warning ISUZU TROOPER 1995 Manual PDF

rw
0.85Y
----------------~o~.s~rw~~~-------------l ~13r---------~o-~s~rw~~~--------~
.,
., d
., le '"'
BOOY-LH II
GENERATOR
0.85Y
0.85Y
3W
RELAY;
CHASSIS ELECTRICAL 8-41
SHIFT LOCK CONTROLLER (5) (TO PAGE 8-2021
WARNING LIGHTS (METER) (TO PAGE 8-291 I
5W
HEATER & AIR CONOmONING
~
C-19 C-20 25A 10AAIC SLOWER
~N !~ b(ll ~ol ;~ cr:!l :::><0 ~t :f ~g (g

8 - 1 06 CHASSIS ELECTRICAL
TURN SIGNAL LIGHT, HAZARD WARNING LIGHT,
CORNERING LIGHT,
BACKUP LIGHT AND HORN
GENERAL DESCRIPTION
The circuit consists of the starter switch, lighting switch, turn signal/cornering switch (combination witch),
turn signal light, cornering light, hazard warning switch, flasher unit, mode switch (A/T), backup light switch,
backup light, horn switch and horn.
When
turning on the respective switches with the starter switch on, the turn signal light and the back p light
will operate. When the turn signal light is flashing, the indicator light in the meter also starts flash in .
When the hazard
warning switch is turned on, the current flows to the flasher unit through the hazard
warning switch to cause the hazard warning light to flash, independent of the position of the starter switch.
At the same time, the indicator lights in the meter also start flashing.
When the
turn signal lever is set in either the left or right direction while the headlight is on, the co nering
switch incorporated
into the combination switch is activated to illuminate the appropriate cornering I ght.
When the horn switch is turned on, (independent
of the position of the starter switch) the relay is acti ated to
sound the horn.
OPERATION OF TURN SIGNAL AND CORNERING LIGHT CIRCUIT
Turn signal and cornering light
CORNERING RELAY
TURN
SIGNAL
/CORNERING FUSE
F-4
~+---------.
Ll G
HT SW L......f-'-=-~--l
STARTER SW
HAZARD
WARNING
sw
NOTE: Arrow marks " ~ " indicate the direction of current
Fig. 8-135
Hazard warning light
D
BATTERY(+)
HAZARD~ WARNING L.f-~'-'----f--' sw
lB
TURN SIGNAL LIGHT
(FLASH)
:z: _J 2: a: :::J 1-
li}
:z: a: 2: a: :::J 1-
~
METER (FLASH)
•

-n 10' 00 I .... w 0>
(
RELAY:
CORNERING LIGHT
DIODE

RELAY;HORN
\
RELAY
& FUSE
BOX'·.,,
(FL-1, FL-2,
F-31
~.
"",
BATTERY
'
FRT
TURN
SIGNAL,
HAZARD.
WARNING LIGHT
(RH) /
CORNERING LIGHT
(RH) C-31 HORN (HIGH)
( TURN
SIGNAL,
HAZARED
WARNING
INDICATOR LIGHT
(METER)
(
COMBINATION
SW
HAZARD
WARN
IN~
LIGHT
SW

FRT TURN
SIGNAL,
HAZARD
WARNING
LIGHT
(LH)
CORNERING LIGHT
(LH)
LIGHTING
SW
TURN
SIGNAL LIGHT,
/~l/
~/
CORNERING LIGHT SW. RR
TURN
SIGNAL,
HAZARD
WARNING LIGHT (LHI
=·
BACKUP
B-53
LIGHT(LH) "R-7 TRAILER HARNESS
CONNECTOR
FLASHER
UNIT
FUSE
BOX (C-3)
BACKUP LIGHT SW, (MfTI
)g ~ (/) r-0 (") ~ 0
2
(") ::c )> en
en en m r­m (") -i :lJ (") )> r­QI) I ..a 0 .....

CHASSIS ELECTRICAL 8 -111
DIAGNOSIS
QUICK CHART FOR CHECK POINTS
1. Turn signal light, hazard warning light, and cornering light
~·
Fuse
Turn Ha-Turn Cornering Cornering Cable Flasher C-3 F-3 cornering
zard
unit signal light light harn-
e (15A)
(15A)
sw
sw bulb bulb relay ess
1-1 Turn signal light does not 0
0 0 0 0
flash. (1) (4) (3) (2) (5)
1-2 Turn
signal light flashes 0 0
too quickly. (1) (2)
1-3 Both
cornering lights 0
0 0
0
inoperative. (1)
(4) (3) (2)
1-4 Cornering light on the left 0 0 0
(or
right) side inoperative. (2) (1) (3)
1-5 Cornering light remains on. 0 (1)
NOTE: Figure in parenthesis"{ )"indicates the order of inspection.
2. Backup light, horn
~·
Fuse
Backup Backup
Horn Horn Cable C-3 F-3 light SW/ light Horn switch relay
harness
e {15A) {15A) modeSW bulb
2-1 Both
backup lights inoperative. 0 0 0 (1) {3) {2)
2-2 Backup light on
the left (or right) 0 0
side do not light up {1) (2)
2-3 Backup lights remain on. b {1)
2-4 Horns do not sound. 0 0
0
0 0 {1) (4) {5) {2) (3)
2-5 Horns do not shut off. 0 0 0 {2) (1) (3)
NOTE: Figure
in parenthesis "{ )" indicates the order of inspection.

