bonnet Peugeot 3008 Hybrid 4 2012 User Guide
[x] Cancel search | Manufacturer: PEUGEOT, Model Year: 2012, Model line: 3008 Hybrid 4, Model: Peugeot 3008 Hybrid 4 2012Pages: 284, PDF Size: 55.64 MB
Page 162 of 284
CHECKS
160
BONNET
)
Push the exterior safety catch B
to
the left and raise the bonnet.
)
Unclip the stay C
from its housing.
)
Fix the stay in the notch to hold the
bonnet open.
Closing
)
Take the stay out of the support
notch.
)
Clip the stay in its housing.
)
Lower the bonnet and release it at
the end of its travel.
)
Pull on the bonnet to check that it is
secured correctly.
Opening
The location of the interior
bonnet release lever prevents
opening of the bonnet while
the front left door is closed.
Do not open the bonnet in high
winds.
When the engine is hot, handle the
exterior safety catch and the bonnet
stay with care (risk of burns).
Before doing anything under
the bonnet, switch off the igni-
tion ( Ready
lamp off) to avoid
any risk of injury resulting from auto-
matic operation of the engine.
)
Open the front left door.
)
Pull the interior bonnet release le-
ver A
, located at the bottom of the
door aperture.
Never touch, handle or remove
the orange "high voltage" cables.
Page 163 of 284
CHECKS
161
RUNNING OUT OF FUEL
(DIESEL)
2 litre HDi engine
)
Fill the fuel tank with at least fi ve li-
tres of Diesel.
)
Open the bonnet.
)
Unclip the style cover for access to
the priming pump.
)
Slacken the bleed screw.
)
Squeeze and release the priming
pump repeatedly until fuel appears
in the transparent pipe with the
green connector.
)
Tighten the bleed screw.
)
Operate the starter until the engine
starts.
)
Put the style cover back in position
and clip it in place, ensuring that it
has clipped correctly.
)
Close the bonnet.
Before doing anything under
the bonnet, switch off the igni-
tion ( Ready
lamp off) to avoid
any risk of injury resulting from auto-
matic operation of the engine.
On vehicle fi tted with HDi engines, the
fuel system must be primed if you run
out of fuel; refer to the engine compart-
ment view on the "Diesel engine" page.
If the tank on your vehicle is fi tted with
a misfuel prevention device, refer to the
section "Access - § Misfuel prevention
(Diesel)".
If the engine does not start fi rst
time, don't keep trying. Start
the procedure again from the
beginning.
Page 165 of 284
CHECKS
163
CHECKING LEVELS
Oil specifi cation
Oil level
The check is carried out either
when the ignition is switched on
using the oil level indicator on the
instrument panel, or using the dip-
stick.
This manual check will only be correct if the
vehicle is on level ground and the engine
has been off for more than 30 minutes.
After topping up the oil, the check when
switching on the ignition with the oil level
indicator in the instrument panel will only
be valid 30 minutes after topping up. The oil must be the correct
grade for your engine and con-
form to the manufacturer's rec-
ommendations.
Brake fluid level
The brake fl uid level should be close to
the "MAX" mark. If it is not, check the
brake pad wear.
Power steering fluid level
The power steering fl uid level
should be close to the "MAX"
mark. Unscrew the cap, with the
engine cold, to check the level.
It is normal to top up the oil level
between services. PEUGEOT
recommends that you check
the oil level and top up if necessary ev-
ery 3 000 miles (5 000 kilometres).
Engine oil change
Refer to the servicing booklet for details
of the interval for this operation.
In order to maintain the reliability of the
engine and emission control system,
the use of additives in the engine oil is
prohibited.
Changing the fl uid
Refer to the servicing booklet for details
of the interval for this operation. In addition, as the cooling system is
pressurised, wait at least one hour after
switching off the engine before carrying
out any work.
To avoid any risk of scalding, unscrew
the cap by two turns to allow the pres-
sure to drop. When the pressure has
dropped, remove the cap and top up
the level.
Coolant level
The coolant level should be
close to the "MAX" mark but
should never exceed it.
When the engine is warm, the
temperature of the coolant is regulated
by the fan. This can operate with the ig-
nition off.
On vehicles which are fi tted with a par-
ticle emission fi lter, the fan may oper-
ate after the vehicle has been switched
off, even if the engine is cold.
Changing the coolant
The coolant does not have to be
changed.
When working under the bon-
net, take care, as certain ar-
eas of the engine may be
extremely hot (risk of burns).
Before doing anything under
the bonnet, switch off the igni-
tion ( Ready
lamp off) to avoid
any risk of injury resulting from auto-
matic operation of the engine.
