wheel RENAULT KANGOO 1997 KC / 1.G Chassis Owner's Guide

RENAULT KANGOO 1997 KC / 1.G Chassis Owner's Guide KANGOO 1997 KC / 1.G RENAULT RENAULT https://www.carmanualsonline.info/img/7/1734/w960_1734-0.png RENAULT KANGOO 1997 KC / 1.G Chassis Owner's Guide

Page 53 of 105

RENAULT KANGOO 1997 KC / 1.G Chassis Owners Guide STEERING ASSEMBLY
Axial ball joint
36
Put the vehicle on a two post lift.
REMOVAL
Disconnect the track rod end using tool T.Av. 476.
Slacken the bolt on the parallelism adjustment
sleeve and slacken t

Page 55 of 105

RENAULT KANGOO 1997 KC / 1.G Chassis Owners Guide STEERING ASSEMBLY
Manual steering rack
36
Put the vehicle on a two post lift.
REMOVAL
Remove the front wheels.
Cut the rubber gaiter retaining clip and push the
gaiter back towards the bulkhead.
Disco

Page 56 of 105

RENAULT KANGOO 1997 KC / 1.G Chassis Owners Guide STEERING ASSEMBLY
Power assisted steering rack
36
SPECIAL TOOLING REQUIRED
Mot. 453-01 Hose clamp pliers
T.Av. 476 Ball joint extractor
Wheel bolts 9
Track rod end nut 3.7
Steering rack mounting bolt

Page 57 of 105

RENAULT KANGOO 1997 KC / 1.G Chassis Owners Guide STEERING ASSEMBLY
Power assisted steering rack
36
Disconnect the high and low pressure pipes on the
steering rack (take precautions to catch the oil)
and the nut on the pipe retaining bracket.
Remove:

Page 62 of 105

RENAULT KANGOO 1997 KC / 1.G Chassis Owners Guide STEERING ASSEMBLY
          Manual steering assistance pump
36
SPECIAL TOOLING REQUIRED
Mot. 453-01Hose clamp pliers
Put the vehicle on a two post lift.
REMOVAL
Remove:
- the right hand wheel,
- the r

Page 64 of 105

RENAULT KANGOO 1997 KC / 1.G Chassis Owners Guide STEERING ASSEMBLY
Steering column
36
TIGHTENING TORQUES (in daN.m)
REMOVAL
Disconnect the battery.
Set the vehicle wheels straight.
Remove the steering wheel in the following
manner.
Without airbag op

Page 65 of 105

RENAULT KANGOO 1997 KC / 1.G Chassis Owners Guide STEERING ASSEMBLY
Steering column
36
If the switch is being replaced, the new part is
supplied ready-centred, held in place by an
adhesive label which tears off when the steering
wheel is moved for th

Page 68 of 105

RENAULT KANGOO 1997 KC / 1.G Chassis Owners Guide STEERING ASSEMBLY
Steering column
36
IMPORTANT : if these instructions are not
followed exactly the system may not operate
normally and could even be triggered incorrectly.
IMPORTANT 
Before reconnect

Page 76 of 105

RENAULT KANGOO 1997 KC / 1.G Chassis Owners Guide MECHANICAL ELEMENT CONTROLS
Handbrake control
37
ADJUSTMENT
Incorrect adjustment of the handbrake where the
cable is too tight:
- prevents the correct operation of the automa-
tic compensation system

Page 77 of 105

RENAULT KANGOO 1997 KC / 1.G Chassis Owners Guide MECHANICAL ELEMENT CONTROLS
Handbrake control
37
98992-1R2
Ensure :
- the cables slide correctly,
- the handbrake levers (B) are in the correct
position against the brake shoes.
Progressively tighten