8-112 CHASSIS ELECTRICAL
1-1 TURN SIGNAL LIGHT DOES NOT FLASH
~ ..
I • IS FUSE C-3 (15A) NORMAL?
I
YES
I NO I
I
• IS THE FLASHER UNIT NORMAL? I REPLACE THE FUSE I
I
YES
I NO I
I
• DISCONNECT THE CONNECTORS OF THE HAZARD REPLACE
THE FLASHER UNIT
WARNING SWITCH
• TURN THE STARTER SWITCH ON .
• IS THERE A BATTERY VOLTAGE APPLIED BETWEEN THE
HAZARD WARNING SWITCH HARNESS SIDE CONNECTOR 8 WJ] AND THE GROUND?
I
YES
I NO I
I
• WITH THE HAZARD WARNING SWITCH TURNED OFF, IS REPAIR A POOR CONNECTION AT THE CONNEC ORS THERE CONTINUITY BETWEEN
THE SWITCH CONNEC-OR AN OPEN CIRCUIT BETWEEN THE FUSE C-3 ( SA) ~ TORS 7 [Iill AND 8 WJ] 7 8!ITIJ.
I
YES
J NO I
I
• DISCONNECT THE CONNECTORS OF THE FLASHER UNIT • REPAIR OR REPLACE THE SWITCH I • IS THERE A BATTERY VOLTAGE APPLIED BETWEEN THE FLASHER UNIT HARNESS SIDE CONNECTOR 1 IB-531 AND THE GROUND?
I
YES
I NO I
I
• IS IB-191 GROUNDED SECURELY? I REPAIR A POOR CONNECTION AT THE CONNEC ORS
OR AN OPEN CIRCUIT BETWEEN THE HARNESS SIDE
CONNECTORS 7 WJ] -1IB-53I.
I
YES
I NO I
I
• IS THERE CONTINUITY BETWEEN THE HARNESS SIDE GROUNDED IT SECURELY I CONNECTORS 3IB-s3l -IB-191 7
~
I
YES
I NO I
I I
CONTINUED ON THE FOLLOWING PAGE CONTINUED ON THE FOLLOWING PAGE
•

TURN SIGNAL LIGHT BULB
FRONT SIDE (FIG. 8-141)
Fig. 8-141
B REMOVAL
Preparation: Disconnect the battery ground cable.
1. Front combination light
• Remove the screw at the upper portion of the
light bracket, and remove the bracket from
the fender.
2. Bulb
• Remove the turn signal light socket by
turning it counterclockwise.
• Remove the bulb by turning it counter­
clockwise
while pushing it at the same time.
B INSTALLATION
To install, follow the removal steps in the reverse
order.
REAR SIDE (FIG. 8-142)
~ Fig. 8-142
B REMOVAL
Preparation: Disconnect the battery ground cable.
CHASSIS ELECTRICAL 8-121
1. Rear combination light
• Remove the three screws and release the lock
at
two positions.
2. Turn signal light socket/bulb
• Remove the socket by turning it counter­
clockwise.
3. Bulb
• Remove the bulb by turning it counter­
clockwise
while pushing it at the same time.
B INSTALLATION
To install, follow the removal steps in the reverse
order.
CORNERING LIGHT BULB
Fig. 8-143
EJ REMOVAL (FIG. 8-143)
Preparation: Disconnect the battery ground cable.
1. Front combination light
• Remove the screws at the upper portion of
the light bracket, and remove the bracket
from the fender.
3. Bulb
• Remove the cornering light bulb socket by
turning it counterclockwise.
• Remove the bulb by turning it counter­
clockwise while pushing it at the same time.
E) INSTALLATION
To install, follow the removal steps in the reverse
order.
HAZARD WARNING SWITCH
~ INSPECTION
rfll Check the continuity between the terminals of
~ the hazard warning switch. (Fig. 8-144)
Repair
or replace the switch when the result of
inspection is found abnormal.

8-122 CHASSIS ELECTRICAL
rn
~~:::1
ill I -
~I . 4 s 6 7 8 2 1 3 n
ON o--o-f-0 0 -o
~ OFF o--o
Fig. 8-144
B REMOVAL (FIG. 8-145)
Preparation: Disconnect the battery ground cable.
5. Hazard warning switch 4. Instrument panel
cluster assembly
I
I
3. Instrument / panel driver lower cover ,
This illustration is based on re-ar defogger SW removal.
Fig, 8-145
'(
1. Front console assembly
2. Lower cluster assembly
3. Instrument panel driver lower cover
4. Instrument panel cluster assembly
• Refer to FOG LIGHT SWITCH remov I steps
in this section.
5. Hazard warning switch
• To remove the switch, pushing the lo k from
the back side of the cluster assembly.
B INSTALLATION
To install, follow the removal steps in the everse
order, noting the
following point
1. Push in the switch with your fingers until t locks
securely.
FLASHER UNIT
~ INSPECTION
When a SSW bulb is connected to the u it side
terminals No. 1(L) and 3(E) while connecti g the
battery
(+) terminal to terminal No. 1(8), nd the
battery (-)
terminal to terminal No. 3(E), d es the
bulb light on and off? (Fig. 8-146)
~
•

