fuel cap Peugeot RCZ 2014 Owner's Manual

63150
6
RCZ_EN_CHAP00B_PRISE EN MAIN_ED02-2013
1. Unlocking and partial opening of the boot lid.
2. Open the boot lid.
For access to the fuel fi ller cap, the vehicle must be unlocked.
1. Open the fuel fi ller fl ap by pressing at its rear edge.
2. Remove the fuel fi ller cap by unscrewing it and hook it on to the back of the fi ller fl ap.
Capacity of the tank: approximately 55 litres.
FUEL TANK
BOOT
1. Partial opening of the boot lid.
2. Open the boot lid.
Vehicle locked
Vehicle unlocked

28
Engine
autodiagnosis
system
fl ashing.
The engine management system
has a fault. Risk of destruction of the catalytic converter.
Have it checked by a PEUGEOT dealer or a qualifi ed
workshop.
fi xed. The emission control system has
a fault. The warning lamp should go off when the engine is started.
If it does not go off, contact a PEUGEOT dealer or qualifi ed
workshop without delay.
Low fuel level fi xed with the
needle in the
red zone,
accompanied by
an audible signal
and a message.
When it fi rst comes on there
remains approximately
5 litres of
fuel in the tank.
At this point, you begin to use the
fuel reserve. Refuel as soon as possible to avoid running out of fuel.
Until suffi cient fuel has been added, this warning lamp
will come on every time the ignition is switched on,
accompanied by an audible signal and a message.
The audible signal and message are repeated with
increasing frequency as the fuel level drops towards
"0" .
Fuel tank capacity: approximately 55 litres .
Never continue to drive until you run out of fuel, as this
could damage the emission control and injection systems.
Warning lamp
is on Cause Action / Observations
Service on temporarily.
A minor fault has occurred for
which there is no specifi c warning
lamp. Identify the fault by reading the message shown in the
screen, such as, for example:
- opening of the doors, boot or bonnet,
- low engine oil level,
- low screenwash level,
- fl at remote control battery,
- saturation of the particle emission fi lter (Diesel)
As soon as traffi c conditions permit, regenerate the
fi lter by driving at a speed of at least 36 mph (60 km/h)
until the service warning lamp goes off.
- a fault with the tyre under-infl ation detection system,
- ...
For any other faults, contact a PEUGEOT dealer or a
qualifi ed workshop.
fi xed. A major fault has occurred for
which there is no specifi c warning
lamp. Identify the fault by reading the message shown on the
screen and contact a PEUGEOT dealer or a qualifi ed
workshop.

62
Pressing the central locking control unlocks the vehicle.
Opening a door from the inside, when stationary, also unlocks the
vehicle, but the vehicle will be locked again when the speed exceeds
6 mph (10 km/h).
Activation / Deactivation
You can activate or deactivate this function.
 With the ignition on, press the button for more than two seconds.
A confi rmation message appears in the screen.
EMERGENCY LOCKING
To lock or unlock the doors mechanically in the event of a central
locking system failure or fl at battery.
Locking the driver's door
 Insert the key in the lock, then turn it to the right.
Unlocking the driver's door
 Insert the key in the lock, then turn it to the left.
Locking the passenger door
 Using the key, remove the black cap on the edge of the door.
 Insert the key in the cavity without forcing, then without turning it, move the the latch sideways towards the interior of the door.
 Remove the key and refi t the cap.
Unlocking the passenger door
 Pull the interior door opening control.
ANTI-INTRUSION SECURITY
This function permits automatic and simultaneous locking of the doors,
boot lid and fuel fi ller fl ap as soon as the vehicle speed exceeds 6 mph
(10 km/h).
Operation
If one of the doors is open, the automatic central locking does not take\

place.
If the boot lid is open, the automatic central locking of the doors is
active.

150
FUEL TANK
Fuel tank capacity: approximately 55 litres.
LOW FUEL LEVEL
FILLING
When the fuel tank minimum level is reached this warning
lamp comes on on the instrument panel, accompanied by an
audible signal and an alert message. When it fi rst comes on
there remains approximately 5 litres of fuel in the tank.
Until suffi cient fuel is added, this warning lamp appears every time
the ignition is switched on, accompanied by an audible signal and a
message. When driving, this audible signal and display of the alert
message are repeated with increasing frequency as the fuel level drops
towards "0" .
Refuel as soon as possible to avoid running out of fuel.
If you run out of fuel (Diesel), refer also to the "Running out of fue\
l
(Diesel)" section.
A label affi xed to the inside of the fl ap reminds you of the type of fuel to
be used depending on your engine.
Additions of fuel must be of at least 5 litres, in order to be registere\
d by
the fuel gauge. To fi ll the tank in complete safety:
 the engine must be switched off,

 press the rear part of the fl ap, then raise it to open it,
 turn the cap to the left,
 remove the cap and hook it onto the clip located on the inside of the fl ap,
 fi ll the tank, but do not continue after the 3rd cut-off of the
pump ; this could cause malfunctions.
Opening the fi ller cap may create a noise a caused by an inrush
of air. This vacuum is entirely normal, resulting from the sealing of
the fuel system.