Check all of these levels regularly and
top them up if necessary, unless other-
wise indicated.
If a level drops signifi cantly, have the corre-
sponding system checked by a PEUGEOT
dealer or a qualifi ed workshop.
Fluid specifi cation
The coolant must conform to the manu-
facturer's recommendations.
Screenwash and headlamp
wash fluid
In the case of vehicles fi tted
with headlamp washers, the
low fl uid level is indicated by an
audible signal and a message
in the instrument panel screen.
Top up the reservoir when you stop the
vehicle.
Fluid specifi cation
The brake fl uid must conform to the
manufacturer's recommendations and
meet the DOT4 standard.
Page 166 of 284
CHECKS
164
Dust filter/Anti-odour filter
(activated carbon)
Your vehicle is fi tted with a fi lter which
traps certain dust and limits odours in
the ventilation and air conditioning.
Refer to the servicing booklet for its re-
placement interval.
Do not hesitate to change it if you notice
unpleasant odours, contact a PEUGEOT
dealer or a qualifi ed workshop.
A clogged passenger compartment fi lter
may reduce the performance of the air
conditioning system and produce un-
pleasant odours. Avoid prolonged contact of
used oil or fl uids with the skin.
Most of these fl uids are harm-
ful to health or indeed very
corrosive.
Do not discard used oil or fl u-
ids into sewers or onto the
ground.
Take used oil to a PEUGEOT
dealer or a qualifi ed workshop
(France) or to an authorised waste
disposal site.
Diesel additive level (Diesel engine
with particle emission filter)
The additive reservoir low level is indi-
cated by fi xed illumination of this warn-
ing lamp, accompanied by an audible
warning and a message in the multi-
function screen.
Used products
CHECKS
12 V battery
The battery does not require
any maintenance.
However, check that the ter-
minals are clean and correctly
tightened, particularly in sum-
mer and winter.
When carrying out work on the battery,
refer to the "Practical information" sec-
tion for details of the precautions to be
taken before disconnecting the battery
and following its reconnection.
Air filter
Refer to the Warranty and
Maintenance Record for de-
tails of the replacement inter-
vals for these components.
Depending on the environment (e.g. dusty atmosphere) and the use of
the vehicle (e.g. city driving), replace
them twice as often if necessary
(refer to the "Engines" paragraph).
Oil filter
Replace the oil fi lter each time
the engine oil is changed.
Refer to the Warranty and
Maintenance Record for de-
tails of the replacement inter-
val for this component.
Topping up
This additive must be topped up by a
PEUGEOT dealer or a qualifi ed work-
shop without delay.
Unless otherwise indicated, check
these components in accordance with
the Warranty and Maintenance Record.
Otherwise, have them checked by a
PEUGEOT dealer.
Before doing anything under
the bonnet, switch off the igni-
tion ( Ready
lamp off) to avoid
any risk of injury resulting from auto-
matic operation of the engine.
Fluid specifi cation
For optimum cleaning and to avoid
freezing, this fl uid must not be topped
up with or replaced with plain water.
Page 188 of 284
PRACTICAL INFORMATION
186
12 V BATTERY
Procedure for charging your battery
when it is fl at or for starting the engine
using another battery.
Access to the battery
The battery is located under the bonnet.
To gain access to it:
)
open the bonnet using the interior
release lever, then the exterior safe-
ty catch,
)
secure the bonnet stay,
)
remove the plastic cover to gain ac-
cess to the two terminals,
)
unclip the fusebox to remove the
battery, if necessary.
Disconnecting the cables
)
Raise the locking tab fully.
Reconnecting the cables
)
Position the open clip 1
of the cable
on the positive terminal (+) of the
battery.
)
Press vertically on the clip 1
to posi-
tion it correctly against the battery.
)
Lock the clip by spreading the position-
ing lug and then lowering the tab 2
.
Do not force the tab as locking
will not be possible if the clip is
not positioned correctly; start
the procedure again.
Before doing any work on your
vehicle, switch off the ignition
( Ready
lamp off) to avoid any
risk of injury resulting from automatic
operation of the engine.
Your vehicle is fi tted with a conventional
12 V battery, located under the bonnet,
in addition to the high voltage battery
used by the hybrid system.
In certain conditions, if the 12 V battery
is too discharged to activate the hybrid
system, recharging from another con-
ventional 12 V battery is possible.
Do not carry out this recharge if the
Ready
lamp is on.
Page 202 of 284
TECHNICAL DATA
200
IDENTIFICATION MARKINGS
Various visible markings for the identifi -
cation and tracing of your vehicle.
If the tyre pressures are too
low, this increases fuel con-
sumption.
The tyre pressures must be
checked when the tyres are
cold, at least once a month.