8-128 CHASSIS ELECTRICAL
DOME LIGHT, LUGGAGE ROOM LIGHT, COURTESY LIGHT,
MAP LIGHT, SEAT BELT SWITCH AND WARNING BUZZER
GENERAL DESCRIPTION
This circuit consists of the starter switch, door switch, dome light, luggage room light, courtesy lig t, map
light, seat belt switch, key remind switch and warning buzzer.
The dome
light lights up when any one of doors except the tailgate is opened with the switch set at t e door
mode. (Vehicles with a built-in timer do not have door mode.) !
The courtesy lights for the front doors are controlled by a circuit different from the one which cont ols the
courtesy
lights for the rear doors. When a door is opened, the lights on both sides in either front or r ar seat
light up.
The
luggage room light illuminates by opening the tailgate when the switch is set at the door mode.
The
map light illuminates by turning the switch on.
All these lights light up by turning on respective switches regardless of the position of the starter swi ch key.
The
warning buzzer sounds to remind the driver of seat belt use, leaving the key in the starter sv.. tch, or
headlights were left on.
OPERATION OF THE CIRCUIT
BATIERY (+) _....,.=>..:.__ _________ =>~---------lij
l} :X: :X: ...J a: ~ ~ :X: :X: Q .....__ (.!) ...J :J
~~ ®~ II: li: :::> r----:::> 0 0 u u a: a:
a: a:
z Q r---t----,
~ Go (.!) :J w ON OFF 0 0
~ DOOR 0 '-----+------'
~----------~~~~~~~~lr-l ____________ ,_b __ +-~~~-'--~'---,~ II...... 111"""11 Ill"""' J
-:..._ -=-
RRDOORSW RRDOORSW -LH -RH
DIODE DIODE
-=­
FRTDOOR SW -RH
NOTE: Arrow marks u =:> H indicate the direction of current
Fig. 8-158
FRTDOOR W -LH (ON)
•

, ce· co I .... U1 co
(
RR
DOOR
SW
(RH)
, '-..__
RR
COURTESY LIGHT
(RH)
, ,
~
MAP
LIGHT~
FRT
DOOR
SW
(RH)
,
~,
~
,·

"·,.
FRT
COURTESY LIGHT (RH),
\\,
:~~ /,
' ;. >,I
H-21
(\
/~~

\,
SEAT
BELT,
KEY
&LIGHT
B-1,
REMIND BUZZER
~
""
~
H-12,""
RELAY & FUSE
BOX,
~
14
',,
(FL-1, FL-2)
'~
'
BATIERY
FUSE
BOX IC-10, C-16)
( DOME
LIGHT
/ 1 LUGGAGE
ROOM
LIGHT
1-9 SEATBELTWARNING
LIGHT
, TAILGATE
SW
/
RR
DOOR
SW(LH)
I(Y.£!
= /
I RR
COURTESY
LIGHT(LH)
~11
) I
FRT
DOOR
sw.
(LH)
-
I.
B-22
FRT
COURTESY LIGHT
(LH)
KEY
REMIND SW,
(STARTER
SW)
SEAT BELT
SW
(LH)
(
~ :lJ ~ r-0 0 ~ 0 2
0 :c 1:i en 0 m I""' m 0 -t ::0 cs )> I""' co I ...a N CD

, co CX) . ... Ol ...
( --.. ..
.. 0 0 0 ~
~
0 <
!:l
,;,
,;,
"'
X
,
------------------------------~
. :g :~ ,c •"' ,x . ... :~ ·-•!: om :2!
--------------------------------·
FRT
DOOR
SW-RH
O.SGR/W
2B
O.SB
O.SB/W
~ C> ~
O.SGR/W
( ,,o.J-.r.~ FRT COURTESY
UGHT-LH
FRT
COURTESY
UGHT-RH
O.SR/W
O.SR!W
RELAV;TAILI•I ITO PAGE
8-781
KEY
REMIND
SW
CST ARTER
SW1
O.SR/W O.SR/W
O.SR/W
O.SR/W O.SlJY
8 !:
0 ., "'[;] ~ .;. ,,
mf"Yl ~liJ•Ik-
lb I ill
ill?j
~~., !~
~ :~ I h
.. !!' "'
II
O.SlJY
II~ I
O.SLJV
I
~ 0
SEAT
BELT
WARNING
LIGHT
(
(") -::0 (") c =i c 5> C) ::0 )> s I CJ) :I: 0 ~ ~ :I: m
m r-to )> CJ) m I I I
() :::t )> en
en (i) m r-m () -1 :c 0 )> r-QO I ..a w ..a