ignition MAZDA PROTEGE 1992 Workshop Manual

h ntnwJu lJlAUc(Arn
. INTERIOR LAMP l SOUND WARNING SYSTEM
QGNITION KEY CYLINDER LAMP
BTN
COURTESY LAMP
(SECTION I-3)
EECTION I-41
-05 IGNITION KEY
IEMINOER SWITCH(F) :
I
M
z-74
I-06 BUCKLE SWITCH (R) I-07 INTERIOR 6 SPOT LAMPtIN)
I-08 DOOR SWITCH FL (R)
SHOULDER BELT
YfOULCER BELT S%XlLOER BELT
WITHOUT SUNROOF WITH SUNROOF SHOULDER BELT
-09 DOOR SWITCH FR (R) I-IO ODOR SWITCH RL(RI I-11 DOOR SWITCH RR(R) D-01 IGNITTON KEY CYLINDER LAMP(F)
M-01 SPOT LAMP {IN)
WITH CRUISE CONTROL
SHOULDER BELT
CRUISE CONTROL
-02 SLIDING SUNROOF M-03 SLIDING SUNROOF
SWITCH MOTOR -

Vs: Battery voltags
Terminal Connecte4t to
Voltage . . . Procedure
a (Output) Actuator ov Ignition switch ON
Approx. 9V Main switch ON
b (Output) Actuator ov Ignition switch ON
Approx. 9V Main switch ON
c (Output) Actuator ov Ignition switch ON
Approx. 9V Main switch ON
d
e (Input) Cruise control main VEI Ignition switch ON
switch (N.C)
f (input) Cruise control main Ve Main switch ON
switch (N.0).
9 Wwft) EC-AT control unit VI3 Ignition switch ON
(only ATX)
h (Output) Stoplight switch 2 (NC) Approx. 9V Main switch ON
i (Input) Inhibitor switch (ATX) ov “N” or “P” range and main switch ON
Note Approx. 5V Other range and main switch ON
Disconnect
EGI control Clutch switch (MTX) ov
Clutch pedal depressed and main switch ON
unit connector Approx. 5V Main switch ON
I (Input) Horn relay VB Horn switch OFF
m (Input) Stoplight switch 1 (N.0) ov Ignition switch ON
VEI
Brake pedal depressed
n (Input) Cruise control switch VE Main switch ON
(Resumelaccel switch) Approx. 9V While pushing the resume/accel switch after main switch
ON
Cruise control switch VEI Main switch ON
(Set/coast switch) Approx. 5V While pushing the set/coast switch after main switch ON
0 (Input) Stoplight switch 2 (N.C) Approx. 9V Main switch ON
ov
Brake pedal depressed
P (Input) Speed sensor Run out
Note While rotating the rear tire
between
O&connect 0-w
EC-AT control
unit connector
q
r
S Battery Vs
Constant
t Ground ov
Constant

. WIIWNU UIAUnA-
iDIAGNOSIS CONNECTOR U
ENGINE
CONTROL UN IT (SECTION B-la. 2a) @-W/Y (SECTION B-la. 2al
ENGINE
CONTROL UNIT
(SECTION
B-la, 2a) *W/B (SECTION B-la. 2a)
U-01 DIAGNOSIS CONNECTOR
IGNITION
COIL
(SECTION
J-01 DIAGNOSIS CONNECTOR (EM)
NOTE: TH-tS IS THE CONNECTOR AS ZEN FROM THE TERMINAL SIDE.
Z-96