A.
Vehicle Identifi cation Number (VIN)
under the bonnet.
This number is engraved on the
bodywork near the damper support.
B.
Vehicle identifi cation Number (VIN)
on the windscreen lower cross-
member.
This number is indicated on a self-
adhesive label which is visible
through the windscreen.
C.
Manufacturer's label.
The VIN is indicated on a self-de-
stroying label affi xed to the door ap-
erture, on the driver's side.
D.
Tyre/paint label.
This label is affi xed to the door aper-
ture, on the driver's side.
It bears the following information:
- the tyre infl ation pressures with and
without load,
- the wheel rim and tyre sizes,
- the brands of tyre recommended by
the manufacturer,
- the infl ation pressure of the spare
wheel,
- the paint colour code.
The use of snow chains is
only authorised on the front
wheels.
The selector must be in 4WD mode.
Page 274 of 284
ALPHABETICAL INDEX
272
Accessories ........................194, 195
Accessory socket,
12 volt ...................... 107, 109, 115
Adjusting headlamps ..................100
Adjusting head
restraints ....................................75
Adjusting seat belt
height .......................................132
Adjusting the steering
wheel .........................................79
Airbags .........................................53
Airbags, curtain...................137, 138
Airbags, front ......................135, 138
Airbags, lateral....................137, 138
Air conditioning .............................37
Air conditioning, digital............69, 70
Air conditioning, manual ...............69
Air fi lter .......................................164
Air fl ow ..........................................37
Air vents........................................68
Alarm ............................................87
Anti-pinch.............................. 89, 113
Anti-theft .......................................84
Armrest .......................................107
Armrest, front ..............................109
Armrest, rear ............................... 112
Assistance call ............................202
Audible warning ..........................129
Audio/video sockets....................232
Audio streaming
(Bluetooth) ...............................261
Audio systems ..............................64
Automatic illumination
of headlamps .....................97, 100
Automatic operation of hazard
warning lamps .........................129
Automatic rain sensitive
windscreen wipers ...........101, 103
Auxiliary
sockets ................... 232, 256, 258Battery ................... 40, 79, 164, 186
Battery, charging .........................186
Battery, remote control ...........85, 86
Blind for panoramic sunroof........ 113
Blinds .......................................... 117
Bluetooth
(hands-free) ............. 233-235, 259
Bluetooth (telephone) ......... 233-235
Bonnet ........................................160
Bonnet stay.................................160
Boot fl oor, adjustable .................. 115
Boot lamp ...................................106
Boot lid..........................................94
Brake discs .................................165
Brake lamps................................177
Brake pads .................................165
Brakes ........................................165
Capacity, fuel tank ........................95
CD MP3 ......................................255
Central locking ........................83, 92
Changing a bulb ........ 175, 177, 178
Changing a fuse .........................179
Changing a wheel .......................172
Changing a wiper blade ......103, 190
Changing the date ..............238, 263
Changing the remote
control battery ............................85
Changing the time ..............238, 263
Checking levels ..................163, 164
Checking the engine oil level ........57
Checking tyre pressures
(using the kit) ...........................166
Checks....................... 162, 164, 165
Child lock ....................................128
Children ..................... 123, 126, 127
Child seats .......................... 118, 124Child seats, conventional....121, 123
Child seats, Isofi x .......................127
Closing the boot................83, 93, 94
Closing the doors....................83, 91
Cold climate screen ....................193
Colour screen, retractable ......62, 64
Connectors,
audio ............... 108, 109, 256, 258
Control for panoramic
sunroof blind ............................ 113
Coolant level .........................54, 163
Coolant temperature indicator ......54
Courtesy lamps...........................104
Courtesy mirror ...........................108
Cruise control .............................151
Cup holder ..................................107
AB
C
Date (setting) ............. 238, 262, 263
Daytime running lamps .................99
Deactivating ESP ........................131
Deactivating
the passenger airbag ...............135
Deadlocking ..................................83
Defrosting ...............................69, 80
Dials and gauges ..........................44
Diesel............................................36
Diesel additive level ....................164
Dimensions .................................199
Dipped beam ........................97, 175
Dipstick .................................57, 163
Direction indicators .............129, 177
Doors ............................................91
Doors emergency control .............93
Door trays ...................................107
Dynamic emergency braking ......142
Dynamic stability control
(DSC) ...................................49, 52
D
Page 276 of 284
ALPHABETICAL INDEX
274
Main beam ....................................97
Maintenance .................................37
Map reading lamps .....................104
Markings, identifi cation ...............200