7/
CHECKS
QUALITY OF THE FUEL USED FOR PETROL
ENGINES
The petrol engines are perfectly compatible with E10 or E24 type petrol \
biofuels (containing 10 % or 24 % ethanol), conforming to European
standards EN 228 and EN 15376.
E85 type fuels (containing up to 85 % ethanol) are reserved exclusivel\
y
for vehicles marketed for the use of this type of fuel (BioFlex vehicle\
s).
The quality of the ethanol must comply with European standard
EN 15293.
For Brazil only, special vehicles are marketed to run on fuels containing
up to 100 % ethanol (E100 type).
QUALITY OF THE FUEL USED FOR DIESEL
ENGINES
The Diesel engines are perfectly compatible with biofuels which
conform to current and future European standards (Diesel fuel which
complies with standard EN 590 mixed with a biofuel which complies
with standard EN 14214) available at the pumps (containing up to
7 % Fatty Acid Methyl Ester).
The B30 biofuel can be used in certain Diesel engines; however, this
use is subject to strict application of the special servicing conditions\
.
Contact a PEUGEOT dealer or a qualifi ed workshop.
The use of any other type of (bio)fuel (vegetable or animal oils, pur\
e
or diluted, domestic fuel...) is strictly prohibited (risk of damage t\
o the
engine and fuel system).
When you have fi lled the tank:
 put the cap back in place,
 turn it to the right,
 close the fl ap.
Freezing conditions
In these conditions, the fi ller fl ap may be jammed.
Opening the boot gives access to the fl ap, allowing it to be
released by hand.

154
DIESEL ENGINE
The various caps and covers allow access for checking the levels of the various fl uids, for replacing certain components and for priming the fuel system.
1. Power steering reservoir.
2. Screenwash and headlamp wash reservoir.
3. Coolant reservoir.
4. Brake fl uid reservoir.
5. Battery / Fuses.
6. Fusebox. 7. Air fi lter.
8. Engine oil dipstick.
9. Engine oil fi ller cap.
10. Priming pump.
11 .
Bleed screw.

F0
158
DIESEL FUEL ADDITIVE LEVEL (DIESEL WITH
PARTICLE EMISSIONS FILTER)
The additive reservoir low level is indicated by fi xed illumination
of this warning lamp, accompanied by an audible signal and
a message that the particle emissions fi lter additive level is
too low.
Topping up
The reservoir must be topped up without delay by a PEUGEOT dealer
or a qualifi ed workshop.
USED PRODUCTS
Avoid prolonged contact of used oil or fl uids with the skin.
Most of these fl uids are harmful to health or indeed very corrosive.
Do not discard used oil or fl uids into sewers or onto the ground.
Take used oil to a PEUGEOT dealer or a qualifi ed workshop
(France) or to an authorised waste disposal site.
COOLANT LEVEL
The coolant level should be close to the "MAX" mark but
should never exceed it.
When the engine is warm, the temperature of the coolant is regulated
by the fan.
In addition, as the cooling system is pressurised, wait at least one hou\
r
after switching off the engine before carrying out any work.
To avoid any risk of scalding, unscrew the cap by two turns to allow the \
pressure to drop. When the pressure has dropped, remove the cap and
top up the level. The cooling fan may start after switching off the engine: take
care with articles and clothing that might become caught by the
fan blades.
Fluid specification
The coolant must conform to the manufacturer's recommendations.
SCREENWASH AND HEADLAMP WASH FLUID
In the case of vehicles fi tted with headlamp washers, the low
fl uid level is indicated by an audible signal and a message in
the instrument panel screen.
Top up the reservoir when you next stop the vehicle.
Fluid specification
For optimum cleaning and to avoid freezing, this fl uid must not be
topped up with or replaced with plain water.
In wintry conditions, the use of an ethyl alcohol or methanol base fl uid is
recommended.