DIAGRAM Z
rl PARTS NAME
-
PA ,K
SECTION T
CIGARETTE LIGHTER ............................................
I-1
CIRCUIT OPENING RELAY ..............................
B-l&Pa
I CLUTCH
SWITCH .............................................. B-lc
CONDENSER ................................................. B-la.2a
CONDENSER FAN ..................................................
G
CONDENSER
FAN RELAY ....................................... G
COMBINATION
SWITCH .................................... E-l.2
COOLING FAN MOTOR .....................................
B-3,4
COOLING
FAN RELAY ........................................ B-3,4
COURTESY LAMP ................................................
l-3
CPU .................................................................... l-2
CRUISE CONTROL
MAIN SWITCH ........................... Q
CRUISE
CONTROL SWITCH .................................... Q
CRUISE CONTROL UNIT ......................................... Q 0 ACTUATOR ........................................................... Q
A/C RELAY ........................................................... G
t A/C SWITCH .........................................................
G
t AIRFLOW METER .......................................... B-lc,Pc
t ALTERNATOR .....................................................
A-2
I AUDIO SYSTEM .....................................................
J
@BACK-UP LIGHT .................................................. F-3
BACK-UP LIGHT SWITCH
..................................... F-3
I
BLOWER MOTOR ...................................................
G
h BLOWER SWITCH ..................................................
G
I BRAKE FLUID SWITCH ...........................................
C
BUCKLE SWITCH .............................................
l-2, S
@I DIAGNOSIS CONNECTOR .......................................
U
DIGITAL CLOCK
................................................... l-l
DIODE ..................................................................
G
DISTRIBUTOR ...............................................
B-l b,2b
DOOR CATCH SWITCH .......................................... S
DOOR
SPEAKER ..................................................... J
DOOR SWITCH ....................................................
l-2
DRL CONTROL UNIT ............................................
E-3
DRL RELAY .........................................................
E-3
ORL RESISTOR ....................................................
E-3
ENGINE CONTROL UNIT
.................................... B-1.2
ii@ FLASHER UNIT ....................................................
F-l
FRONT TURN LIGHT ............................................
F-l
FUEL METER
......................................................... C
FUEL
TANK UNIT .......................................... B-la,2a
HAZARD SWITCH ...............................................
F-l _
HEADLIGHT .....................................................
E-l.2
HEADLIGHT RELAY .............................................
E-2
h HIGH
MOUNT STOPLIGHT ....................................
F-2
h HOLD SWITCH .................................................. B-2c
4 HORN .................................................................
F-3
! HORN RELAY
...................................................... F-3
HORN SWITCH ....................................................
F-3
0 IC REGULATOR ..................................................
A-2
-L
T-S INDEX
PARTS NAME SECTION
IGNITER ........................................................ B-la,2a
IGNITION COIL ..............................................
B-la.2a
IGNITION KEY CYLINDER LAMP .............................
l-2
IGNITION KEY REMINDER SWITCH ........................ l-2
ILLUMINATION LAMP
A/C SWITCH ..................................................... l-4
AT SELECT
....................................................... l-4
AUDIO SYSTEM
................................................. l-4
BLOWER SWITCH .............................................
l-4
CIGARETTE LIGHTER
......................................... l-4
CRUISE CONTROL
MAIN SWITCH ....................... l-4
HAZARD SWITCH .............................................
l-4
INSTRUMENT CLUSTER
..................................... l-4
REAR WINDOW DEFROSTER SWITCH
................. l-4
INHIBITOR SWITCH .................................... A-l, B-2c
INJECTOR ....................................................
B-1 b,2b
INSTRUMENT CLUSTER ..........................................
C
INTERIOR & SPOT LAMP .......................................
l-2
ISC VALVE ...................................................
B-1 b,26
@ LICENSE PLATE LIGHT .........................................
E-4
LIMIT SWITCH .......................................................
S
481 MAGNETIC
CLUTCH .............................................. G
MAIN RELAY (FUEL INJ) ................................
B-la,Pa
@ NEUTRAL SWITCH ............................................
B-lc
@ OIL PRESSURE SWITCH ..........................................
C
OXYGEN SENSOR ......................................... B-la.2a
@ PANEL LIGHT CONTROL .......................................
l-4
PARKING BRAKE SWITCH ......................................
C
PASSIVE SHOULDER BELT CONTROL UNIT
.............. S
PASSIVE SHOULDER BELT
MOTOR .......................... S
POSITION LIGHT .................................................
E-4
POWER DOOR LOCK MOTOR
............................... K-2
POWER DOOR LOCK RELAY
................................. K-2
POWER DOOR LOCK SWITCH
.............................. K-2
POWER
OUTSIDE MIRROR ...................................... L
POWER OUTSIDE MIRROR MOTOR
.......................... L
POWER OUTSIDE MIRROR SWITCH .........................
L
POWER STEERING PRESSURE SWITCH ........... B-l b.2b
POWER WINDOW MAIN SWITCH .........................
K-l
POWER WINDOW MOTOR ...................................
K-l
POWER WINDOW SWITCH
.................................. K-l
@ REAR TURN LIGHT ..............................................
F-l
REAR SiDE MARKER LIGHT ..................................
E-4
REAR
SPEAKER ......................................................
J
REAR WASHER MOTOR ......................................
D-3
REAR WINDOW DEFROSTER
................................. I-1
REAR WINDOW DEFROSTER SWITCH ....................
I-1
REAR WIPER MOTOR
.......................................... D-3
REAR WIPER & WASHER SWITCH
........................ D-3
REFRIGERANT PRESSURE SWITCH
.......................... G
RESISTOR ASSEMBLY ............................................
G