Mat.............................................. 110
Menu, main .................................252
Mini fuel level ................................95
Mirror, rear view ............................81
Mirrors, door .................................80
Misfuel prevention ........................96
Motorway function
(direction indicators) ................129
Mountings for ISOFIX seats .......125
MP3 CD ......................................255
Multimedia, rear .......................... 111
Music media players ...................228Oil fi lter .......................................164
Oil level .................................57, 163
Opening the bonnet ....................160
Opening the boot ....................82, 93
Opening the doors ..................82, 91
Opening the panoramic
sunroof blind ............................ 113
Opening the retractable
screen ........................................64
Opening
the tailgate ...........................93, 94
Operation indicator
lamps ...................... 46, 48, 49, 51 Navigation...................................216
Niveau mini carburant...................52
Number plate lamps ...................178
Radio ..................................227, 253
RCA sockets ...............................232
Reading lamps, rear ...................104
Rear foglamp ......................177, 178
Rear screen (demisting) .........69, 80
Recharging the battery ...............186
Reduction of electrical load ........189
Reinitialising the electric windows ...89
Reinitialising the remote control ...85
Remote control .................82, 83, 86
Removable screen
(snow shield) ...........................193
Removing a wheel ......................173
Removing the mat ...................... 110
Repair kit, puncture ....................166
Replacing bulbs ......... 175, 177, 178
Replacing fuses ..........................179
Replacing the air fi lter .................164
Replacing the oil fi lter .................164
Replacing the particle emission fi lter ...165 Level, brake fl uid ........................163
Level, headlamp wash ........102, 163
Level, power steering
fl uid ..........................................163
Levels and checks .............. 162-164
Lighting .......................................106
Lighting, guide-me home ......99, 100
Lighting, interior ..................104, 105
Lighting bulbs
(replacement) ......... 175, 177, 178
Lighting control stalk .....................97
Lighting dimmer ............................58
Loading .................................37, 193
Load reduction mode ..................189
Load space cover ....................... 116
Locating your vehicle ....................83
Locking from the inside.................92
Long objects, transporting .... 76, 112
Luggage retaining strap .............. 114Peugeot Connect Media
Navigation (NG4 3D) ....45, 62, 65,
205, 208, 211, 239
Peugeot Connect Sound
(RD5) ................ 59, 249, 264, 266
PEUGEOT services ....................203
PIN code .....................................236
Player,
CD MP3 ...................................255
POIs (updating) ..........................223
Port, USB................... 109, 256, 258
Priming the fuel
system .....................................161
Protecting
children .....118, 123, 125-127, 135
Puncture .....................................166
MON
R
Paint colour code ........................200
Panoramic glass
sunroof ..................................... 113
Parking brake .............................165
Parking brake, electric ........139, 142
Parking sensors,
front .........................................158
Parking sensors,
rear ..........................................157
Particle emission
fi lter ..................................164, 165
Passenger compartment
fi lter ..........................................164
PEUGEOT call button .................203
P
Page 280 of 284
VISUAL SEARCH
278
Courtesy lamps................... 104, 105
Seat belt/passenger's front airbag
warning lamps display ...... 133, 136
Rear view mirror ........................... 81
INSTRUMENTS AND CONTROLS
Dashboard
fuses ......................... 179, 180-182
Electronic gear
control gearbox ................. 153-156
Hill start
assist ................................. 144-146
Peugeot Connect Sound ... 249-271
Setting the date/time .... 262
Sun visor..................................... 108
Opening the bonnet .................... 160
Electric parking
brake ..................139-143, 145-146
Interior fi ttings ...................... 107-110
- glove box
- driver's storage compartments
- mat
12 V accessory socket................ 109
Peugeot Connect Media Navigation (NG4 3D) ... 205-248
Setting the date/time .... 238
Ventilation ................................ 68-69
Digital air conditioning ............. 70-72
Front armrest .............................. 109
Peugeot Connect USB ............... 109
Page 282 of 284
VISUAL SEARCH
280
TECHNICAL DATA - MAINTENANCE
Identifi cation markings ................ 200
Running out of fuel, Diesel ......... 161
Checking levels ................... 163-164
- oil
- brake fl uid
- power steering fl uid
- coolant
- screenwash/headlamp wash fl uid
Checking components ......... 164-165
- battery
- air fi lter
- particle emissions fi lter
- passenger compartment fi lter
- oil fi lter
- brake pads/discs
Changing bulbs.................... 175-178
- front
- rear
Batteries .............................. 186-188
Load reduction, economy mode .... 189
Engine compartment fuses ........ 179,
183-185
Opening the bonnet .................... 160
Under the bonnet, Diesel ............ 162
Electric motor.............................. 196
Diesel engine .............................. 197
Dimensions ................................. 199
Diesel weights ............................ 198
High voltage cables ................. 41-42