9/
TECHNICAL DATA
Engines 1.6 litre THP
150 hp 1.6 litre THP 156 hp 1.6 litre THP
163 hp 1.6 litre THP
200 hp 1.6 litre THP
270 hp
Gearboxes Automatic
(6-speed) Manual
(6-speed) Automatic
(6-speed) Automatic
(6-speed) Manual
(6-speed) Manual
(6-speed)
Model codes:
4J... 5FE-J
5FV-8 5FV-A 5FM-J 5FU-8 5FGM
Cubic capacity (cc) 1 598 1 598 1 598 1 598 1 598
Bore x stroke (mm) 77 x 85.8 77 x 85.8 77 x 85.8 77 x 85.8 77 x 85.8
Max power: EU standard (kW) * 110 115 120 147 199
Max power engine speed (rpm) 6 050 6 000 6 000 5 500 6 000
Max torque: EU standard (Nm) 240 240 240 275 330
Max torque engine speed (rpm) 1 400 1 400 1 400 1 700 1 900
Fuel Unleaded Unleaded Unleaded Unleaded Unleaded
Catalytic converter Yes Yes Yes Yes Yes
Engine oil capacity (in litres)
(with fi lter replacement) 4.25
4.25 4.25 4.25 -
PETROL ENGINES AND GEARBOXES
* The maximum power quoted is the type approved value obtained on a test bed, under the conditions defi ned in European legislation
(directive 1999/99/CE).

9/
TECHNICAL DATA
Engine 2.0 litre HDi 163 hp
Gearbox Manual
(6-speed)
Model codes:
4J... RHH-8

Cubic capacity (cc) 1 997
Bore x stroke (mm) 85 x 88
Max power: EU standard (kW) * 120
Max power engine speed (rpm) 3 750
Max torque: EU standard (Nm) 340
Max torque engine speed (rpm) 2 000
Fuel Diesel
Catalytic converter Yes
Particle emission fi lter Yes
Engine oil capacity (in litres)
(with fi lter replacement) -
DIESEL ENGINE AND GEARBOX
* The maximum power quoted is the type approved value obtained on a test bed, under the conditions defi ned in European legislation
(directive 1999/99/CE).

ALPHABETICAL INDEX
ALPHABETICAL INDEX
ABS and EBFD systems..................103
Accessories ..................................... 199
Accessory socket, 12V ...................... 83
Access to rear seats .......................... 72
Active bonnet ................................... 106
Adjusting headlamps .........................95
Adjusting the steering wheel ..............68
Airbags ............................................. 11 3
Airbags, front ............................ 114, 117
Airbags, lateral .......................... 115, 117
Air conditioning .................................. 20
Air conditioning, automatic ..........74, 75
Air fi lter ............................................ 159
Air fl ow ............................................... 20
Air vents............................................. 73
Alarm ................................................. 55
Alert / warning log .............................. 46
Alloy wheels..................................... 198
Anti-lock braking system (ABS) .......103
Anti-pinch ........................................... 58
Anti-theft .......................................... 129
Arches, aluminium ...........................197
Armrest, front ..................................... 84
Ashtray .............................................. 83
Assistance call .................102, 207, 208
Audible warning ............................... 102
Audio streaming (Bluetooth) ....295, 322
Audio systems .................................. 2 11
Audio/video sockets .........................238
Automatic illumination of headlamps ............................ 90, 93
Automatic operation of hazard warning lamps ............................... 101Automatic rain sensitive windscreen
wipers ....................................... 97, 99
Auxiliary sockets ............ 85, 238, 286, 317, 319A/ A/
Battery ..................................... 159, 176
Battery, charging .............................. 177
Battery, remote control ................ 53, 54
Bluetooth (hands-free) ..................239, 277, 320
Bluetooth (telephone) ......239, 277, 320
Bodywork ......................................... 197
Bonnet ............................................. 152
Boot ................................................... 63
Boot lamp .......................................... 88
Boot (opening) ................................... 51
Brake discs ...................................... 160
Brake lamps............................. 181, 184
Brake pads ...................................... 160
Braking assistance system ..............103
Capacity, fuel tank ........................... 150
CD MP3 ........................... 234, 292, 316
Central locking ............................. 52, 61
Changing a bulb .......................178-185 DAB (Digital Audio
Broadcasting) ................290, 314, 315
Date (setting) ......................... 45, 47, 49B/
C/
D/
Changing a fuse .......................186-192
Changing a wheel .....................168-172
Changing a wiper blade ...........100, 174
Changing the remote control battery .... 53
Changing the time ...........38, 45, 47, 49
CHECK .............................................. 37
Checking levels ........................ 156-158
Checking the engine oil level .....33, 156
Checking tyre pressures (using the kit) ................................ 167
Checks...................................... 153-160
Children ..................... 112, 118, 124-128
Child seats ............................... 118-128
Cleaning (advice) ............................. 197
Clock.................................................. 38
Closing the boot ........................... 52, 63
Closing the doors .........................52, 60
Colour screen, retractable .....46, 48, 50
Connectors, audio ............... 85, 238, 286, 317, 319
Coolant level .............................. 33, 158
Coolant temperature indicator ...........33
Courtesy mirror .................................. 82
Cruise control .................................. 143
Cup holder ......................................... 81
Customising stickers........................ 197C/