall width: 1790 mm (70.5 in)...................................................................
Overall height:
Soft top 1965 mm (77.4 in)....................................................................
Pick-up and Station wagon 1963 mm (77.3 in)......................................
Hard top 1972 mm (77.6 in)...................................................................
Wheelbase 2360 mm (92.9 in).......................................................................
Track front/rear 1486 mm (58.5 in).................................................................
Width between wheel boxes 925 mm (36.4 in)............................................
110 models
Overall length:
Soft top and Pick-up 4438 mm (175 in)................................................
High capacity pick-up 4631 mm (182 in)..............................................
Hard top/Station and County 4599 mm (181 in)...................................
Overall width: 1790 mm (70.5 in)...................................................................
Overall height: 2035 mm (80.1 in)..................................................................
Wheelbase 2794 mm (110 in).......................................................................
Track front/rear 1486 mm (58.5 in).................................................................
Width between wheel boxes:
High capacity pick-up 1090 mm (43 in)..............................................
all other models 925 mm (36.4 in).......................................................
130 models
Overall length 5132 mm (202 in)...................................................................
Overall width 1790 mm (70.5 in)....................................................................
Overall height 2035 mm (80.1 in)...................................................................
Wheelbase 3226 mm (127 in).......................................................................
Track front/rear 1486 mm (58.5 in).................................................................
Width between wheel boxes 1090 mm (43 in)............................................
ProCarManuals.com
Page 37 of 667
ProCarManuals.com
Page 38 of 667
05 - ENGINE TUNING DATA
CONTENTS
Page
INFORMATION
ENGINE - Td5 1......................................................................................................
HEATER PLUGS - Td5 1........................................................................................
INJECTORS - Td5 1................................................................................................
TURBOCHARGER - Td5 1.....................................................................................
ProCarManuals.com
Page 39 of 667
ProCarManuals.com
Page 40 of 667
ENGINE TUNING DATA
1
INFORMATION ENGINE - Td5
Type2.5 Litre direct injection Diesel, turbocharged, .................................................................................
intercooled
Firing order1-2-4-5-3 .....................................................................
Injection timingControlled by ECM ...............................................................
Maximum governed speed4850 rev/min ............................................
Maximum overrun speed5460 rev/min ...............................................
Idle speed740±50 rev/min .......................................................................
HEATER PLUGS - Td5
Make & type Beru 12 V......................................................................
Number of plugs Four plugs only, in cylinders 1, 2, 3 and 4...............................................................
INJECTORS - Td5
Injectors
Make/Type Lucas EV1..............................................................
Nominal operating pressure 1500 bar (21750 lbf.in
2) ....................................
TURBOCHARGER - Td5
Make & type Garrett GT 20.....................................................................
ProCarManuals.com